Rubicon Express RE7141 User Manual

RUBICON EXPRESS 3290 MONIER CIR., RANCHO CORDOVA, CA. 95742 866-533-7706, www.Rubiconexpress.com

INSTALLATION INSTRUCTIONS FOR:

RE7121 & RE7141

2007-2013 2.5” JEEP WRANGLER JK COIL SPRING LIFT KIT

Safety Warning:

Suspension systems or components that enhance the off-road performance of your ve­hicle may cause it to handle differently, on and off-road, than it did from the factory.
Care must be taken to prevent loss of control or vehicle rollover during sudden maneu­vers. Failure to drive the vehicle safely may result in serious injury or death to driver
and passengers. We recommend you always wear your seatbelt, drive safely and avoid
quick turns and other sudden maneuvers. Constant maintenance is required to keep
your vehicle safe. Thoroughly inspect your vehicle before and after every off-road use.

Installation Warning:
We recommend that certified technicians perform the installations of our products. At­tempts to install these products without knowledge or experience may jeopardize the
safety of the vehicle. These instructions only cover the installation of our products and
may not include factory procedures for disassembly and reassembly of factory compo­nents. Read instructions from start to finish and be sure all parts are present before
disassembling the vehicle. Included instructions are guidelines only for recommended
procedures and in no way are meant to be definitive. Installer is responsible to insure
a safe and controllable vehicle after performing modifications. Do not perform test
drives on public roads with partially completed installations. Always double and triple
check your work before use.

ESP WARNING NOTE
Stability Program (ESP). This system is designed to help control the vehicle
in times of uncertain traction conditions and roll stability. Due to the com­plex nature of this program Rubicon Express strongly suggest that after lift­ing the vehicle it is returned to the dealer for a computer “flash” to re ad­dress tire size and proper ESP control settings. Rubicon Express also recom­mends that you become familiar with the ESP controls and how the different
level of settings can help you to keep better control of your vehicle.

: The 2007+ Jeep Wrangler JK is equipped an Electric

Revised

12.19.12

Revised

12.19.12

RE7121 2 Door Standard Kit (w/o Shock)

2 RM60450 Front coil spring
2 RM60465 Rear coil spring
1 RE1380 Front bump stop kit
1 RE1387 Rear bump stop pad
1 RE1607 Rear Lower Track Bar Bracket
1 RE1478 JK Alignment plate set
2 HWC11083 Shock hardware: Bar Pin
2 RM40360 Lower Shock Sleeve
1 RE1158 Extended Rear Sway Bar End Link Kit

RE7121T 2 Door Kit (w/ Twin Tube Shocks)

1 RE7121 2 Door Standard Kit
2 RXT2420 Twin Tube Shock
2 RXT2421 Twin Tube Shock

RE7121M 2 Door Kit (w/ Mono Tube Shocks)

1 RE7121 2 Door Standard Kit
2 RXJ713 Mono Tube front Shock
2 RXJ714 Mono Tube Rear Shock

:

:

:

RE7141 4 Door Standard Kit (w/o Shocks):
2 RM60450 Front coil spring
2 RM60470 Rear coil spring
1 RE1380 Front bump stop kit
1 RE1387 Rear bump stop pad
1 RE1607 Rear Lower Track Bar Bracket
1 RE1478 JK Alignment plate set
2 HWC11083 Shock hardware: Bar Pin
2 RM40360 Lower Shock Sleeve
1 RE1158 Extended Rear Sway Bar End Link Kit

RE7141T 4 Door Kit (w/ Twin Tube Shocks)

:

1 RE7141 4 Door Standard Kit
2 RXT2420 Twin Tube Shock
2 RXT2421 Twin Tube Shock

RE7141M 4 Door Kit (w/ Mono Tube Shocks):

1 RE7141 4 Door Standard Kit
2 RXJ713 Mono Tube front Shock
2 RXJ714 Mono Tube Rear Shock