Rubicon Express RE7133 User Manual

RUBICON EXPRESS 1900 EL CAMINO AVE, SACRAMENTO, CA 95815 866-533-7706, www.Rubiconexpress.com

INSTALLATION INSTRUCTIONS FOR:

RE7133 2.5” JK BUDGET BOOST SUSPENSION LIFT

Safety Warning:

Suspension systems or components that enhance the off-road performance of y our vehicle may cause it
to handle differently, on and off-road, than it did from the factory. Care must be taken to prevent loss
of control or vehicle rollover during sudden maneuvers. Failure to drive the vehicle safely may result in
serious injury or death to driver and passengers. We recommend you always wear your seatbelt, drive
safely and avoid quick turns and other sudden maneuvers. Constant maintenance is required to keep
your vehicle safe. Thoroughly inspect your vehicle before and after every off-road use.

Installation Warning

We recommend that certified technicians perform the installations of our products. Attempts to inst all
these products without knowledge or experience may jeopardize the safety of the vehicle. These in­structions only cover the installation of our products and may not include factory procedures for disas­sembly and reassembly of factory components. Read instructions from start to finish and be sure all
parts are present before disassembling the vehicle. Included instructions are guidelines only for recom­mended procedures and in no way are meant to be definitive. Installer is responsible to insure a safe
and controllable vehicle after performing modifications. Do not perform test drives on public roads with
partially completed installations. Always double and triple check your work before use.

ESP WARNING NOTE
gram (ESP). This system is designed to help control the vehicle in times of uncertain trac­tion conditions and roll stability. Due to the complex nature of this program Rubicon Ex­press strongly suggest that after lifting the vehicle it is returned to the dealer for a com­puter “flash” to re address tire size and proper ESP control settings. Rubicon Express also
recommends that you become familiar with the ESP controls and how the different level of
settings can help you to keep better control of your vehicle.

RE7133 Spacer Kit (w/o Shocks):

2 RM40090 2.5” Front coil spacer

2 RM40110 1.75” Rear coil spacer
2 90-RM42520 2” Front bump stops
2 HW1060 Front bump stop mounting hardware
1 RE1478 Front alignment washers
2 86-RM22016 2” Rear bump stops
1 HWC10319 Rear bump stop hardware pack
1 86-RM24053 Rear track bar bracket

1 HWC15018 Rear track bar bracket hardware pack
1 35-RM31023 Rear Track Bar Bracket spacer
1 RE1158 Extended Rear Sway Bar End Link Kit

:

: The 2007+ Jeep Wrangler JK is equipped an Electric Stability Pro-

Revised

9.3.13

RE7133E Spacer Kit (w/ Shock Extensions):

1 RE7133 Spacer Kit:
2 RM40090 2.5” Front coil spacer
2 RM40110 1.75” Rear coil spacer
2 90-RM40520 2” Front bump stop s
2 HW1060 Front bump stop mounting hardware
1 RE1478 Front alignment washers

2 86-RM22016 2” Rear bump stops
1 HWC10319 Rear bump stop hardware pack
1 86-RM24053 Rear track bar bracket
1 HWC15018 Rear track bar bracket hardware pack
1 35-RM31023 Rear Track Bar Bracket spacer
1 RE1158 Extended Rear Sway Bar End Link Kit

1 RE2003 Front shock extensions

1 RE2004 Rear shock extensions

RE7133T Spacer Kit (w/RXT Shocks):

1 RE7133 Spacer Kit:
2 RM40090 2.5” Front coil spacer
2 RM40110 1.75” Rear coil spacer
2 90-RM40520 2” Front bump stop s
2 HW1060 Front bump stop mounting hardware
1 RE1478 Front alignment washers
2 86-RM22016 2” Rear bump stops
1 HWC10319 Rear bump stop hardware pack
1 86-RM24053 Rear track bar bracket
1 HWC15018 Rear track bar bracket hardware pack
1 35-RM31023 Rear Track Bar Bracket spacer

1 RE1158 Extended Rear Sway Bar End Link Kit
2 RXT2421B Twin Tube Front Shock Extension
2 RXT2420B Twin Tube Rear Shock Extension

RE7133M Spacer Kit (w/RXJ Shocks):

1 RE7133 Spacer Kit:
2 RM40090 2.5” Front coil spacer
2 RM40110 1.75” Rear coil spacer
2 90-RM40520 2” Front bump stop s
2 HW1060 Front bump stop mounting hardware
1 RE1478 Front alignment washers
2 86-RM22016 2” Rear bump stops
1 HWC10319 Rear bump stop hardware pack
1 86-RM24053 Rear track bar bracket
1 HWC15018 Rear track bar bracket hardware pack
1 35-RM31023 Rear Track Bar Bracket spacer

1 RE1158 Extended Rear Sway Bar End Link Kit
2 RXJ713 Rubicon Mono-tube Front Shock
2 RXJ714 Rubicon Mono-tube Rear Shock

Revised

9.3.13