Sakrete Maximizer
Safety Data Sheet
according to
the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012.
Date of issue
Product form
:
Mixture
Product name.
:
Sakrete Maximizer
Use of the substance/mixture
:
Various.
Emergency number
:
CHEMTREC (800) 424-9300
CH
Acute toxicity 4 (Oral)
Skin irritation 2
Serious eye damage 1
Skin sensitization 1
Carcinogenicity 1A
Specific target organ toxicity - single exposure 3
Specific target organ toxicity - repeated exposure 1
Hazard pictograms (GHS-US)
:
Signal word (GHS-US)
:
Danger
Hazard statements (GHS-US)
:
Harmful if swallowed. Causes skin irritation. Causes serious eye damage. May cause an allergic
skin reaction. May cause cancer. May cause respiratory irritation. Causes damage to organs
through prolonged or repeated exposure.
Precautionary statements (GHS-US)
:
Do not eat, drink or smoke when using this product. Wash hands thoroughly after handling.
Contaminated work clothing must not be allowed out of the workplace. Obtain special
instructions before use. Do not handle until all safety precaut
understood. Wear protective gloves/protective clothing/eye protection/face protection. Use only
outdoors or in a well
poison center/doctor. Rinse mouth. If in ey
Remove contact lenses, if present and easy to do. Continue rinsing. Immediately call a poison
center/doctor. If on skin: Wash with plenty of water. Take off contaminated clothing and wash it
before reuse
person to fresh air and keep comfortable for breathing. Call a poison center/doctor if you feel
unwell.
of contents and container in accordance with all local, regional, national and international
regulations.
Other hazards not contributing to the
:
Not applicable.
22 % of the mixture consists of ingredient(s) of unknown acute toxicity.
SECTION 1: Identification of the substance/mixture and of the company/undertaking
1.1. Product identifier
1.2. Relevant identified uses of the substance or mixture and uses advised against
1.3. Details of the supplier of the safety data sheet
Sakrete of North America
8201 Arrowridge Blvd.
28273 Charlotte, NC - USA
T 866-725-7383
1.4. Emergency telephone number
: 07/17/2014 Supersedes: 07/03/2013 Version: 1.0
SECTION 2: Hazards identification
2.1. Classification of the substance or mixture GHS-US classification
2.2. Label elements GHS-US labelling
EMTREC International +1 (703) 527-3887 24 hr
GHS05
GHS07
GHS08
ions have been read and
-ventilated area. Do not breathe dust. If swallowed: Immediately call a
. If skin irritation or rash occurs: Get medical advice/attention. If inhaled: Remove
Store locked up. Store in a well-ventilated place. Keep container tightly closed. Dispose
2.3. Other hazards
classification
2.4. Unknown acute toxicity (GHS US)
SECTION 3: Composition/information on ingredients
3.1. Substances
Not applicable.
3.2. Mixture
07/17/2014 EN (English)
es: Rinse cautiously with water for several minutes.
Page 1
Sakrete Maximizer
Safety Dat
a Sheet
according to
Name
Product identifier
%
GHS-US classification
Quartz
14808-60-7
30 - 60
Carc. 1A, H350
STOT RE 1, H372
Cement, portland, chemicals
(CAS No) 65997-15-1
15 - 40
Skin Irrit. 2, H315
STOT SE 3, H335
Calcium oxide
(CAS No) 1305-78-8
1 - 5
Acute Tox. 4 (Oral), H302
STOT SE 3, H335
The exact percentage (concentration) of composition has been withheld as a trade secret in accordance with paragraph (i) of §1910.1200.
First-aid measures after inhalati on
:
If breathing is difficult, remove victim to fresh air and keep at rest in a position comfortable for
breathing. Get medical advice/attention if you feel unwell.
First-aid measures after skin contact
:
In case of contact, immediately flush skin with plenty of water. Remove contaminated clothing
and shoes. Wash clothing before reuse. Call a physician if irritation develops and persists.
First-aid measures after eye contact
:
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes. If easy to
do, remove contact lenses, if worn. Get medical attention immediately.
First-aid measures after ingestion
:
If swallowed, do NOT induce vomiting unless directed to do so by medical personnel. Never give
anything by mout
Symptoms/injuries after inhalation
:
May cause respiratory irritation.
Symptoms/injuries after skin contact
:
Causes skin irritation. May cause burns in the presence of moisture. Skin contact during
hydration may slowly develop sufficient heat that may cause severe burns possibly
permanent injury.
p
contact.
Symptoms/injuries after eye contact
:
Causes serious eye damage. May cause burns in the presence of moisture. Symptoms may
include discomfort or pain, excess
swelling.
Symptoms/injuries after ingestion
:
Harmful if swallowed. May cause stomach distress, nausea or vomiting.
Suitable extinguishing media
:
Treat for surrounding material.
Unsuitable extinguishing media
:
None known.
Fire hazard
:
Products of combustion may include, and are not limited to: oxides of carbon.
Reactivity
:
No dangerous reaction known under conditions of normal use.
Protection during firefighting
:
Keep upwind of fire. Wear full fire fighting turn-out gear (full Bunker gear) and respiratory
protection (SCBA).
General measures
:
Use personal protection recommended in Section 8. Isolate the hazard area and deny entry to
unnecessary and unprotected personnel.
For containment
:
Contain spill then place in a suitable container. Do not flush to sewer or allow to enter
waterways.
Methods for cleaning up
:
Vacuum or sweep material and place in a disposal container.
SECTION 4: First aid measures
4.1. Description of first aid measures
the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012.
(CAS No)
Eye Dam. 1, H318
Skin Sens. 1, H317
Skin Irrit. 2, H315
Eye Dam. 1, H318
4.2. Most important symptoms and effects, both acute and delayed
h to an unconscious person. Get medical advice/attention.
resulting in
Do not allow product to harden around any body part or allow continuous,
rolonged contact with skin. Handling can cause dry skin. May cause sensitisation by skin
blinking and tear production, with possible redness and
4.3. Indication of any immediate medical attention and special treatment needed
Symptoms may not appear immediately. In case of accident or if you feel unwell, seek medical advice immediately (show the label or SDS where
possible).
SECTION 5: Firefighting measures
5.1. Extinguishing media
5.2. Special hazards arising from the substance or mixture
5.3. Advice for firefighters
SECTION 6: Accidental release measures
6.1. Personal precautions, protective equipment and emergency procedures
6.2. Methods and material for containment and cleaning up
Use appropriate Personal Protective Equipment (PPE).
6.3. Reference to other sections
No additional information available.
07/03/2013 EN (English)
2/6
Sakrete Maximizer
Safety Dat
a Sheet
according to
Precautions for safe handling
:
Avoid contact with skin and eyes. Do not swallow. Good housekeeping is important to prevent
accumulation of dust. Avoid generating and breathing dust. The use of compressed air for
cleaning clothing, equipment, etc, is not recommended. Handle and open container with care.
Hygiene measures
:
Wash hands before eating, drinking, or smoking. Launder contaminated clothing before reuse.
Storage conditions
:
Keep out of the reach of children. Keep container tightly closed when not in use. Store in dusttight, dry, labelled containers. Avoid any dust buildup by frequent cleaning and suitable
construction of the storage area. Do not store in an area equipped with emergency water
sprinklers.
Incompatible materials
:
Wet cement is alkaline and incompatible with acid, ammonium salts and aluminum metal.
Quartz (14808-60-7)
USA ACGIH
ACGIH TWA (mg/m³)
0.025 mg/m³
Cement, portland, chemicals (65997-15-1)
USA ACGIH
ACGIH TWA (mg/m³)
1 mg/m³
Calcium oxide (1305-78-8)
USA ACGIH
ACGIH TWA (mg/m³)
2 mg/m³
Appropriate engineering controls
:
Use ventilation adequate to keep exposures (airborne levels of dust, fume, vapor, etc.) below
recommended exposure limits.
Hand protection
:
Wear suitable waterproof gloves.
Eye protection
:
Wear approved eye protection (properly fitted dust- or splash-proof chemical safety goggles) and
face protection (face shield).
Skin and body protection
:
Wear suitable waterproof protective clothing.
Respiratory protection
:
A NIOSH approved dust mask or filtering facepiece is recommended in poorly ventilated areas or
when permissible exposure limits may be exceeded. Respirators should be selected by and used
under the direction of a trained health and safety professional following requirements found in
OSHA’s respirator standard (29 CFR 1910.134) and ANSI’s standard for respiratory protection
(Z88.2).
Environmental exposure controls
:
Maintain levels below Community environmental protection thresholds.
Other information
:
Do not eat, smoke or drink where material is handled, processed or stored. Wash hands carefully
before eating or smoking. Handle according to established industrial hygiene a
practices.
Physical state
:
Solid.
Appearance
:
Powder.
Colour
:
Various.
Odour
:
Characteristic.
Odour threshold
:
No data available.
pH : 12 - 13
Relative evaporation rate (butylacetate=1)
:
No data available.
Melting point
:
No data available.
Freezing point
:
No data available.
Boiling point
:
No data available.
Flash point
:
No data available.
Self ignition temperature
:
No data available.
Decomposition temperature
:
No data available.
Flammability (solid, gas)
:
Not Flammable.
Vapour pressure
:
No data available.
Relative vapour density at 20 °C
:
No data available.
Relative density
:
No data available.
SECTION 7: Handling and storage
7.1. Precautions for safe handling
7.2. Conditions for safe storage, including any incompatibilities
7.3. Specific end use(s)
Not available.
SECTION 8: Exposure controls/personal protection
8.1. Control parameters
the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012.
8.2. Exposure controls
SECTION 9: Physical and chemical properties
9.1. Information on basic physical and chemical properties
nd safety
07/03/2013 EN (English)
3/6
Sakrete Maximizer
Safety Dat
a Sheet
according to
Solubility
:
No data available.
Log Pow
:
No data available.
Log Kow
:
No data available.
Viscosity, kinematic
:
No data available.
Viscosity, dynamic
:
No data available.
Explosive properties
:
No data available.
Oxidising properties
:
No data available.
Explosive limits
:
No data available.
Acute toxicity
:
Harmful if swallowed.
Quartz (14808-60-7)
LD50 oral rat
500 mg/kg
Calcium oxide (1305-78-8)
LD50 oral rat
500 mg/kg
Skin corrosion/irritation
:
Causes skin irritation.
Serious eye damage/irritation
:
Causes serious eye damage.
Respiratory or skin sensitisation
:
May cause an allergic skin reaction.
Germ cell mutagenicity
:
Based on available data, the classification criteria are not met.
Carcinogenicity
:
May cause cancer.
Quartz (14808-60-7)
IARC group
1
National Toxicity Program (NTP)
2
Reproductive toxicity
:
Based on available data, the classification criteria are not met.
Specific target organ toxicity (single exposure)
:
May cause respiratory irritation.
Specific target organ toxicity (repeated
:
Causes damage to organs through prolonged or repeated exposure. (Respirable crystalline silica
in the form of quartz or cristobalite from occupational sources is listed by the International
Agency for Research on Cancer (IARC) and Nat
carcinogen. Prolonged exposure to respirable crystalline silica has been known to cause
silicosis, a lung disease, which may be disabling. While there may be a factor of individual
susceptibility to a given exposure
severity of the disease is clearly related to the amount of dust exposure and the length of time
(usually years) of exposure.)
Aspiration hazard
:
Based on available data, the classification criteria are not met.
Potential Adverse human health effects and
:
Not available.
Symptoms/injuries after inhalation
:
May cause respiratory irritation.
9.2. Other information
No additional information available.
SECTION 10: Stability and reactivity
10.1. Reactivity
No dangerous reaction known under conditions of normal use.
10.2. Chemical stability
Stable under normal storage conditions. Keep dry in storage.
10.3. Possibility of hazardous reactions
No dangerous reaction known under conditions of normal use.
10.4. Conditions to avoid
Incompatible materials. Moisture.
10.5. Incompatible mater ials
Wet cement is alkaline and incompatible with acid, ammonium salts and aluminum metal.
10.6. Hazardous decomposition products
May include, and are not limited to: oxides of carbon.
the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012.
SECTION 11: Toxicological information
11.1. Information on toxicological effects
exposure)
ional Toxicology Program (NTP) as a lung
to respirable silica dust, the risk of contracting silicosis and the
symptoms
07/03/2013 EN (English)
4/6
Sakrete Maximizer
Safety Dat
a Sheet
according to
Symptoms/injuries after skin contact
:
Causes skin irritation. May cause burns in the presence of moisture. Skin contact during
hydration may slowly develop sufficient heat that may cause severe burns possibly
permanent injury.
pr
contact.
Symptoms/injuries after eye contact
:
Causes serious eye damage. May cause burns in the presence of moisture. Symptoms may
include discomfort or pain, excess blinking and tear produ
swelling.
Symptoms/injuries after ingestion
:
Harmful if swallowed. May cause stomach distress, nausea or vomiting.
Ecology - general
:
No ecological consideration when used according to directions. Normal dilution of this product to
drains, sewers, septic systems and treatment plants is not considered environmentally harmful.
Sakrete Maximizer
Persistence and degradability
No data available.
Sakrete Maximizer
Bioaccumulative potential
No data available.
Sakrete Maximizer
Ecology - soil
No data available.
Other adverse effects
:
No data available.
Waste disposal recommendations
:
This material must be disposed of in accordance with all local, state, provincial, and federal
regulations.
Other information
:
No supplementary information available.
Special transport precautions
:
Do not handle until all safety precautions have been read and understood.
Quartz (14808-60-7)
Listed on the United States TSCA (Toxic Substances Control Act) inventory
Cement, portland, chemicals (65997-15-1)
Listed on the United States TSCA (Toxic Substances Control Act) inventory
Calcium oxide (1305-78-8)
Listed on the United States TSCA (Toxic Substances Control Act) inventory
Sakrete Maximizer
State or local regulations
This product contains Crystalline Silica, Quartz and may also contain trace amounts of
the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012.
SECTION 12: Ecological information
12.1. Toxicity
12.2. Persistence and degradability
12.3. Bioaccumulative potential
12.4. Mobility in soil
12.5. Other adverse effects
Do not allow product to harden around any body part or allow continuous,
resulting in
olonged contact with skin. Handling can cause dry skin. May cause sensitisation by skin
ction, with possible redness and
SECTION 13: Disposal considerations
13.1. Waste treatment methods
SECTION 14: Transport information
In accordance with DOT
14.1. UN number
Not applicable.
14.2. UN proper shipping name
Not applicable.
14.3. Additional information
SECTION 15: Regulatory information
15.1. US Federal regulations
15.3. US State regulations
other chemicals known to the State of California to cause cancer, birth defects or other
07/03/2013 EN (English)
reproductive harm.
5/6
Sakrete Maximizer
Safety Dat
a Sheet
according to
Quartz (14808-60-7)
U.S. - California -
U.S. - California -
U.S. - California -
U.S. - California -
No significance risk level
Yes
No
No
No
No
Data sources
:
SDS prepared pursuant to the Hazard Communication Standard (CFR29 1910.1200) HazCom
2012.
NFPA health hazard
:
3
NFPA fire hazard
:
1
NFPA reactivity
:
0
the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012.
Proposition 65 Carcinogens List
SECTION 16: Other information
Proposition 65 Developmental Toxicity
Proposition 65 Reproductive Toxicity Female
Proposition 65 Reproductive Toxicity Male
(NSRL)
This information is based on our current knowledge and is intended to describe the product for the purposes of health, safety and environmental requirements only. It should not therefore be
construed as guaranteeing any specific property of the product
07/03/2013 EN (English)
6/6
Loading...