Rust-Oleum 245478 User Manual

Date Printed: 8/14/2014
Safety Data Sheet
* Trusted Quality Since 1921 *
www.rustoleum.com
1. Identification
Product Name: ROHPER 1-GL 2PK V7400 SAFETY RED Revision Date: 8/14/2014
Product Identifier: 245478 Supercedes Date: New SDS
Product Use/Class: Topcoat/ Alkyd
Page 1 / 7
Preparer: Regulatory Department
Emergency Telephone:
Rust-Oleum Corporation 11 Hawthorn Parkway Vernon Hills, IL 60061 USA
24 Hour Hotline: 847-367-7700
Manufacturer:
Rust-Oleum Corporation 11 Hawthorn Parkway Vernon Hills, IL 60061 USA
2. Hazard Identification
EMERGENCY OVERVIEW: Harmful if inhaled. Causes eye irritation. Combustible liquid and vapor. Use ventilation necessary to
keep exposures below recommended exposure limits, if any. May cause eye, skin, or respiratory tract irritation. KEEP OUT OF REACH OF CHILDREN.
Classification
Symbol(s) of Product
Signal Word
Danger
Possible Hazards
33% of the mixture consists of ingredient(s) of unknown acute toxicity

GHS HAZARD STATEMENTS

Flammable liquid, category 4 H227 Combustible liquid Organic Peroxide, categories C, D H242 Heating may cause a fire. Acute Toxicity, Oral, category 3 H301 Toxic if swallowed. Aspiration Hazard, category 2 H305 May be harmful if swallowed and enters airways. Acute Toxicity, Dermal, category 1 H310 Fatal in contact with skin. Acute Toxicity, Dermal, category 5 H313 May be harmful in contact with skin. Skin Irritation, category 2 H315 Causes skin irritation. Eye Irritation, category 2B H320 Causes eye irritation. Acute Toxicity, Inhalation, category 4 H332 Harmful if inhaled. STOT, single exposure, category 3, RTI H335 May cause respiratory irritation. STOT, single exposure, category 3, NE H336 May cause drowsiness or dizziness.

GHS PRECAUTIONARY STATEMENTS

P102 Keep out of reach of children. P103 Read label before use. P202 Do not handle until all safety precautions have been read and understood.
Date Printed: 8/14/2014
Proprietary
8052-41-3
98-56-6
64742-88-7
556-67-2
100-41-4
P210 Keep away from heat/sparks/open flames/hot surfaces. – No smoking. P220 Keep/Store away from clothing/…/combustible materials. P234 Keep only in original container. P260 Do not breathe dust/fume/gas/mist/vapours/spray. P261 Avoid breathing dust/fume/gas/mist/vapours/spray. P262 Do not get in eyes, on skin, or on clothing. P264 Wash … thoroughly after handling. P270 Do not eat, drink or smoke when using this product. P271 Use only outdoors or in a well-ventilated area. P273 Avoid release to the environment. P280 Wear protective gloves/protective clothing/eye protection/face protection. P281 Use personal protective equipment as required. P285 In case of inadequate ventilation wear respiratory protection. P301+P310 IF SWALLOWED: Immediately call a POISON CENTER or doctor/physician. P302+P350 IF ON SKIN: Gently wash with plenty of soap and water. P304+P340 IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for
breathing. P310 Immediately call a POISON CENTER or doctor/physician. P312 Call a POISON CENTER or doctor/physician if you feel unwell. P321 Specific treatment (see … on this label). P322 Specific measures (see … on this label). P330 Rinse mouth. P332+P313 If skin irritation occurs: Get medical advice/attention. P351 Rinse cautiously with water for several minutes. P352 Wash with plenty of soap and water. P361 Remove/Take off immediately all contaminated clothing. P362 Take off contaminated clothing and wash before reuse. P363 Wash contaminated clothing before reuse. P374 Fight fire with normal precautions from a reasonable distance. P402 Store in a dry place. P403+P233 Store in a well-ventilated place. Keep container tightly closed. P405 Store locked up. P410+P412 Protect from sunlight. Do no expose to temperatures exceeding 50°C/ 122°F. P411+P235 Store at temperatures not exceeding …°C/…°F. Keep cool. P420 Store away from other materials. P501 Dispose of contents/container to …
Page 2 / 7
3. Composition/Information On Ingredients
HAZARDOUS SUBSTANCES
Chemical Name CAS-No. Wt.%
Range
Polymers/Binder/Resin Stoddard Solvents 1-Chloro-4(Trifluoromethyl)Benzene Mineral Spirits Octamethylcyclotetrasiloxane Ethylbenzene
The text for GHS Hazard Statements shown above (if any) is given in the "16. Other Information" section.
10-25 10-25 10-25
2.5-10
2.5-10
0.1-1.0
GHS Symbols
GHS02 GHS02-GHS06 GHS06 GHS02-GHS06 GHS02-GHS07
GHS Statements
H224 H226-300-310 H331 H226-311 H225-332
4. First-aid Measures
FIRST AID - EYE CONTACT: Immediately flush eyes with plenty of water for at least 15 minutes holding eyelids open. Get medical
attention. Do NOT allow rubbing of eyes or keeping eyes closed.
FIRST AID - SKIN CONTACT: Wash skin with soap and water. Remove contaminated clothing. Get medical attention if irritation develops or persists.
Date Printed: 8/14/2014
Page 3 / 7
FIRST AID - INHALATION: Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get immediate medical attention. Do NOT use mouth-to-mouth resuscitation. If you experience difficulty in breathing, leave the area to obtain fresh air. If continued difficulty is experienced, get medical assistance immediately.
FIRST AID - INGESTION: If swallowed, get medical attention.
5. Fire-fighting Measures
EXTINGUISHING MEDIA:
Alcohol Film Forming Foam, Carbon Dioxide, Dry Chemical, Dry Sand, Water Fog
UNUSUAL FIRE AND EXPLOSION HAZARDS: Closed containers may explode when exposed to extreme heat due to buildup of steam. Keep containers tightly closed. Combustible liquid and vapor. No unusual fire or explosion hazards noted.
SPECIAL FIREFIGHTING PROCEDURES: Evacuate area and fight fire from a safe distance. Use water spray to keep fire-exposed containers cool. Containers may explode when heated.
6. Accidental Release Measures
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Remove all sources of ignition, ventilate area and remove with
inert absorbent and non-sparking tools. Dispose of according to local, state (provincial) and federal regulations. Do not incinerate closed containers.
7. Handling and Storage
HANDLING: Wash thoroughly after handling. Wash hands before eating. Remove contaminated clothing and launder before reuse.
Use only with adequate ventilation. Follow all MSDS/label precautions even after container is emptied because it may retain product residues. Avoid breathing fumes, vapors, or mist. Avoid contact with eyes, skin and clothing.
STORAGE: Store in a dry, well ventilated place. Keep container tightly closed when not in use. Keep containers tightly closed. Isolate from heat, electrical equipment, sparks and open flame. Do not store above 120 ° F. Store large quantities in buildings designed and protected for storage of NFPA Class II combustible liquids. Avoid excess heat.
8. Exposure Controls/Personal Protection
Chemical Name CAS-No.
Polymers/Binder/Resin Proprietary 20.0 N.E. N.E. N.E. N.E. Stoddard Solvents 8052-41-3 20.0 100 ppm N.E. 500 ppm N.E. 1-Chloro-4(Trifluoromethyl) Benzene Mineral Spirits 64742-88-7 10.0 100 ppm N.E. 100 ppm N.E. Octamethylcyclotetrasiloxane 556-67-2 5.0 N.E. N.E. N.E. N.E. Ethylbenzene 100-41-4 1.0 20 ppm 125 ppm 100 ppm N.E.
98-56-6 20.0 N.E. N.E. N.E. N.E.
Weight %
Less Than
ACGIH TLV-
TWA
ACGIH TLV-
STEL
OSHA PEL-TWA
OSHA PEL-
CEILING
PERSONAL PROTECTION
ENGINEERING CONTROLS: Use process enclosures, local exhaust ventilation, or other engineering controls to control airborne
levels below recommended exposure limits. Prevent build-up of vapors by opening all doors and windows to achieve cross­ventilation.
RESPIRATORY PROTECTION: A respiratory protection program that meets OSHA 1910.134 and ANSI Z88.2 requirements must be followed whenever workplace conditions warrant a respirator's use.
SKIN PROTECTION: Use gloves to prevent prolonged skin contact. Nitrile or Neoprene gloves may afford adequate skin protection.
EYE PROTECTION: Use safety eyewear designed to protect against splash of liquids.
OTHER PROTECTIVE EQUIPMENT: Refer to safety supervisor or industrial hygienist for further guidance regarding types of
personal protective equipment and their applications.
HYGIENIC PRACTICES: Wash thoroughly with soap and water before eating, drinking or smoking. Remove contaminated clothing immediately and launder before reuse.
Date Printed: 8/14/2014
9. Physical and Chemical Properties
Page 4 / 7
Appearance: Odor: Relative Density: Freeze Point, °C: Solubility in Water: Decompostion Temp., °C: Boiling Range, °C: Flammability: Evaporation Rate: Vapor Density:
(See "Other information" Section for abbreviation legend)
Liquid Solvent Like
1.014 N.D. None No Information 277 - 500 Supports Combustion Slower than Ether Heavier than Air
Physical State: Odor Threshold: pH: Viscosity: Partition Coefficient, n-octanol/
water:
Explosive Limits, vol%: Flash Point, °C: Auto-ignition Temp., °C: Vapor Pressure:
Liquid N.E. N.A. N.D.
No Information
0.7 - 8.9 38 No Information N.D.
10. Stability and Reactivity
CONDITIONS TO AVOID: Avoid temperatures above 120 ° F. Avoid contact with strong acid and strong bases.
INCOMPATIBILITY: Incompatible with strong oxidizing agents, strong acids and strong alkalies.
HAZARDOUS DECOMPOSITION: When heated to decomposition, it emits acrid smoke and irritating fumes. Contains solvents
which may form carbon monoxide, carbon dioxide, and formaldehyde.
HAZARDOUS POLYMERIZATION: Will not occur under normal conditions.
STABILITY: This product is stable under normal storage conditions.
11. Toxicological information
EFFECTS OF OVEREXPOSURE - EYE CONTACT: Substance causes moderate eye irritation.
EFFECTS OF OVEREXPOSURE - SKIN CONTACT: Substance may cause slight skin irritation.
EFFECTS OF OVEREXPOSURE - INHALATION: High gas, vapor, mist or dust concentrations may be harmful if inhaled. Avoid
breathing fumes, spray, vapors, or mist. High vapor concentrations are irritating to the eyes, nose, throat and lungs. Prolonged or excessive inhalation may cause respiratory tract irritation.
EFFECTS OF OVEREXPOSURE - INGESTION: Irritating to the nose, throat and respiratory tract. Harmful if swallowed.
EFFECTS OF OVEREXPOSURE - CHRONIC HAZARDS: Reports have associated repeated and prolonged occupational
overexposure to solvents with permanent brain and nervous system damage. IARC lists Ethylbenzene as a possible human carcinogen (group 2B).
PRIMARY ROUTE(S) OF ENTRY: Eye Contact, Ingestion, Inhalation, Skin Absorption, Skin Contact
ACUTE TOXICITY VALUES The acute effects of this product have not been tested. Data on individual components are tabulated below:
CAS-No.
98-56-6 1-Chloro-4(Trifluoromethyl)Benzene 13 g/kg Rat >2 mL/kg Rabbit 33 mg/L Rat 64742-88-7 Mineral Spirits >5000 mg/kg Rat 3000 mg/kg Rabbit >5.28 mg/L Rat 556-67-2 Octamethylcyclotetrasiloxane N.I. 794 µL/kg Rabbit N.I. 100-41-4 Ethylbenzene 3500 mg/kg Rat 15354 mg/kg Rabbit 17.2 mg/L Rat
N.I. - No Information
Chemical Name Oral LD50 Dermal LD50 Vapor LC50
12. Ecological Information
ECOLOGICAL INFORMATION: Product is a mixture of listed components.
13. Disposal Information
DISPOSAL INFORMATION: Dispose of material in accordance to local, state, and federal regulations and ordinances. Do not allow
to enter waterways, wastewater, soil, storm drains or sewer systems.
Date Printed: 8/14/2014
Page 5 / 7
14. Transport Information
Domestic (USDOT) International (IMDG) Air (IATA) TDG (Canada)
UN Number: N.A. 1263 1263 N.A.
Proper Shipping Name: Not Regulated Paint Paint Not Regulated
Hazard Class: N.A. 3 3 N.A.
Packing Group: N.A. III III N.A.
Limited Quantity: No Yes, >5L No Yes, >5L No No
15. Regulatory Information
U.S. Federal Regulations:
CERCLA - SARA Hazard Category
This product has been reviewed according to the EPA ‘Hazard Categories’ promulgated under Sections 311 and 312 of the Superfund Amendment and Reauthorization Act of 1986 (SARA Title III) and is considered, under applicable definitions, to meet the following categories:
Fire Hazard, Acute Health Hazard, Chronic Health Hazard
Sara Section 313:
This product contains the following substances subject to the reporting requirements of Section 313 of Title III of the Superfund Amendment and Reauthorization Act of 1986 and 40 CFR part 372:
Chemical Name
1-Chloro-4(Trifluoromethyl)Benzene 98-56-6 Ethylbenzene 100-41-4
CAS-No.
Toxic Substances Control Act:
This product contains the following chemical substances subject to the reporting requirements of TSCA 12(B) if exported from the United States:
No TSCA components exist in this product.
Inventory Information
Country Value
USA (TSCA) No Information Canada (DSL) No Information Mexico(INSQ) No Information Europe (EINECS) No Information Japan (ENCS) No Information Philippines (PICCS) No Information China (IECSC) No Information Australia (AICS) No Information Korea (KECI) No Information New Zealand (NZIOC) No Information
No Information
CALIFORNIA PROPOSITION 65:
Warning: This products contains a substance known to the State of California to cause cancer.
Chemical Name
Ethylbenzene
CAS-No.
100-41-4
Date Printed: 8/14/2014
CALIFORNIA PROPOSITION 65 REPRODUCTIVE TOXINS
Warning: This product contains a substance known to the State of California to cause birth defects or other reproductive harm.
No Proposition 65 Reproductive Toxins exist in this product.
International Regulations:
CANADIAN WHMIS:
This SDS has been prepared in compliance with Controlled Product Regulations except for the use of the 16 headings.
16. Other Information
HMIS RATINGS
Health: 2* Flammability: 2 Physical Hazard: 0 Personal Protection: X
CANADIAN WHMIS CLASS: B3 D2A
NFPA RATINGS
Health: 2 Flammability: 2 Instability 0
Page 6 / 7
VOLATILE ORGANIC COMPOUNDS, g/L:
MSDS REVISION DATE:
REASON FOR REVISION:
Legend: N.A. - Not Applicable, N.E. - Not Established, N.D. - Not Determined
8/14/2014
No Information
336
Text for GHS Hazard Statements shown in Section 3 describing each ingredient:
H224 Extremely flammable liquid and vapour. H225 Highly flammable liquid and vapour. H226 Flammable liquid and vapour. H300 Fatal if swallowed. H310 Fatal in contact with skin. H311 Toxic in contact with skin. H331 Toxic if inhaled. H332 Harmful if inhaled.
Icons for GHS Pictograms shown in Section 3 describing each ingredient:
GHS02
GHS06
GHS07
Date Printed: 8/14/2014
Page 7 / 7
Rust-Oleum Corporation believes, to the best of its knowledge, information and belief, the information contained herein to be accurate and reliable as of the date of this safety data sheet. However, because the conditions of handling, use, and storage of these materials are beyond our control, we assume no responsibility or liability for personal injury or property damage incurred by the use of these materials. Rust-Oleum Corporation makes no warranty, expressed or implied, regarding the accuracy or reliability of the data or results obtained from their use. All materials may present unknown hazards and should be used with caution. The information and recommendations in this material safety data sheet are offered for the users’ consideration and examination. It is the responsibility of the user to determine the final suitability of this information and to comply with all applicable international, federal, state, and local laws and regulations.
Loading...