Page 1
UASL
Parts List
30-September-2017
This parts list is current as of the above revision date.
See http://www.rheempartslists.net/92-42801-UASL.pdf for the current revision.
Condensing Units
Page 2
Table of Contents
Model Explanation................................................................................................................... Page 3
Parts Numbers
Panels - Miscellaneous (Granite-Steel Gray) ..................................................................... Page 4
Panels - Miscellaneous (Neutra Green) .......................................................................... Page 5
Electrical Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 6
Fan Group....................................................................................................... Page 7
Coil Parts ....................................................................................................... Page 8
Compressor Group .............................................................................................. Page 9
Accessories .................................................................................................... Page 10
Drawings/Photographs
Exploded View ................................................................................................. Page 11
Control Box Assembly (JAZ) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 12
Control Box Assembly (JEZ, JEC)............................................................................... Page 13
Notes .......................................................................................................................... Page 14
Page 2 of 14
30-September-2017
92-42801-UASL
Page 3
U A S L - 0 2 4 J E Z
(1)TRADEBRAND IDENTIFICATION
(2)MODEL (6)ELECTRICAL DESIGNATION
A= Condensing Unit J= 208-230/1/60
(3)TYPE (7)VARIATIONS
S= Super High Efficiency A= Standard Model
E= Electronic Model
(4)DESIGN SERIES / VARIATION
(8)COMPRESSOR
(5)COOLING CAPACITY Z= Scroll
024= 24,000 BTU/HR C= Scroll/Serial Communicating
025= 24,000 BTU/HR
036= 36,000 BTU/HR
037= 36,000 BTU/HR
039= 39,000 BTU/HR
048= 48,000 BTU/HR
060= 60,000 BTU/HR
6 7 6 1 M 0 1 0 9 0 7 9 9 9
(1) COMPRESSOR IDENTIFICATION NUMBER
(2) PRODUCTION LOCATION
F= Ft. Smith, AR
M= Milledgeville, GA
W= Nuevo Laredo,MX
(3) WEEK OF PRODUCTION
(4) YEAR OF PRODUCTION
(5) PRODUCTION NUMBER
(1) (2) (3) (4) (5) (6) (7) (8)
(1) (2) (3) (4) (5)
MODEL NUMBER EXPLANATION
SERIAL NUMBER EXPLANATION
Page 3 of 14
30-September-2017
92-42801-UASL
Page 4
No.Notes
1 Base Pan AE-58426-83 AE-58426-83 AE-58426-83 AE-58426-83 AE-58426-85 AE-58426-85 AE-58426-85
2 Button Plug 45-22980-07 45-22980-07 45-22980-07 45-22980-07 45-22980-07 45-22980-07 45-22980-07
3 Cabinet AE-100609-87 AE-100609-87 AE-100609-87 AE-100609-87 AE-100609-87 AE-100609-87 AE-100609-87
4 Top Panel AE-100618-85 AE-100618-85 AE-100618-85 AE-100618-85 AE-100618-85 AE-100618-85 AE-100618-85
5 Grille 95-100906-06 95-100906-06 95-100906-06 95-100906-06 95-100906-06 95-100906-06 95-100906-06
6 1 ControlBox - See Note 1 10-102307-05 10-102307-05 10-102307-05 10-102307-05 10-102721-01 10-102721-01 10-102721-01
6a
6a
6b Capacitor Strap AE-50892-51 AE-50892-51 AE-50892-51 AE-50892-51 AE-50892-51 AE-50892-51 AE-50892-51
7 Access Panel AE-100617-87 AE-100617-87 AE-100617-87 AE-100617-87 AE-100617-87 AE-100617-87 AE-100617-87
8 Service Valve - Suction 61-21368-15 61-21368-15 61-21368-15 61-21368-15 61-21368-24 61-21368-24 61-21368-16
9 Service Valve - Liquid 61-101160-13 61-101160-13 61-101160-13 61-101160-13 61-101160-13 61-101160-13 61-101160-13
No.Notes
1 Base Pan AE-58426-83 AE-58426-83 AE-58426-83 AE-58426-83
2 Button Plug 45-22980-07 45-22980-07 45-22980-07 45-22980-07
3 Cabinet AE-100609-87 AE-100609-87 AE-100609-87 AE-100609-87
4 Top Panel AE-100618-85 AE-100618-85 AE-100618-85 AE-100618-85
5 Grille 95-100906-06 95-100906-06 95-100906-06 95-100906-06
6 1 ControlBox - See Note 1 10-102307-03 10-102307-03 10-102307-03 10-102307-03
6a
6a
6b Capacitor Strap AE-50892-51 AE-50892-51 AE-50892-51 AE-50892-51
7 Access Panel AE-100617-87 AE-100617-87 AE-100617-87 AE-100617-87
8 Service Valve - Suction 61-21368-15 61-21368-15 61-21368-15 61-21368-15
9 Service Valve - Liquid 61-101160-13 61-101160-13 61-101160-13 61-101160-13
MODEL
COOLING CAPACITY
VARIATION
Control Box Dust Cover 10-102360-02 10-102360-02 10-102360-02 10-102360-02 10-102360-03 10-102360-03 10-102360-03
Capacitor Adapter Plate (2 in. round
capacitor)
Capacitor Adapter Plate (2 in. x 1-1/4
in. oval capacitor)
Touch-up Paint - Granite/Steel Gray
(Aerosol)
Touch-up Paint - Granite/Steel Gray
(Paint Pens)
MODEL
COOLING CAPACITY
VARIATION
Control Box Dust Cover 10-102360-01 10-102360-01 10-102360-01 10-102360-01
Capacitor Adapter Plate (2 in. round
capacitor)
Capacitor Adapter Plate (2 in. x 1-1/4
in. oval capacitor)
Touch-up Paint - Granite/Steel Gray
(Aerosol)
Touch-up Paint - Granite/Steel Gray
(Paint Pens)
SHEET METAL PARTS,MISCELLANEOUS (Granite/Steel Gray, After Date Code 4811)
SHEET METAL PARTS,MISCELLANEOUS (Granite/Steel Gray, After Date Code 4811)
UASL
-024
JEC
AE-54609-01 AE-54609-01 AE-54609-01 AE-54609-01 AE-54609-01 AE-54609-01 AE-54609-01
AE-54609-02 AE-54609-02 AE-54609-02 AE-54609-02 AE-54609-02 AE-54609-02 AE-54609-02
PD523018 PD523018 PD523018 PD523018 PD523018 PD523018 PD523018
PD523019 PD523019 PD523019 PD523019 PD523019 PD523019 PD523019
UASL
-024
JEZ
AE-54609-01 AE-54609-01 AE-54609-01 AE-54609-01
AE-54609-02 AE-54609-02 AE-54609-02 AE-54609-02
PD523018 PD523018 PD523018 PD523018
PD523019 PD523019 PD523019 PD523019
UASL
-025
JEC
UASL
-025
JEZ
UASL
-036
JEC
UASL
-036
JEZ
UASL
-037
JEC
UASL
-037
JEZ
UASL
-039
JEC
UASL
-048
JEC
UASL
-060
JEC
Page 4 of 14
30-September-2017
92-42801-UASL
Page 5
No.Notes
1 Base Pan AE-58426-03 AE-58426-03 AE-58426-05 AE-58426-05 AE-58426-05
2 Button Plug 45-22980-07 45-22980-07 45-22980-07 45-22980-07 45-22980-07
3 Cabinet AE-100609-07 AE-100609-07 AE-100609-07 AE-100609-07 AE-100609-07
4 Top Panel AE-100618-05 AE-100618-05 AE-100618-05 AE-100618-05 AE-100618-05
5 Grille 95-100906-06 95-100906-06 95-100906-06 95-100906-06 95-100906-06
6 1 ControlBox - See Note 1 10-102307-05 10-102307-05 10-102721-01 10-102721-01 10-102721-01
6a Capacitor Adapter Plate (2 in. round capacitor) AE-54609-01 AE-54609-01 AE-54609-01 AE-54609-01 AE-54609-01
6a Capacitor Adapter Plate (2 in. x 1-1/4 in. oval capacitor) AE-54609-02 AE-54609-02 AE-54609-02 AE-54609-02 AE-54609-02
6b Capacitor Strap AE-50892-51 AE-50892-51 AE-50892-50 AE-50892-50 AE-50892-50
7 Access Panel AE-100617-07 AE-100617-07 AE-100617-07 AE-100617-07 AE-100617-07
8 Service Valve - Suction (Before W1410) 61-21368-15 61-21368-15 61-21368-16 61-21368-16 61-21368-16
8 Service Valve - Suction (On or After W1410) 61-21368-15 61-21368-15 61-21368-24 61-21368-24 61-21368-16
9 Service Valve - Liquid 61-101160-13 61-101160-13 61-101160-13 61-101160-13 61-101160-13
No.Notes
1 Base Pan AE-58426-03 AE-58426-03
2 Button Plug 45-22980-07 45-22980-07
3 Cabinet AE-100609-07 AE-100609-07
4 Top Panel AE-100618-05 AE-100618-05
5 Grille 95-100906-06 95-100906-06
6 Control Box - JAZ models N/A AE-100633-01
6 1 ControlBox - JEZ models - See Note 1 10-102307-03 10-102307-03
6a Capacitor Adapter Plate (2 in. round capacitor) AE-54609-01 AE-54609-01
6a Capacitor Adapter Plate (2 in. x 1-1/4 in. oval capacitor) AE-54609-02 AE-54609-02
6b Capacitor Strap AE-50892-51 AE-50892-51
7 Access Panel AE-100617-07 AE-100617-07
8 Service Valve - Suction (Before M0307) - JAZ models N/A 61-101160-21
8 Service Valve - Suction (On or after M0307) - JAZ models N/A 61-21368-15
8 Service Valve - Suction - JEZ models 61-21368-15 61-21368-15
9 Service Valve - Liquid 61-101160-13 61-101160-13
MODEL
COOLING CAPACITY
VARIATION
SHEET METAL PARTS,MISCELLANEOUS (Neutra Green, Before Date Code 4811)
Control Box Dust Cover 10-102360-02 10-102360-02 10-102360-03 10-102360-03 10-102360-03
Touch-up Paint (Aerosol) 52-18662-48 52-18662-48 52-18662-48 52-18662-48 52-18662-48
Touch-up Paint (Paint Pens) 523010 523010 523010 523010 523010
MODEL
COOLING CAPACITY
VARIATION
SHEET METAL PARTS,MISCELLANEOUS (Neutra Green, Before Date Code 4811)
Control Box Dust Cover - JAZ models N/A AE-101222-01
Control Box Dust Cover - JEZ models 10-102360-01 10-102360-01
Touch-up Paint (Aerosol) 52-18662-48 52-18662-48
Touch-up Paint (Paint Pens) 523010 523010
UASL
-024
JEC
UASL
-024
JEZ
UASL
-036
JEC
UASL
-036
JAZ/JEZ
UASL
-039
JEC
UASL
-048
JEC
UASL
-060
JEC
Page 5 of 14
30-September-2017
92-42801-UASL
Page 6
No.Notes
11 Capacitor - Fan Motor/Compressor See Compressor Group
12 Start Relay See Compressor Group
13 Capacitor - Compressor Start See Compressor Group
14 Stk Control Board - Two Stage (Before W0910)
14 Stk
14 Stk
No.Notes
11 Capacitor - Fan Motor/Compressor See Compressor Group
12 Start Relay See Compressor Group
13 Capacitor - Compressor Start See Compressor Group
14 Stk Control Board 47-102090-02 47-102090-02 47-102090-02 47-102090-02
No.Notes
10 Stk Contactor 42-42728-03
11 Capacitor - Fan Motor/Compressor See Compressor Group
12 Start Relay See Compressor Group
13 Capacitor - Compressor Start See Compressor Group
MODEL
COOLING CAPACITY
VARIATION
CONTROL BOX COMPONENTS:
Control Board - Two Stage (On or After
W0910)
Control Board - Tandem Secondary (On or
After W0910)
Stk Low Ambient Sensor 47-102709-01 47-102709-01 47-102709-01 47-102709-01 47-102709-01 47-102709-01 47-102709-01
Control - Identity EEPROM (Before W0910)
Control - Identity EEPROM (On or After
W0910)
Control - Identity EEPROM (On or After
W0910) -TandemPrimary
Control - Identity EEPROM (On or After
W0910) -TandemSecondary
Terminal Block N/A N/A N/A N/A 45-22246-04 45-22246-04 45-22246-04
Wiring Harness - Fan Motor See FanGroup
1 Wiring Harnesses See Note 1
Wiring Harnesses - 9 pin, 4 wires to 3 quick
connects (BeforeW0910)
Wiring Harnesses - 9 pin, 6 wires to 3 quick
connects and 1 (two pin) connector (On or
After W0910)
Wiring Harnesses - 9 pin, 7 wires to strip
leads (BeforeW0910)
Wiring Harnesses - 9 pin, 7 wires to strip
leads (On or After W0910)
MODEL
COOLING CAPACITY
VARIATION
CONTROL BOX COMPONENTS:
Wiring Harness - Fan Motor See FanGroup
1 Wiring Harnesses See Note 1
MODEL
COOLING CAPACITY
VARIATION
CONTROL BOX COMPONENTS:
Time Delay Relay 42-22756-04
Stk Comfort Alert 42-101504-02
Mounting Bracket - Comfort Alert AE-101503-01
UASL
-024
JEC
47-102090-04
(1)
47-102090-04
(1)
N/A N/A N/A N/A
47-102738-71
(1)
47-102738-71
(1)
N/A N/A N/A N/A
N/A N/A N/A N/A
N/A N/A N/A N/A 45-102134-07 45-102134-07 45-102134-07
N/A N/A N/A N/A 45-102134-09 45-102134-09 45-102134-09
N/A N/A N/A N/A 45-102134-06 45-102134-06 45-102134-06
N/A N/A N/A N/A 45-102134-08 45-102134-08 45-102134-08
UASL
-024
JEZ
UASL
-025
JEC
ELECTRICAL GROUP
N/A
47-102090-08
(1)
47-102738-99
(1)
47-102738-99
(1)
UASL
-025
JEZ
ELECTRICAL GROUP
ELECTRICAL GROUP
47-102090-04
47-102090-04
47-102738-72
47-102738-72
UASL
-036
JEC
(1)
(1)
(1)
(1)
UASL
-036
JEZ
UASL
-036
JAZ
UASL
-037
JEC
N/A
47-102090-08
(1)
47-102738-10
0
(1)
47-102738-10
0
(1)
UASL
-037
JEZ
UASL
-039
JEC
47-102090-04
(2)
47-102090-08
(1)
47-102090-07
(1)
47-102738-73
(2)
N/A N/A N/A
47-102738-80
(1)
47-102738-81
(1)
UASL
-048
JEC
47-102090-04
(2)
47-102090-08
(1)
47-102090-07
(1)
47-102738-74
(2)
47-102738-82
(1)
47-102738-83
(1)
47-102090-04
47-102090-08
47-102090-07
47-102738-75
47-102738-84
47-102738-85
UASL
-060
JEC
(2)
(1)
(1)
(2)
(1)
(1)
Page 6 of 14
30-September-2017
92-42801-UASL
Page 7
No.Notes
15 Stk Fan Motor - ECM 51-102728-08 51-102728-08 51-102728-02 51-102728-02 51-102728-15 51-102728-15 51-102728-15
16 Stk Fan Blade 70-21858-17 70-21858-17 70-21858-17 70-21858-17 70-21858-17 70-21858-17 70-21858-17
No.Notes
15 Stk Fan Motor - ECM 51-101548-08 51-101548-08 51-101548-02 51-101548-02
16 Stk Fan Blade 70-21858-17 70-21858-17 70-21858-17 70-21858-17
MODEL
COOLING CAPACITY
VARIATION
Stk,1 Wiring Harness- Fan Motor 45-102122-01 45-102122-01 45-102122-01 45-102122-01 N/A N/A N/A
Stk,1 Wiring Harnesses- Fan Motor - 6 pin (3 wire) N/A N/A N/A N/A 45-102122-04 45-102122-04 45-102122-04
Stk,1 Wiring Harnesses - Fan Motor - 6 pin (4 wire) N/A N/A N/A N/A 45-102122-03 45-102122-03 45-102122-03
MODEL
COOLING CAPACITY
VARIATION
Wiring Harness - FanMotor (JEZ models) Stk,1
See Note 1
UASL
-024
JEC
UASL
-024
JEZ
45-102122-01 45-102122-01 45-102122-01 45-102122-01
UASL
-025
JEC
FANGROUP
UASL
-025
JEZ
FANGROUP
UASL
-036
JEC
UASL
-036
JAZ/JEZ
UASL
-037
JEC
UASL
-037
JEZ
UASL
-039
JEC
UASL
-048
JEC
UASL
-060
JEC
Page 7 of 14
30-September-2017
92-42801-UASL
Page 8
No.Notes
17 Stk Condenser Coil AS-102419-03 AS-102419-03 AS-59326-03 AS-59326-03 AS-102777-01 AS-102661-01 AS-102661-01
No.Notes
17 Stk Condenser Coil AS-102419-03 AS-102419-03 AS-59326-03 AS-59326-03
MODEL
COOLING CAPACITY
VARIATION
Stk Filter Drier 83-22755-03 83-22755-03 83-22755-03 83-22755-03 83-22755-05 83-22755-05 83-22755-05
High Pressure Control (90 Deg Elbow
Stk
with 1/4 inch connection)
Low Pressure Control (90 Deg Elbow
with 1/4 inch connection)
High Pressure Control (Sraight with
Stk
1/4 inch connection) - before W0311
High Pressure Control (90 Deg Elbow
Stk
with 1/4 inch connection) - on or after
W0311
Low Pressure Control (90 Deg Elbow
Stk
with 5/16 inch connection) - before
W0311
Low Pressure Control (90 Deg Elbow
Stk
with 1/4 inch connection) - on or after
W0311
Low Ambient Sensor See Electrical Group
Distributor w/o Header Tubes - 3-Way
(1/2 in. to 3/8 in.)
Distributor w/o Header Tubes - 3-Way
(3/8 in. to 3/8 in.)
Distributor w/o Header Tubes - 2-Way
(5/8 in. to 1/2 in.)
MODEL
COOLING CAPACITY
VARIATION
Stk Filter Drier 83-22755-03 83-22755-03 83-22755-03 83-22755-03
High Pressure Control (Sraight with
Stk
1/4 inch connection) - before W0311
High Pressure Control (90 Deg Elbow
Stk
with 1/4 inch connection) - on or after
W0311
Stk Low Pressure Control - JAZ models N/A N/A 47-101529-02 N/A
Low Pressure Control (90 Deg Elbow
Stk
with 5/16 inch connection) - before
W0311
Low Pressure Control (90 Deg Elbow
Stk
with 1/4 inch connection) - on or after
W0311
Distributor w/o Header Tubes - 3-Way
(1/2 in. to 3/8 in.)
Distributor w/o Header Tubes - 3-Way
(3/8 in. to 3/8 in.)
UASL
-024
JEC
N/A N/A N/A N/A 47-26184-04 47-26184-04 47-26184-04
N/A N/A N/A N/A 47-101529-08 47-101529-08 47-101529-08
47-26184-01 N/A 47-26184-01 N/A N/A N/A N/A
47-103669-01 47-103669-01 47-103669-01 47-103669-01 N/A N/A N/A
47-101529-04 N/A 47-101529-04 N/A N/A N/A N/A
47-103670-02 47-103670-02 47-103670-02 47-103670-02 N/A N/A N/A
83-17467-06 83-17467-06 83-17467-06 83-17467-06 N/A N/A N/A
83-17467-07 83-17467-07 83-17467-07 83-17467-07 N/A N/A N/A
N/A N/A N/A N/A 83-41634-01 83-41634-01 83-41634-01
UASL
-024
JEZ
47-26184-01 N/A 47-26184-01 N/A
47-103669-01 47-103669-01 47-103669-01 47-103669-01
47-101529-04 N/A 47-101529-04 N/A
47-103670-02 47-103670-02 47-103670-02 47-103670-02
83-17467-06 83-17467-06 83-17467-06 83-17467-06
83-17467-07 83-17467-07 83-17467-07 83-17467-07
UASL
-025
JEC
COIL GROUP
UASL
-025
JEZ
COIL GROUP
UASL
-036
JEC
UASL
-036
JAZ/JEZ
UASL
-037
JEC
UASL
-037
JEZ
UASL
-039
JEC
UASL
-048
JEC
UASL
-060
JEC
Page 8 of 14
30-September-2017
92-42801-UASL
Page 9
No.Notes
18 Stk Compressor 55-23156-08S 55-23156-35S 55-23156-09S 55-23156-36S N/A N/A N/A
18 Stk Compressor - Tandem Assembly N/A N/A N/A N/A AS-102714-01 AS-102714-02 AS-102714-03
11 Stk Capacitor - Compressor Run
12 Stk Start Relay 42-100491-09 42-100491-09 42-100491-09 42-100491-09 42-100491-09 42-100491-09 42-100491-09
13 Stk Start Capacitor 43-17075-04 43-17075-04 43-17075-04 43-17075-04 43-17075-04 43-17075-04 43-17075-04
No.Notes
18 Stk Compressor 55-23156-08S 55-23156-35S 55-23156-09S 55-23156-36S
11 Stk Capacitor - Compressor Run 43-100510-23 43-101666-20 43-101666-24 43-101666-24
12 Stk Start Relay 42-18282-09 42-18282-09 42-18282-09 42-18282-09
13 Stk Start Capacitor 43-17075-04 43-17075-04 43-17075-04 43-17075-04
MODEL
COOLING CAPACITY
VARIATION
Compressor ID: 7686 8615 7234 8616 7834 7835 7836
Compressor Wiring Harness (Line
Stk,1
Voltage- Molded Plug) - See Note 1
Compressor Wiring Harness (Low
Stk,1
Voltage- Molded Plug) - See Note 1
MODEL
COOLING CAPACITY
VARIATION
Compressor ID: 7686 8615 7234 8616
Compressor Wiring Harness (Line
Stk
Voltage- Molded Plug) - JAZ models
Compressor Wiring Harness (Line
Stk,1
Voltage- Molded Plug) - JEZ models
- See Note 1
Compressor Wiring Harness (Low
Stk,1
Voltage- Molded Plug) - See Note 1
UASL
-024
JEC
45-100834-04
(1)
45-101723-01 45-101723-01 45-101723-01 45-101723-01 N/A N/A N/A
43-101666-23
(1)
UASL
-024
JEZ
N/A N/A 45-100834-02 N/A
45-100834-07 45-100834-07 45-100834-07 45-100834-04
45-101723-01 45-101723-03 45-101723-01 45-101723-03
UASL
-025
JEC
COMPRESSOR GROUP
45-100834-04
(1)
43-101666-20
(1)
UASL
-025
JEZ
COMPRESSOR GROUP
UASL
45-100834-04
43-101666-24
UASL
JAZ/JEZ
-036
JEC
(1)
(1)
-036
UASL
-037
JEC
45-100834-04
(1)
43-101666-24
(1)
UASL
-037
JEZ
UASL
-039
JEC
45-100834-80
(2)
43-100510-36
(2)
UASL
-048
JEC
45-100834-80
(2)
43-100510-20
(2)
UASL
-060
JEC
45-100834-80
(2)
43-101666-24
(2)
Page 9 of 14
30-September-2017
92-42801-UASL
Page 10
No. Notes
Low Ambient Control RXAD-A08
MODEL
VARIATIONS
ACCESSORIES
UASL
ALL
Page 10 of 14
30-September-2017
92-42801-UASL
Page 11
Exploded View
Page 11 of 14
30-September-2017
92-42801-UASL
Page 12
Control Box Assembly (JAZ)
Page 12 of 14
30-September-2017
92-42801-UASL
Page 13
Control Box Assembly (JEZ, JEC)
Page 13 of 14
30-September-2017
92-42801-UASL
Page 14
NOTES
Stk It is recommended that stock be maintained for this part.
N/A Not Applicable
1 Wiring Harnesses not listed individually are included with the JEZ, JEC model Control Box (item 6).
P.O. Box 17010
Fort Smith, AR 72917-7010