120V Lithium Ion Cordless Hedge Trimmer
Operation Manual
This safety alert symbol identies important safety messages in
this manual. Failure to follow this important safety information may
!
result in serious injury or death.
MODELS # 106489
Part # 106661 Rev A
For Service or Questions
Call 1-877-487-8275
720-287-5182
www.redbackpowerusa.com
Redback products are distributed by
1100 W 120th Ave, Suite 600
Westminster, CO 80234 • 720-287-5182
Table of Contents
Important Safety Information
Intended Use ...........................................................................................4
Personal Protective Equipment ...........................................................4
General Safety ........................................................................................5
Safety Icons ............................................................................................6
Attaching the Battery ................................................................................7
Overview of Components .........................................................................8
Operation.....................................................................................................9
Maintenance ............................................................................................10
Storage ......................................................................................................11
Warranty & Specifications .................................................. Back Cover
3
Important Safety Information
!
WARNING
WARNING: Read and thoroughly understand all instructions and
safety information before assembling or operating the hedge
trimmer. Failure to do so may cause serious injury or death. Do
not allow anyone to operate this hedge trimmer who has not read
this manual. As with all power equipment, a hedge trimmer can be
dangerous if assembled or used improperly. Do not operate this
hedge trimmer if you have doubts or questions concerning safe
operation.
Call our customer service department at 720-287-5182,
1-877-487-8275, or visit www.redbackpowerusa.com if you
have any questions or concerns about the safe operation of this
equipment.
!
DANGER
Intended Use
The hedge trimmer has been designed for cutting and trimming
hedges and bushes which have a maximum branch thickness of 22
mm (55/64”) and it is not suitable for work above shoulder height.
Do not use the hedge trimmer for any purpose other than for which
it was designed. Any other use is unauthorized and may result in
serious injury or death.
Personal Protective Equipment
When operating this hedge trimmer it is essential that you wear
safety gear including goggles or safety glasses, steel-toed shoes
and tight tting gloves (no loose cuffs or draw strings). Always
wear ear plugs or sound deafening headphones to protect against
hearing loss when operating this mower. Always wear sturdy
footwear. Never wear sandals, sneakers or open shoes, and never
operate the hedge trimmer with bare feet. Do not wear loose
clothing that might get caught in moving parts.
4
Important Safety Information
General Safety
Failure to follow warnings, cautions, assembly and operation
instructions in the Operation Manual may result in serious injury or
death.
!
DANGER
READ THE OPERATION MANUAL BEFORE OPERATION.
• Do not permit children to operate this equipment at any time.
• Do not permit others that have not read and understood the
complete Operation Manual to operate this equipment.
• Observe the area of operation and ensure there are no obstacles
in the hedge trimmer’s path.
• Do not operate the hedge trimmer when under the inuence of
alcohol, drugs or medication.
• Do not allow a person who is tired or otherwise impaired or not
completely alert to operate the hedge trimmer.
!
DANGER
• Do not operate the hedge trimmer in rain or other wet conditions.
Protect the hedge trimmer from rain.
• Keep hands, feet, hair and clothing away from the hedge trimmer.
• The battery should be removed before attempting to remove
clippings from the blades, or before making any repairs.
• Carry the hedge trimmer by the handle only. Blades are sharp!
Battery tool use and care
• Recharge only with the charger specied by the manufacturer. A
charger that is suitable for one type of battery pack may create a
risk of re when used with another battery pack.
• Use power tools only with specically designated battery packs.
Use of any other battery packs may create a risk of injury and re.
• When battery pack is not in use, keep it away from other metal
objects, like paper clips, coins, keys, nails, screws or other small
metal objects, that can make a connection from one terminal to
another. Shorting the battery terminals may cause burns or a re.
• Under certain conditions, liquid may be ejected from the battery;
avoid contact. If contact accidentally occurs, ush with water. If
liquid contacts eyes, additionally seek medical help. Liquid ejected
from the battery may cause irritation or burns.
• DO NOT USE BATTERIES WITH DAMAGED CASES. Dispose of
batteries properly. Do not dispose of batteries in household waste.
5
Important Safety Information
!
Safety Icons
Safety icons are to remind you of important information while you
are operating the unit.
Use caution when operating this power
equipment
A hedge trimmer can eject objects at
high speeds. Use caution when operating
around other people and pets.
Use caution when handling, dangerous
pinch points!
Use caution around rotating parts!
Do not touch the blades duting operation.
Read and understand the Operation
Manual before operating the hedge
trimmer.
A hedge trimmer can eject objects at high
speeds. Use caution when operating near
walls, fences, wires and other obstacles.
Wear goggles or other eye protection.
The hedge trimmer can propel objects
and dust.
Avoid operating in the rain, protect the
battery and hedge trimmer from wet
conditions.
Safety Decals
Safety decals on the hedge trimmer are to remind you of
important information while you are operating the unit. Make
sure all decals are attached and in readable condition. Replace
missing or defaced decals. Contact Redback USA at 1-877-4878275 for replacement decals.
6
Attaching the Battery
Before operating the hedge trimmer, fully charge the battery.
Inserting/Replacing the Battery
Charge the battery as described in the charger operation manual.
Press the charged battery into the power tool until it clicks into
place (see Figure 1).
To remove the battery, press the release button 1 and pull out the
battery 2 (see Figure 2).
Figure 1
Figure 2
!
2
Protect the battery contacts when the battery is not being used.
Metal objects may short-circuit the contacts and pose
both an explosion and fire hazard!
1
CAUTION
7
Overview of Components
BATTERY
RECEPTACLE
VENTILATION
OPENINGS
CUTTING
BLADES
REAR HANDLE
RELEASE
SWITCH
LOCK
POWER
SWITCH
SAFETY
HANDLEBAR
SWITCH
SHIELD
REAR
SWIVELING
HANDLEBAR
IMPACT
GUARD
8
BLADE
SHEATH
Operation
2
Figure 3
3
1
Figure 4
1
2
Adjusting the Rear Handle
Depending on the planned use the rear handle can be rotated from
the middle position by 90° in either direction (see Figure 3). Press
the release button downwards 1 and simultaneously rotate the
rear handle to the left or right 2 until it clicks.
NOTE: The hedge trimmer will not turn on when the rear handle is
not securely engaged in the respective end position.
Powering the Hedge Trimmer
The hedge trimmer is switched on and operated with both hands.
One hand operates the switch on the rear handle, the second hand
the safety switch on the handlebar. If you release one of the two
switches, the cutter bar automatically stops.
Switching on
Hold the hedge trimmer rmly with both hands (see Figure 4). Press
and hold down the switch interlock
the safety switch 3. The hedge trimmer runs.
Switching off
Release one of the two switches (see Figure 5). The cutter bar
stops immediately. Wait until all rotating parts have stopped. Place
the blade sheath on the cutter bar.
. Press the switch
1
2
and
Figure 5
Hedge Trimming
Always cut at full engine speed. The impact guard protects against
the recoil torque of the cutter when striking a solid object. Cut the
upper edges of the hedge slightly round. Cut in several stages if
heavy trimming is required.
If cutting hedges over a prolonged period, interrupt your work
frequently and oil the cutting bar.
Switch the engine off and remove the battery to remove jammed
clippings from the cutting blades.
The hedge trimmer can be guided with its double-sided cutters
forwards and backwards or in an oscillating movement from one
side to the other. Cut the sides of the hedge rst and then the top.
When cutting sideways, rotate the rear handlebar sideways.
When cutting down low, hold the handlebar above. Cut the hedge
from bottom to top. Hold the hedge trimmer at an angle of 5–10° to
the hedge to ensure a straight cut.
9
Maintenance
!
CAUTION
Before performing any maintenance on the hedge trimmer,
remove the battery and wear protective gloves.
Cleaning the Hedge Trimmer
Remove the battery. Do not use water or liquid detergents.
Whenever possible, always clean the unit directly after using
with a hand brush.
Keep the ventilation slots clean and dust-free.
After each use, clean the hedge trimmer using a dry cloth
or a brush if the unit is very dirty. Never spray the hedge
trimmer with water.
Clean the cutting blades after each use. Spray or wipe the
cutting blades with a light machine oil to ensure that the
hedge trimmer has a long service life.
Repairs
Check the unit for damage. Repairs may be carried out by an
authorized customer service center only.
10
Storage
Storage
Remove the battery from the hedge trimmer before storing. Store
the hedge trimmer in a dry, dust-free and frost-free place ideally in
a temperature range of 50° - 77°F (10-25 °C).
Store the battery and the unit separately.
Place the blade sheath over the trimmer blades for protection.
Charge the battery before storing the unit in winter.
Keep the unit, in particular its plastic components, away from brake
uids, petrol, petroleum products, penetrating oil, etc. They contain
chemical substances which may damage, attack or destroy the
plastic components of the unit.
Remove the battery from the hedge trimmer when not in use.
Disposal Information
Recycle raw materials instead of disposing as waste.
Battery, accessories and packaging should be recycled in an
environmentally friendly manner. Plastic parts are identied for
recycling according to material type.
!
CAUTION
Do not use batteries with damaged casing.
Do not attempt to open batteries.
Do not dispose of in fire, water or household waste.
11
Warranty & Specications
IMPORTANT NOTICE
We, the manufacturer, reserve the right to change the product and/
or specications in this manual without notication. The manual is for
information usage only and the pictures and drawings depicted herein are
for reference only.
Warranty Repair and Service
Do not return this product to the store for warranty issues or repair. Call
our customer service department at 720-287-5182, 1-877-487-8275, or visit
www.redbackpowerusa.com for the location of the nearest service center.
Record the information below for future reference.
Model No.
Serial No.
Date of Purchase
Place of Purchase
SKU/Part No. 106489
Description 120V Lithium Ion Cordless Hedge Trimmer
Rated Voltage 120 Volts DC
Stroke Rate 1500/minute (no load)
Blade Length 24 Inches (610mm)
Cutting Thickness 55/64” (22mm)
Sound Rating 88.4 dB (A)
Shipping Weight 8.36 Lbs. (w/o battery)
Battery 2.0Ah (included)
Battery Charger 1.5A Charger (included)
Run Time Up to 75 minutes/charge
Warranty 5-Year Limited Warranty, 1-Year on Battery
Redback products are distributed by
1100 W 120th Ave., Suite 600
Westminster, CO 80234 • 720-287-5182
For Service or Questions
Call 1-877-487-8275
720-287-5182
www.redbackpowerusa.com
Loading...