Date Printed: 8/13/2014
Safety Data Sheet
* Trusted Quality Since 1921 *
www.rustoleum.com
1. Identification
Product Name: ENAMEL 5-GL GLOSS SAFETY BLUE Revision Date: 8/13/2014
Product Identifier: 925300 Supercedes Date: New SDS
Product Use/Class: Topcoat/Alkyd
Page 1 / 7
Supplier:
Preparer: Regulatory Department
Emergency Telephone:
Rust-Oleum Corporation
11 Hawthorn Parkway
Vernon Hills, IL 60061
USA
24 Hour Hotline: 847-367-7700
Manufacturer:
Rust-Oleum Corporation
11 Hawthorn Parkway
Vernon Hills, IL 60061
USA
2. Hazard Identification
EMERGENCY OVERVIEW: Harmful if inhaled. Harmful if swallowed. Causes eye irritation. Vapors irritating to eyes and
respiratory tract. Combustible liquid and vapor. Use ventilation necessary to keep exposures below recommended exposure limits,
if any. Harmful if inhaled. May affect the brain or nervous system causing dizziness, headache or nausea. May cause eye, skin, or
respiratory tract irritation. KEEP OUT OF REACH OF CHILDREN.
Classification
Symbol(s) of Product
Signal Word
Danger
GHS HAZARD STATEMENTS
Flammable liquid, category 4 H227 Combustible liquid
Organic Peroxide, categories C, D H242 Heating may cause a fire.
Aspiration Hazard, category 2 H305 May be harmful if swallowed and enters airways.
Acute Toxicity, Dermal, category 5 H313 May be harmful in contact with skin.
Skin Irritation, category 2 H315 Causes skin irritation.
Eye Irritation, category 2B H320 Causes eye irritation.
Acute Toxicity, Inhalation, category 4 H332 Harmful if inhaled.
STOT, single exposure, category 3, RTI H335 May cause respiratory irritation.
STOT, single exposure, category 3, NE H336 May cause drowsiness or dizziness.
GHS PRECAUTIONARY STATEMENTS
P102 Keep out of reach of children.
P103 Read label before use.
P202 Do not handle until all safety precautions have been read and understood.
P210 Keep away from heat/sparks/open flames/hot surfaces. – No smoking.
P220 Keep/Store away from clothing/…/combustible materials.
P234 Keep only in original container.
Date Printed: 8/13/2014
8052-41-3
64742-88-7
13463-67-7
1317-80-2
100-41-4
P260 Do not breathe dust/fume/gas/mist/vapours/spray.
P261 Avoid breathing dust/fume/gas/mist/vapours/spray.
P262 Do not get in eyes, on skin, or on clothing.
P264 Wash … thoroughly after handling.
P270 Do not eat, drink or smoke when using this product.
P271 Use only outdoors or in a well-ventilated area.
P273 Avoid release to the environment.
P280 Wear protective gloves/protective clothing/eye protection/face protection.
P281 Use personal protective equipment as required.
P285 In case of inadequate ventilation wear respiratory protection.
P302+P350 IF ON SKIN: Gently wash with plenty of soap and water.
P304+P340 IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for
breathing.
P312 Call a POISON CENTER or doctor/physician if you feel unwell.
P321 Specific treatment (see … on this label).
P332+P313 If skin irritation occurs: Get medical advice/attention.
P351 Rinse cautiously with water for several minutes.
P352 Wash with plenty of soap and water.
P362 Take off contaminated clothing and wash before reuse.
P374 Fight fire with normal precautions from a reasonable distance.
P402 Store in a dry place.
P403+P233 Store in a well-ventilated place. Keep container tightly closed.
P405 Store locked up.
P410+P412 Protect from sunlight. Do no expose to temperatures exceeding 50°C/ 122°F.
P411+P235 Store at temperatures not exceeding …°C/…°F. Keep cool.
P420 Store away from other materials.
P501 Dispose of contents/container to …
Page 2 / 7
3. Composition/Information On Ingredients
HAZARDOUS SUBSTANCES
Chemical Name CAS-No. Wt.%
Range
Stoddard Solvents
Mineral Spirits
Titanium Dioxide
Titanium Dioxide
Ethylbenzene
The text for GHS Hazard Statements shown above (if any) is given in the "16. Other Information" section.
25-50
10-25
2.5-10
1.0-2.5
0.1-1.0
GHS Symbols
GHS02
GHS06
GHS02-GHS07
GHS Statements
H224
H331
H225-332
4. First-aid Measures
FIRST AID - EYE CONTACT: Immediately flush eyes with plenty of water for at least 15 minutes holding eyelids open. Get medical
attention. Do NOT allow rubbing of eyes or keeping eyes closed.
FIRST AID - SKIN CONTACT: Wash skin with soap and water. Remove contaminated clothing. Get medical attention if irritation
develops or persists.
FIRST AID - INHALATION: Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get
immediate medical attention. Do NOT use mouth-to-mouth resuscitation. If you experience difficulty in breathing, leave the area to
obtain fresh air. If continued difficulty is experienced, get medical assistance immediately.
FIRST AID - INGESTION: If swallowed, get medical attention.
EXTINGUISHING MEDIA:
UNUSUAL FIRE AND EXPLOSION HAZARDS: Closed containers may explode when exposed to extreme heat due to buildup of
steam. Keep containers tightly closed. Combustible liquid and vapor. No unusual fire or explosion hazards noted.
5. Fire-fighting Measures
Alcohol Film Forming Foam, Carbon Dioxide, Dry Chemical, Dry Sand, Water Fog
Date Printed: 8/13/2014
Page 3 / 7
SPECIAL FIREFIGHTING PROCEDURES: Water may be used to cool closed containers to prevent pressure buildup and possible
autoignition or explosion. Evacuate area and fight fire from a safe distance. Use water spray to keep fire-exposed containers cool.
Containers may explode when heated.
6. Accidental Release Measures
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Contain spilled liquid with sand or earth. DO NOT use
combustible materials such as sawdust. Remove all sources of ignition, ventilate area and remove with inert absorbent and nonsparking tools. Dispose of according to local, state (provincial) and federal regulations. Do not incinerate closed containers.
7. Handling and Storage
HANDLING: Wash thoroughly after handling. Wash hands before eating. Remove contaminated clothing and launder before reuse.
Use only with adequate ventilation. Follow all MSDS/label precautions even after container is emptied because it may retain product
residues. Avoid breathing fumes, vapors, or mist. Avoid contact with eyes, skin and clothing. Avoid contact with eyes.
STORAGE: Store in a dry, well ventilated place. Keep container tightly closed when not in use. Keep containers tightly closed.
Isolate from heat, electrical equipment, sparks and open flame. Do not store above 120 ° F. Store large quantities in buildings
designed and protected for storage of NFPA Class II combustible liquids. Keep away from heat, sparks, flame and sources of
ignition. Keep container closed when not in use. Avoid excess heat.
8. Exposure Controls/Personal Protection
Chemical Name CAS-No.
Stoddard Solvents 8052-41-3 35.0 100 ppm N.E. 500 ppm N.E.
Mineral Spirits 64742-88-7 15.0 100 ppm N.E. 100 ppm N.E.
Titanium Dioxide 13463-67-7 5.0 10 mg/m3 N.E.
Titanium Dioxide 1317-80-2 5.0 10 mg/m3 N.E.
Ethylbenzene 100-41-4 1.0 20 ppm 125 ppm 100 ppm N.E.
Weight %
Less Than
ACGIH TLV-
TWA
ACGIH TLV-
STEL
OSHA PEL-TWA
15 mg/m3 [Total
Dust]
15 mg/m3 (Total
Dust)
OSHA PEL-
CEILING
N.E.
N.E.
PERSONAL PROTECTION
ENGINEERING CONTROLS: Use process enclosures, local exhaust ventilation, or other engineering controls to control airborne
levels below recommended exposure limits. Prevent build-up of vapors by opening all doors and windows to achieve crossventilation.
RESPIRATORY PROTECTION: A respiratory protection program that meets OSHA 1910.134 and ANSI Z88.2 requirements must be
followed whenever workplace conditions warrant a respirator's use. A NIOSH/MSHA approved air purifying respirator with an organic
vapor cartridge or canister may be permissible under certain circumstances where airborne concentrations are expected to exceed
exposure limits.
Protection provided by air purifying respirators is limited. Use a positive pressure air supplied respirator if there is any potential for an
uncontrolled release, exposure levels are not known, or in any other circumstances where air purifying respirators may not provide
adequate protection.
SKIN PROTECTION: Use gloves to prevent prolonged skin contact. Use impervious gloves to prevent skin contact and absorption of
this material through the skin. Nitrile or Neoprene gloves may afford adequate skin protection.
EYE PROTECTION: Use safety eyewear designed to protect against splash of liquids.
OTHER PROTECTIVE EQUIPMENT: Refer to safety supervisor or industrial hygienist for further guidance regarding types of
personal protective equipment and their applications. Refer to safety supervisor or industrial hygienist for further information
regarding personal protective equipment and its application.
HYGIENIC PRACTICES: Wash thoroughly with soap and water before eating, drinking or smoking. Remove contaminated clothing
immediately and launder before reuse.
Date Printed: 8/13/2014
9. Physical and Chemical Properties
Page 4 / 7
Appearance:
Odor:
Relative Density:
Freeze Point, °C:
Solubility in Water:
Decompostion Temp., °C:
Boiling Range, °C:
Flammability:
Evaporation Rate:
Vapor Density:
(See "Other information" Section for abbreviation legend)
Liquid
Solvent Like
0.948
N.D.
Negligible
No Information
212 - 415
Supports Combustion
Slower than Ether
Heavier than Air
Physical State:
Odor Threshold:
pH:
Viscosity:
Partition Coefficient, n-octanol/
water:
Explosive Limits, vol%:
Flash Point, °C:
Auto-ignition Temp., °C:
Vapor Pressure:
Liquid
N.E.
N.A.
N.D.
No Information
0.7 - 8.9
38
No Information
N.D.
10. Stability and Reactivity
CONDITIONS TO AVOID: Avoid temperatures above 120 ° F. Avoid contact with strong acid and strong bases. Avoid all possible
sources of ignition.
INCOMPATIBILITY: Incompatible with strong oxidizing agents, strong acids and strong alkalies.
HAZARDOUS DECOMPOSITION: By open flame, carbon monoxide and carbon dioxide. When heated to decomposition, it emits
acrid smoke and irritating fumes. Contains solvents which may form carbon monoxide, carbon dioxide, and formaldehyde.
HAZARDOUS POLYMERIZATION: Will not occur under normal conditions.
STABILITY: This product is stable under normal storage conditions.
11. Toxicological information
EFFECTS OF OVEREXPOSURE - EYE CONTACT: Causes eye irritation. Substance causes moderate eye irritation.
EFFECTS OF OVEREXPOSURE - SKIN CONTACT: Substance may cause slight skin irritation. May cause skin irritation.
EFFECTS OF OVEREXPOSURE - INHALATION: Harmful if inhaled. High gas, vapor, mist or dust concentrations may be harmful if
inhaled. Avoid breathing fumes, spray, vapors, or mist. May cause headaches and dizziness. High vapor concentrations are
irritating to the eyes, nose, throat and lungs. Prolonged or excessive inhalation may cause respiratory tract irritation.
EFFECTS OF OVEREXPOSURE - INGESTION: Irritating to the nose, throat and respiratory tract. Harmful if swallowed. Aspiration
hazard if swallowed; can enter lungs and cause damage.
EFFECTS OF OVEREXPOSURE - CHRONIC HAZARDS: Reports have associated repeated and prolonged occupational
overexposure to solvents with permanent brain and nervous system damage. IARC lists Ethylbenzene as a possible human
carcinogen (group 2B). Contains Titanium Dioxide. Titanium Dioxide is listed as a Group 2B-"Possibly carcinogenic to humans" by
IARC. No significant exposure to Titanium Dioxide is thought to occur during the use of products in which Titanium Dioxide is bound
to other materials, such as in paints during brush application or drying. Risk of overexposure depends on duration and level of
exposure to dust from repeated sanding of surfaces or spray mist and the actual concentration of Titanium Dioxide in the formula.
(Ref: IARC Monograph, Vol. 93, 2010)
PRIMARY ROUTE(S) OF ENTRY: Eye Contact, Ingestion, Inhalation, Skin Absorption, Skin Contact
ACUTE TOXICITY VALUES
The acute effects of this product have not been tested. Data on individual components are tabulated below:
CAS-No.
64742-88-7 Mineral Spirits >5000 mg/kg Rat 3000 mg/kg Rabbit >5.28 mg/L Rat
13463-67-7 Titanium Dioxide >10000 mg/kg Rat N.I. N.I.
100-41-4 Ethylbenzene 3500 mg/kg Rat 15354 mg/kg Rabbit 17.2 mg/L Rat
N.I. - No Information
Chemical Name Oral LD50 Dermal LD50 Vapor LC50
12. Ecological Information
ECOLOGICAL INFORMATION: Product is a mixture of listed components. Product is a mixture of listed components.
13. Disposal Information
DISPOSAL INFORMATION: Dispose of material in accordance to local, state, and federal regulations and ordinances. Do not allow
to enter waterways, wastewater, soil, storm drains or sewer systems.
Date Printed: 8/13/2014
Page 5 / 7
14. Transport Information
Domestic (USDOT) International (IMDG) Air (IATA) TDG (Canada)
UN Number: N.A. 1263 1263 N.A.
Proper Shipping Name: Not Regulated Paint Paint Not Regulated
Hazard Class: N.A. 3 3 N.A.
Packing Group: N.A. III III N.A.
Limited Quantity: No Yes, >5L No Yes, >5L No No
15. Regulatory Information
U.S. Federal Regulations:
CERCLA - SARA Hazard Category
This product has been reviewed according to the EPA ‘Hazard Categories’ promulgated under Sections 311 and 312 of the
Superfund Amendment and Reauthorization Act of 1986 (SARA Title III) and is considered, under applicable definitions, to
meet the following categories:
Fire Hazard, Acute Health Hazard, Chronic Health Hazard
Sara Section 313:
This product contains the following substances subject to the reporting requirements of Section 313 of Title III of the
Superfund Amendment and Reauthorization Act of 1986 and 40 CFR part 372:
Chemical Name
Ethylbenzene 100-41-4
CAS-No.
Toxic Substances Control Act:
This product contains the following chemical substances subject to the reporting requirements of TSCA 12(B) if exported from
the United States:
No TSCA components exist in this product.
Inventory Information
Country Value
USA (TSCA) No Information
Canada (DSL) No Information
Mexico(INSQ) No Information
Europe (EINECS) No Information
Japan (ENCS) No Information
Philippines (PICCS) No Information
China (IECSC) No Information
Australia (AICS) No Information
Korea (KECI) No Information
New Zealand (NZIOC) No Information
No Information
CALIFORNIA PROPOSITION 65:
Warning: This products contains a substance known to the State of California to cause cancer.
Chemical Name
Titanium Dioxide
Titanium Dioxide
Ethylbenzene
CAS-No.
13463-67-7
1317-80-2
100-41-4
Date Printed: 8/13/2014
CALIFORNIA PROPOSITION 65 REPRODUCTIVE TOXINS
Warning: This product contains a substance known to the State of California to cause birth defects or other reproductive
harm.
No Proposition 65 Reproductive Toxins exist in this product.
International Regulations:
CANADIAN WHMIS:
This SDS has been prepared in compliance with Controlled Product Regulations except for the use of the 16 headings.
16. Other Information
HMIS RATINGS
Health: 2* Flammability: 2 Physical Hazard: 0 Personal Protection: X
CANADIAN WHMIS CLASS: B3 D2A
NFPA RATINGS
Health: 2 Flammability: 3 Instability 0
Page 6 / 7
VOLATILE ORGANIC COMPOUNDS, g/L:
MSDS REVISION DATE:
REASON FOR REVISION:
Legend: N.A. - Not Applicable, N.E. - Not Established, N.D. - Not Determined
8/13/2014
No Information
448
Text for GHS Hazard Statements shown in Section 3 describing each ingredient:
H224 Extremely flammable liquid and vapour.
H225 Highly flammable liquid and vapour.
H331 Toxic if inhaled.
H332 Harmful if inhaled.
Icons for GHS Pictograms shown in Section 3 describing each ingredient:
GHS02
GHS06
GHS07
Date Printed: 8/13/2014
Page 7 / 7
Rust-Oleum Corporation believes, to the best of its knowledge, information and belief, the information contained herein to be
accurate and reliable as of the date of this safety data sheet. However, because the conditions of handling, use, and storage of
these materials are beyond our control, we assume no responsibility or liability for personal injury or property damage incurred by
the use of these materials. Rust-Oleum Corporation makes no warranty, expressed or implied, regarding the accuracy or
reliability of the data or results obtained from their use. All materials may present unknown hazards and should be used with
caution. The information and recommendations in this material safety data sheet are offered for the users’ consideration and
examination. It is the responsibility of the user to determine the final suitability of this information and to comply with all applicable
international, federal, state, and local laws and regulations.
Loading...