Page 1
Sakrete Fast Setting Cement Patcher/Sakrete
Leak Stopper Hydraulic Cement (Gray)
Safety Data Sheet
SECTION 1: Identification of the substance/mixture and of the company/undertaking
1.1. Product identifier
Product form : Mixture
Product name : Sakrete Fast Setting Cement Patcher
1.2. Relevant identified uses of the substance or mixture and uses advised against
Use of the substance/mixture : Various.
1.3. Details of the supplier of the safety data sheet
Sakrete Of North America
8201 Arrowridge Bvd.
Charlotte, NC 28273 - USA
T 866-725-7383
1.4. Emergency telephone number
Emergency number : CHEMTREC (800) 424-9300
SECTION 2: Hazards identification
2.1. Classification of the substance or mixture
GHS-US classification
Skin Irritation 2
Serious Eye Damage 1
Carcinogenicity 1A
Specific Target Organ Toxicity After Single Exposure 3
Specific Target Organ Toxicity After Repeated Exposure 1
2.2. Label elements
GHS-US labelling
Hazard pictograms (GHS-US) :
according to the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012
Date of issue: 01/17/2014 Revision date: 09/08/2015 Version: 1.1
Sakrete Leak Stopper Hydraulic Cement (Gray)
CHEMTREC International +1 (703) 527-3887 24 hr
GHS05
GHS07
GHS08
Signal word (GHS-US) : Danger
Hazard statements (GHS-US) : Causes skin irritation. Causes serious eye damage. May cause cancer. May cause respiratory
irritation. Causes damage to lungs through prolonged or repeated exposure.
Precautionary statements (GHS-US) : Do not eat, drink or smoke when using this product. Wash hands thoroughly after handling.
Obtain special instructions before use. Do not handle until all safety precautions have been
read and understood. Wear protective gloves/protective clothing/eye protection/face protection.
Use only outdoors or in a well-ventilated area. Do not breathe dust. If exposed or concerned:
Get medical advice/attention. If in eyes: Rinse cautiously with water for several minutes.
Remove contact lenses, if present and easy to do. Continue rinsing. Immediately call a poison
center/doctor. If on skin: Wash with plenty of water. Take off contaminated clothing and wash it
before reuse. If skin irritation occurs: Get medical advice/attention. If inhaled: Remove person
to fresh air and keep comfortable for breathing. Call a poison center/doctor if you feel unwell.
Store locked up. Store in a well-ventilated place. Keep container tightly closed. Dispose of
contents and container in accordance with all local, regional, national and international
regulations.
2.3. Other hazards
Other hazards not contributing to the classification : Not applicable.
2.4. Unknown acute toxicity (GHS US)
Sakrete Leak Stopper Hydraulic Cement (Gray): 18% of the mixture consists of ingredient(s) of unknown acute toxicity.
Sakrete Fast Setting Cement Patcher: 10% of the mixture consists of ingredient(s) of unknown acute toxicity.
09/08/2015 EN (English)
Page 1
Page 2
Sakrete Fast Setting Cement Patcher/Sakrete Leak Stopper Hydraulic
1
Cement (Gray)
Safety Data Sheet
according to the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012
SECTION 3: Composition/information on ingredients
3.1. Substance
Not applicable.
3.2. Mixture
Name Product identifier %
Quartz (CAS No) 14808-60-7 ≤75
Cement, alumina, chemicals (CAS No) 65997-16-2 ≤302
Cement, portland, chemicals (CAS No) 65997-15-1 5 - 30
Calcium oxide (CAS No) 1305-78-8 ≤7
Sodium carbonate (CAS No) 497-19-8 ≤52
Iron oxide (CAS No) 1309-37-1 ≤5
Aluminum sulfate (CAS No) 10043-01-3 1.5 - 31
Aluminum oxide (CAS No) 1344-28-1 1.5 - 31
Magnesium oxide (CAS No) 1309-48-4 ≤3
Calcium hydroxide (CAS No) 1305-62-0 0.5 - 22
Calcium magnesium hydroxide oxide (CAS No) 58398-71-3 1.5 - 32
Calcium magnesium hydroxide (CAS No) 39445-23-3 1.5 - 32
Limestone (CAS No) 1317-65-3 ≤1.5
Gypsum (CAS No) 13397-24-5 ≤1.5
Calcium sulfate (CAS No) 7778-18-9 ≤1.5
Sakrete Fast Setting Cement Patcher
2
Sakrete Leak Stopper Hydraulic Cement
* The exact percentage (concentration) of composition has been withheld as a trade secret in accordance with paragraph (i) of §1910.1200.
SECTION 4: First aid measures
4.1. Description of first aid measures
First-aid measures after inhalation : If breathing is difficult, remove victim to fresh air and keep at rest in a position comfortable for
First-aid measures after skin contact : In case of contact, immediately flush skin with plenty of water. Remove contaminated clothing
First-aid measures after eye contact : In case of contact, immediately flush eyes with plenty of water for at least 15 minutes. If easy to
First-aid measures after ingestion : If swallowed, do NOT induce vomiting unless directed to do so by medical personnel. Never
4.2. Most important symptoms and effects, both acute and delayed
Symptoms/injuries after inhalation : May cause respiratory tract irritation.
Symptoms/injuries after skin contact : Causes skin irritation. May cause burns in the presence of moisture. Skin contact during
Symptoms/injuries after eye contact : Causes serious eye damage. May cause burns in the presence of moisture. Symptoms may
Symptoms/injuries after ingestion : May be harmful if swallowed. May cause stomach distress, nausea or vomiting.
4.3. Indication of any immediate medical attention and special treatment needed
Symptoms may not appear immediately. In case of accident or if you feel unwell, seek medical advice immediately (show the label or SDS where possible).
breathing. Get medical advice/attention if you feel unwell.
and shoes. Wash clothing before reuse. Call a physician if irritation develops and persists.
do, remove contact lenses, if worn. Get medical attention immediately.
give anything by mouth to an unconscious person. Immediately call a POISON CENTER or
doctor/physician.
hydration may slowly develop sufficient heat that may cause severe burns possibly resulting in
permanent injury. Do not allow product to harden around any body part or allow continuous,
prolonged contact with skin. Handling can cause dry skin.
include discomfort or pain, excess blinking and tear production, with possible redness and
swelling.
SECTION 5: Firefighting measures
5.1. Extinguishing media
Suitable extinguishing media : Treat for surrounding material.
Unsuitable extinguishing media : Not available.
5.2. Special hazards arising from the substance or mixture
Fire hazard : Products of combustion may include, and are not limited to: oxides of carbon.
09/08/2015 EN (English)
2/8
Page 3
Sakrete Fast Setting Cement Patcher/Sakrete Leak Stopper Hydraulic
A
Cement (Gray)
Safety Data Sheet
according to the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012
5.3. Advice for firefighters
Firefighting instructions : Keep upwind of fire. Wear full fire fighting turn-out gear (full Bunker gear) and respiratory
SECTION 6: Accidental release measures
6.1. Personal precautions, protective equipment and emergency procedures
General measures : Use personal protection recommended in Section 8. Isolate the hazard area and deny entry to
6.2. Methods and material for containment and cleaning up
For containment : Contain spill, then place in a suitable container. Do not flush to sewer or allow to enter
Methods for cleaning up : Vacuum or sweep material and place in a disposal container.
6.3. Reference to other sections
No additional information available.
SECTION 7: Handling and storage
7.1. Precautions for safe handling
Precautions for safe handling :
Hygiene measures : Launder contaminated clothing before reuse. Wash hands before eating, drinking, or smoking.
7.2. Conditions for safe storage, including any incompatibilities
Storage conditions : Keep out of the reach of children. Store in dust-tight, dry, labelled containers. Keep container
7.3. Specific end use(s)
No additional information available.
protection (SCBA).
unnecessary and unprotected personnel.
waterways. Use appropriate Personal Protective Equipment (PPE).
void contact with skin and eyes. Do not swallow. Avoid generating and breathing dust. Good
housekeeping is important to prevent accumulation of dust. The use of compressed air for
cleaning clothing, equipment, etc, is not recommended. Handle and open container with care.
When using do not eat, drink or smoke.
tightly closed when not in use. Avoid any dust buildup by frequent cleaning and suitable
construction of the storage area. Do not store in an area equipped with emergency water
sprinklers.
SECTION 8: Exposure controls/personal protection
8.1. Control parameters
Quartz (14808-60-7)
ACGIH ACGIH TWA (mg/m³) 0.025 mg/m³ (respirable fraction)
OSHA OSHA PEL (TWA) (mg/m3) (30)/(%SiO2 + 2) mg/m3 TWA, total dust
(250)/(%SiO
(10)/(%SiO
+ 5) mppcf TWA, respirable fraction
2
+ 2) mg/m3 TWA, respirable fraction
2
Cement, alumina, chemicals (65997-16-2)
ACGIH Not applicable
OSHA Not applicable
Cement, portland, chemicals (65997-15-1)
ACGIH ACGIH TWA (mg/m³) 1 mg/m³ (particulate matter containing no asbestos
and <1% crystalline silica, respirable fraction)
OSHA OSHA PEL (TWA) (mg/m³) 15 mg/m³ (total dust)
5 mg/m³ (respirable fraction)
50 mppcf (<1% Crystalline silica)
Calcium oxide (1305-78-8)
ACGIH ACGIH TWA (mg/m³) 2 mg/m³
OSHA OSHA PEL (TWA) (mg/m³) 5 mg/m³
Sodium carbonate (497-19-8)
ACGIH Not applicable
OSHA Not applicable
09/08/2015 EN (English)
3/8
Page 4
Sakrete Fast Setting Cement Patcher/Sakrete Leak Stopper Hydraulic
Cement (Gray)
Safety Data Sheet
according to the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012
Iron oxide (1309-37-1)
ACGIH ACGIH TWA (mg/m³) 5 mg/m³ (respirable fraction)
OSHA OSHA PEL (TWA) (mg/m³) 10 mg/m³ (fume)
Aluminum sulfate (10043-01-3)
ACGIH Not applicable
OSHA Not applicable
Aluminum oxide (1344-28-1)
ACGIH Not applicable
OSHA OSHA PEL (TWA) (mg/m³) 15 mg/m³ (total dust)
Magnesium oxide (1309-48-4)
ACGIH ACGIH TWA (mg/m³) 10 mg/m³ (inhalable fraction)
OSHA OSHA PEL (TWA) (mg/m³) 15 mg/m³ (fume, total particulate)
Calcium hydroxide (1305-62-0)
ACGIH ACGIH TWA (mg/m³) 5 mg/m³
OSHA OSHA PEL (TWA) (mg/m³) 15 mg/m³ (total dust)
Calcium magnesium hydroxide oxide (58398-71-3)
ACGIH Not applicable
OSHA Not applicable
Calcium magnesium hydroxide (39445-23-3)
ACGIH Not applicable
OSHA Not applicable
Limestone (1317-65-3)
ACGIH Not applicable
OSHA OSHA PEL (TWA) (mg/m³) 15 mg/m³ (total dust)
Gypsum (13397-24-5)
ACGIH ACGIH TWA (mg/m³) 10 mg/m³ (inhalable fraction)
OSHA OSHA PEL (TWA) (mg/m³) 15 mg/m³ (total dust)
Calcium sulfate (7778-18-9)
ACGIH ACGIH TWA (mg/m³) 10 mg/m³ (inhalable fraction)
OSHA OSHA PEL (TWA) (mg/m³) 15 mg/m³ (total dust)
8.2. Exposure controls
Appropriate engineering controls : Use ventilation adequate to keep exposures (airborne levels of dust, fume, vapor, etc.) below
recommended exposure limits.
Hand protection : Wear suitable waterproof gloves.
Eye protection : Wear approved eye protection (properly fitted dust- or splash-proof chemical safety goggles)
and face protection (face shield).
Skin and body protection : Wear suitable waterproof protective clothing.
15 mg/m³ (total dust)
5 mg/m³ (respirable fraction)
5 mg/m³ (respirable fraction)
5 mg/m³ (respirable fraction)
5 mg/m³ (respirable fraction)
5 mg/m³ (respirable fraction)
5 mg/m³ (respirable fraction)
09/08/2015 EN (English)
4/8
Page 5
Sakrete Fast Setting Cement Patcher/Sakrete Leak Stopper Hydraulic
Cement (Gray)
Safety Data Sheet
according to the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012
Respiratory protection : A NIOSH approved dust mask or filtering facepiece is recommended in poorly ventilated areas
Other information : Handle according to established industrial hygiene and safety practices. Do not eat, smoke or drink
SECTION 9: Physical and chemical properties
9.1. Information on basic physical and chemical properties
Physical state : Solid
Appearance : Powder
Colour : Various
Odour : Characteristic
Odour threshold : No data available
pH : 10 - 13
Melting point : No data available
Freezing point : No data available
Boiling point : No data available
Flash point : No data available
Relative evaporation rate (butylacetate=1) : No data available
Flammability (solid, gas) : Not Flammable
Explosive limits : No data available
Explosive properties : No data available
Oxidising properties : No data available
Vapour pressure : No data available
Relative density : No data available
Relative vapour density at 20 °C : No data available
Solubility : No data available
Partition coefficient: n-octanol/water : No data available
Auto-ignition temperature : No data available
Decomposition temperature : No data available
Viscosity : No data available
Viscosity, kinematic : No data available
Viscosity, dynamic : No data available
9.2. Other information
VOC content : 0%, Not applicable; 0 wt, Not applicable.
or when permissible exposure limits may be exceeded. Respirators should be selected by and
used under the direction of a trained health and safety professional following requirements
found in OSHA’s respirator standard (29 CFR 1910.134) and ANSI’s standard for respiratory
protection (Z88.2).
where material is handled, processed or stored. Wash hands carefully before eating or smoking.
SECTION 10: Stability and reactivity
10.1. Reactivity
No dangerous reaction known under conditions of normal use.
10.2. Chemical stability
Stable under normal storage conditions. Keep dry in storage.
10.3. Possibility of hazardous reactions
No dangerous reaction known under conditions of normal use.
10.4. Conditions to avoid
Incompatible materials. Moisture.
10.5. Incompatible materials
Wet cement is alkaline and incompatible with acid, ammonium salts and aluminum metal.
10.6. Hazardous decomposition products
May include, and are not limited to: oxides of carbon.
09/08/2015 EN (English)
5/8
Page 6
Sakrete Fast Setting Cement Patcher/Sakrete Leak Stopper Hydraulic
A
Cement (Gray)
Safety Data Sheet
according to the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012
SECTION 11: Toxicological information
11.1. Information on toxicological effects
Acute toxicity : Not classified.
Sakrete Fast Setting Cement Patcher/Sakrete Leak Stopper Hydraulic Cement (Gray)
LD50 oral rat > 2000 mg/kg
LD50 dermal rabbit No data available
LC50 inhalation rat No data available
Calcium oxide (1305-78-8)
LD50 oral rat > 2000 mg/kg
Sodium carbonate (497-19-8)
LD50 oral rat 4090 mg/kg
LC50 inhalation rat 2300 mg/m³/2h
Iron oxide (1309-37-1)
LD50 oral rat > 10000 mg/kg
Aluminum sulfate (10043-01-3)
LD50 oral rat 1930 mg/kg
Aluminum oxide (1344-28-1)
LD50 oral rat > 5000 mg/kg
Calcium hydroxide (1305-62-0)
LD50 oral rat 7340 mg/kg
Calcium sulfate (7778-18-9)
LD50 oral rat > 3000 mg/kg
Skin corrosion/irritation : Causes skin irritation.
Serious eye damage/irritation : Causes serious eye damage.
Respiratory or skin sensitisation : Based on available data, the classification criteria are not met.
Germ cell mutagenicity : Based on available data, the classification criteria are not met.
Carcinogenicity : May cause cancer.
Quartz (14808-60-7)
IARC group 1 - Carcinogenic to humans
National Toxicology Program (NTP) Status 2 - Known Human Carcinogens
Iron oxide (1309-37-1)
IARC group 3 - Not classifiable
Reproductive toxicity : Based on available data, the classification criteria are not met.
Specific target organ toxicity (single exposure) : May cause respiratory irritation.
Specific target organ toxicity (repeated exposure) : Causes damage to lungs through prolonged or repeated exposure. (Respirable crystalline silica
Aspiration hazard : Based on available data, the classification criteria are not met.
Symptoms/injuries after inhalation : May cause respiratory tract irritation.
Symptoms/injuries after skin contact : Causes skin irritation. May cause burns in the presence of moisture. Skin contact during
Symptoms/injuries after eye contact : Causes serious eye damage. May cause burns in the presence of moisture. Symptoms may
in the form of quartz or cristobalite from occupational sources is listed by the International
gency for Research on Cancer (IARC) and National Toxicology Program (NTP) as a lung
carcinogen. Prolonged exposure to respirable crystalline silica has been known to cause
silicosis, a lung disease, which may be disabling. While there may be a factor of individual
susceptibility to a given exposure to respirable silica dust, the risk of contracting silicosis and
the severity of the disease is clearly related to the amount of dust exposure and the length of
time (usually years) of exposure.)
hydration may slowly develop sufficient heat that may cause severe burns possibly resulting in
permanent injury. Do not allow product to harden around any body part or allow continuous,
prolonged contact with skin. Handling can cause dry skin.
include discomfort or pain, excess blinking and tear production, with possible redness and
swelling.
09/08/2015 EN (English)
6/8
Page 7
Sakrete Fast Setting Cement Patcher/Sakrete Leak Stopper Hydraulic
Cement (Gray)
Safety Data Sheet
according to the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012
Symptoms/injuries after ingestion : May be harmful if swallowed. May cause stomach distress, nausea or vomiting.
SECTION 12: Ecological information
12.1. Toxicity
Ecology - general : No ecological consideration when used according to directions. Normal dilution of this product to
12.2. Persistence and degradability
Sakrete Fast Setting Cement Patcher/Sakrete Leak Stopper Hydraulic Cement (Gray)
Persistence and degradability No data available.
12.3. Bioaccumulative potential
Sakrete Fast Setting Cement Patcher/Sakrete Leak Stopper Hydraulic Cement (Gray)
Bioaccumulative potential No data available.
12.4. Mobility in soil
Sakrete Fast Setting Cement Patcher/Sakrete Leak Stopper Hydraulic Cement (Gray)
Ecology - soil No data available.
12.5. Other adverse effects
Effect on the global warming : No known ecological damage caused by this product.
SECTION 13: Disposal considerations
13.1. Waste treatment methods
Waste disposal recommendations : This material must be disposed of in accordance with all local, state, provincial, and federal
drains, sewers, septic systems and treatment plants is not considered environmentally harmful.
regulations.
SECTION 14: Transport information
Department of Transportation (DOT)
In accordance with DOT.
Not regulated for transport.
Additional information
Other information : No supplementary information available.
SECTION 15: Regulatory information
15.1. US Federal regulations
All components of this product are listed, or excluded from listing, on the United States Environmental Protection Agency Toxic Substances
Control Act (TSCA) inventory except for:
Gypsum CAS No 13397-24-5
Aluminum oxide (1344-28-1)
Subject to reporting requirements of United States SARA Section 313
SARA Section 313 - Emission Reporting 1.0 % (fibrous forms)
15.2. US State regulations
Sakrete Fast Setting Cement Patcher/Sakrete Leak Stopper Hydraulic Cement (Gray)
State or local regulations This product contains Crystalline Silica, Quartz and may also contain other chemicals
SECTION 16: Other information
Date of issue : 01/17/2014
Revision date : 09/08/2015
Version 1.1
Data sources : SDS prepared pursuant to the Hazard Communication Standard (CFR29 1910.1200) HazCom
known to the State of California to cause cancer, birth defects or other reproductive
harm.
2012.
09/08/2015 EN (English)
7/8
Page 8
Sakrete Fast Setting Cement Patcher/Sakrete Leak Stopper Hydraulic
Cement (Gray)
Safety Data Sheet
according to the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012
NFPA health hazard : 3 - Short exposure could cause serious temporary or
NFPA fire hazard : 1 - Must be preheated before ignition can occur.
NFPA reactivity : 0 - Normally stable, even under fire exposure conditions,
residual injury even though prompt medical attention was
given.
and are not reactive with water.
Disclaimer: We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any kind. The information contained
in this document applies to this specific material as supplied. It may not be valid for this material if it is used in combination with any other materials. It is the user’s responsibility to satisfy oneself as to the
suitability and completeness of this information for the user’s own particular use.
09/08/2015 EN (English)
8/8
Loading...