Sakrete B650958 User Manual

Sakrete Roof Tile Mortar; Sakret e Glass Block Mortar; Sakr et e Trowel Grade Leveler

& Underlayment; Sakrete Sand Mix; Sakrete Stoneworks Mix; Sakrete

Stoneworks Stone Veener Mortar D ry Stack (Gray); Sakrete St oneworks Stone Veener Mortar Dry Stack (Bu ff)

Safety Data Sheet

according to Date of issue

11/13/2015

EN (English)

Page 1

Product form

Mixture

Product name

Sakrete Roof Tile Mortar Sakrete Glass Block Mortar Sakrete Sakrete San Sakrete Stoneworks Mix Sakrete Stoneworks Stone Veener Mortar Dry Stack Sakrete Stoneworks Stone Veener Mortar Dry Stack

Use of the substance/mixture

Various.

Emergency number

CHEMTREC (800) 424-9300 CHEMTREC International +1

Acute toxicity 4 (Oral)

Skin Irritation 2

Serious Eye Damage 1

Skin Sensitization 1

Carcinogenicity 1A

Specific Target Organ Toxicity After Single Exposure 3

Specific Target Organ Toxicity After Repeated Exposure 1

Hazard pictograms (GHS-US)

Signal word (GHS-US)

Danger

Hazard statements (GHS-US)

Harmful if swallowed. Causes skin irritation. Causes serious eye damage. May cause an allergic skin reaction through prolonged or repeated exposure.

Precautionary statements (GHS-US)

Wash hands thoroughly after handling. Do not eat, drink or smoke when using this product. Contaminated work clothing instructions before use understood outdoors or in a well poison center/doctor. clothing and wash it before reuse inhaled center/doctor if you feel unwell. Remove contact lenses, if present and easy to do. Continue rinsing center/doctor. place. Keep containe accordance with all local, regional, national and international regulations.

SECTION 1: Identification of the substance/mixture and of the company/undertaking

1.1. Product identifier

1.2. Relevant identified uses of the substance or mixture and uses advised against

1.3. Details of the supplier of the safety data sheet

the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012. : 02/14/2014 Revision date: 11/13/2015 Version: 1.0

Sakrete of North America 8201 Arrowridge Blvd. 28273 Charlotte, NC – USA T 866-725-7383

1.4. Emergency telephone number

Trowel Grade Leveler& Underlayment

d Mix

Gray Buff

SECTION 2: Hazards identification

2.1. Classification of the substance or mixture

(703) 527-3887 24 hr

GHS-US classification

2.2. Label elements GHS-US labelling

. May cause cancer. May cause respiratory irritation. Causes damage to lungs

must not be all owed out of the workplace. Obtain special

. Do not handle until all safety precautions have been read and

. Wear protective gloves/protective clothing/eye protection/face protection. Use only

-ventilated area. Do not breathe dust. If swallowed: Immediately call a Rinse mouth. If on skin: Wash with plenty of water. Take off cont aminat ed

. If skin irritation or rash occurs: Get medical advice/attention. If

: Remove person to fresh air and keep comfortable for breathing. Call a poison

If exposed or concerned: Get medical advice/attention. Store in a well-ventilated

r tightly closed. Store locked up. Dispose of contents and container in

If in eyes: Rinse cautiously with water for several minutes.

. Immediately call a poison

Sakrete Roof Tile Mortar; Sakrete Glass Block Mortar; Sakrete Trowel Grade Leveler & Underlayment

; Sakrete Sand Mix; Sakrete Stoneworks Mix; Sakrete Stoneworks Stone Veener

Mortar Dry Stack (Gris); Sakrete Stoneworks Stone Veener Mortar Dry Stack (Buff)

Safety Data Sheet

according to

11/13/2015

EN (English)

2/8

Other hazards not contributing to the

Not applicable.

Sakrete Glass Block Mortar; Sakrete Sand Mix: 11 %of the mixture consists of ingredient(s) of unknown acute toxicity.

Name

Product identifier

GHS-US classification

Quartz

14808-60-7

20 - 80

Acute Tox. 4 (Oral) STOT RE 1

Plaster of Paris

(CAS No) 26499-65-0

30 - 602

Not classified

Cement, portland, chemicals

(CAS No) 65997-15-1

10 - 30

Skin Irrit. 2

STOT SE 3

Calcium magnesium hydroxide (CaMg(OH)4)

39445-23-3

3 - 71

Skin Irrit. 2 STOT SE 3

Calcium magnesium hydroxide oxide (CaMg(OH)2O)

(CAS No) 58398-71-3

3 - 71

Skin Irrit. 2 STOT SE 3

Calcium oxide

(CAS No) 1305-78-8

1 - 5

Skin Irrit. 2 STOT SE 3

Calcium hydroxide

1305-62-0

1 - 51

Eye Dam. 1 Skin Corr. 1B

Calcium sulfate

(CAS No) 7778-18-9

1 - 5

Not classified

Limestone

(CAS No) 1317-65-3

1 - 5

Not classified

Iron oxide (Fe2O3)

(CAS No) 1309-37-1

1 - 53

Not classified

Magnesium oxide (MgO)

(CAS No) 1309-48-4

1 - 53

Not classified

Magnesium hydroxide

(CAS No) 1309-42-8

1 - 51

Not classified

Sakrete Glass Block Mortar

Sakrete Roof Tile Mortar; Sakrete Glass Block Mortar; Sakrete Trowel Grade Levele & Underlaymentr; Sakrete Sand Mix

The exact percentage (concentration) of composition has been withheld as a trade secret in accordance with paragraph (i) of §1910.1200.

First-aid measures after inhalation

If breathing is difficult, remove victim to fresh air and keep at rest in a position comfortable for breathing. Get medical advice/attention if you feel unwell.

First-aid measures after skin contact

In case of contact, immediately flush skin with plenty of water. Remove contaminated clothing and shoes. Wash clothing before reuse. Call a physician if irritation develops and persists.

First-aid measures after eye contact

In case of contact, immediately flush eyes with plenty of water for at least 15 minutes. If easy to do, remove contact lenses, if worn. Get medical attention immediately.

First-aid measures after ingestion

If swallowed, do NOT induce vomiting unless directed to do so by medical personnel. Never give anything by mouth to an unconscious person. Immediately call a POISON CENTER or doctor/physician.

Symptoms/injuries after inhalation

May cause respiratory tract irritation.

Symptoms/injuries after skin contact

Causes skin irritation. May cause burns in the presence of moisture. Skin contact during hydration may slowly develop sufficient heat that may cause severe burns possibly re permanent injury. Do not allow product to harden around any body part or allow continuous prolonged contact with skin. contact.

Symptoms/injuries after eye contact

Causes serious eye damage. May cause burns in the presence of moisture. Symptoms may include discomfort or pain, excess blinking and tear production, with possible redness and swelling.

2.3. Other hazards

classification

2.4. Unknown acute toxicity (GHS-US)

Sakrete Stoneworks Stone Veener Mortar Dry Stack (Gray): 17 % of the mixture consists of ingredient(s) of unknown acute toxicity. Sakrete Stoneworks Mix; Sakrete Stoneworks Stone Veener Mortar Dry Stack (Buff): 16 % of the mixture consists of ingredient(s) of unknown acute toxicity. Sakrete Roof Tile Mortar: 15 % of the mixture consists of ingredient(s) of unknown acute toxicity.

SECTION 3: Composition/information on ingredients

3.1. Substance

Not applicable

3.2. Mixture

the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012.

akrete Trowel Grade Leveler & Underlayment: 66 % of the mixture consists of ingredient(s) of unknown acute toxicity.

Sakrete Trowel Grade Leveler & Underlayment

SECTION 4: First aid measures

4.1. Description of first aid measures

(CAS No)

Carc. 1A

Eye Dam. 1 Skin Sens. 1

(CAS No)

Eye Dam. 1

(CAS No)

4.2. Most important symptoms and effects, both acute and delayed

Handling can cause dry skin. May cause sensitisation by skin

sulting in

Sakrete Roof Tile Mortar; Sakrete Glass Block Mortar; Sakrete Trowel Grade Leveler & Underlayment

; Sakrete Sand Mix; Sakrete Stoneworks Mix; Sakrete Stoneworks Stone Veener

Mortar Dry Stack (Gris); Sakrete Stoneworks Stone Veener Mortar Dry Stack (Buff)

Safety Data Sheet

according to

11/13/2015

EN (English)

3/8

Symptoms/injuries after ingestion

Harmful if swallowed. May cause stomach distress, nausea or vomiting.

Suitable extinguishing media

Treat for surrounding material.

Unsuitable extinguishing media

Not available.

Fire hazard

Products of combustion may include, and are not limited to: oxides of carbon.

Firefighting instructions

Keep upwind of fire. Wear full fire fighting turn-out gear (full Bunker gear) and respiratory protection (SCBA).

General measures

Use personal protection recommended in Section 8. Isolate the hazard area and deny entry to unnecessary and unprotected personnel.

For containment

Contain spill, then place in a suitable container. Do not flush to sewer or allow to enter waterways.

Methods for cleaning up

Vacuum or sweep material and place in a disposal container.

Precautions for safe handling

Do not swallow. Avoid contact with skin and eyes. Good housekeeping is important to prevent accumulation of dust. Avoid generating and breathing dust. The use of compressed air for cleaning clothing, equipment, etc, is not recommended. Handle and open container with care. When using

Hygiene measures

Launder contaminated clothing before reuse. Wash hands before eating, drinking, or smoking.

Storage conditions

Keep out of the reach of children. Store in dust-tight, dry, labelled containers. Keep container tightly closed when not in use. Avoid any dust buildup by frequent cleaning and suitable construction of the storage area. Do not store in an area equipped with emergency water sprinkler

Quartz (14808-60-7)

USA ACGIH

ACGIH TWA (mg/m³)

0.025 mg/m³

USA OSHA

OSHA PEL (TWA) (mg/m3)

(30)/(%SiO2 + 2) mg/m3 TWA, total du st (10)/(%SiO2 + 2) mg/m3 TWA, respirable fraction

Cement, portland, chemicals (65997-15-1)

USA ACGIH

ACGIH TWA (mg/m³)

1 mg/m³

USA OSHA

OSHA PEL (TWA) (mg/m³)

5 mg/m³

Calcium oxide (1305-78-8)

USA ACGIH

ACGIH TWA (mg/m³)

2 mg/m³

USA OSHA

OSHA PEL (TWA) (mg/m³)

5 mg/m³

Calcium hydroxide (1305-62-0)

USA ACGIH

ACGIH TWA (mg/m³)

5 mg/m³

4.3. Indication of any immediate medical attention and special treatment needed

Symptoms may not appear immediately. In case of accident or if you feel unwell, seek medical advice immediately (show the label or SDS where possible).

SECTION 5: Firefighting measures

5.1. Extinguishing media

5.2. Special hazards arising from the substance or mixture

5.3. Advice for firefighters

SECTION 6: Accidental release measures

6.1. Personal precautions, protective equipment and emergency procedures

the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012.

6.2. Methods and material for containment and cleaning up

Use appropriate Personal Protective Equipment (PPE).

6.3. Reference to other sections

No additional information available.

SECTION 7: Handling and storage

7.1. Precautions for safe handling

do not eat, drink or smoke.

7.2. Conditions for safe storage, including any incompatibilities

7.3. Specific end use(s)

No additional information available.

SECTION 8: Exposure controls/personal protection

8.1. Control parameters

(250)/(%SiO2 + 5) mppcf TWA, respirable fraction

+ 5 hidden pages