Redarc R-12-350S, R-24-350S, R-12-700S, R-24-700S, R-12-1000S User Manual
...
Pure Sine Wave Inverters
R-12-350S/R-24-350S
R-12-700S/R-24-700S
R-12-1000S/R-24-1000S
R-12-1500S/R-24-1500S
R-12-2000S/R-24-2000S
R-12-3000S/R-24-3000S
REDARC PURE SINE INVERTERS
REDARC Pure Sine Wave Inverters produce a pure sine wave output. This means that the power
output from a REDARC Pure Sine Wave Inverter is not only the same as the mains supply... it’s
often better!
WARNING & SAFETY INSTRUCTIONS
This appliance is not intended for use by persons (including children) with reduced physical,
sensory or mental capabilities, or lack of experience and knowledge, unless they are supervised
or have been instructed on how to use the appliance by a person responsible for their safety.
Children should be supervised to ensure that they do not play with the appliance.
Do NOT disassemble the (Product) - the internal circuitry contains hazardous voltages. Attempting
to service the unit yourself may result in electric shock or fi re and will void the unit warranty.
Do not expose the inverter to rain, snow, spray, bilge or dust. To reduce the risk of hazard, do
not cover or obstruct the ventilation openings. Do not install the inverter in a zero-clearance
compartment. Overheating may result.
To avoid a risk of fi re and/or electronic shock, make sure that existing wiring is in good condition
and not undersized.Do not operate the inverter with damaged or substandard wiring.
Some components in the inverter can cause arcs and sparks. To prevent fi re or explosion, do
not put batteries, fl ammable materials, or anything that should be ignition–protected around the
inverter.
If battery acid contacts skin or clothing, you must wash it out with soap and water immediately.
If battery acid contacts your eyes, you must wash it out with cold running water for at least 20
minutes and get medical attention immediately.
Never smoke or make a spark or fl ame in the vicinity of the battery or the engine.
Do not drop a metal tool on the battery. The resulting spark or short-circuit on the battery or
other electrical part may cause an explosion.
Remove personal metal items such as rings, bracelets, necklaces, and watches when operating
with a lead-acid batteries.
Failure to do so may cause short circuit and very high temperature, which can melt metal items
and burn your skin.
SAL.FOR.Instruction Manual.Pure Sine Inverters – DOC435 – Version 1
1
CONTENTS
Table of Contents Page
Warnings and Safety Instructions 01
Contents 02
1 Introduction 03
1. 12V Specifi cations 03
2. 24V Specifi cations 04
3. Dimensions 05
2 USER Guide 06
1. Front Panel Operation 06
1. Front Panel View 06
2. On/Off/Remote Switch (700W - 3000W) 07
3. Input Level LED Display (700W - 3000W) 07
4. Load Level Display (700W - 3000W) 07
5. Status LED Displayc (All Models) 08
6. Power Saving Mode Settings (700W - 3000W) 08
7. AC Frequency Setting (All Models) 09
2. Rear Panel Operations 09
1. Rear Panel View 09
2. On/Off/Remote Switch (350W Only) 10
3. Remote Port (700W - 3000W) 10
4. Ventilation Fan 10
5. DC Input Terminal (All Models) 11
6. Chassis Ground 11
3 INSTALLATION Guide 12
1. Mounting 12
2. DC Wiring Connections (700W - 3000W) 12
1. DC Cable Size 13
3. Wiring Diagrams 14
4. DC Cable Connection (700W - 3000W) 15
1. 700W - 1500W DC Connection method 15
2. 2000W - 3000W DC Connection method 15
5. AC Safety Grounding 16
6. Inverter First Operation 16
7. Maintenance 16
4 Troubleshooting 17
5 Two Year Warranty 18
2
1 INTRODUCTION
1.1 12V Specifi cations
Specifi cation R-12-350S R-12-700S R-12-1000S R-12-1500S R-12-2000S R-12-3000S
Output Power (Cont.)
Output Power (Max.)
Surge Rating (Max.)
Input Voltage (Nom.)
Input Voltage (Min.)
Input Voltage (Max.)
Output Voltage
Frequency
Output Waveform
Effi ciency (full load)
No Load Current Draw
Stand-By Current Draw
Input Voltage Regulation
Input Level Indicator
350W 700W 1000W 1500W 2000W 3000W
385W 770W 1100W 1650W 2200W 3300W
700W 1400W 2000W 3000W 4000W 6000W
12V 12V 12V 12V 12V 12V
10.5V 10.5V 10.5V 10.5V 10.5V 10.5V
15V 15V 15V 15V 15V 15V
220/ 230/ 240V AC ± 3%
50 / 60Hz ± 0.05%
Pure Sine Wave (THD < 3%)
91.0% 91.0% 91.0% 90.0% 91.0% 90.0%
1.20A 1.25A 1.40A 2.64A 2.80A
0.25A 0.25A 0.28A 0.60A 0.55A
10.5V - 15.0V
N/A Red/ Orange/ Green LEDs
Load Level Indicator
Failure Indicator
Protection
Remote Control Unit
Safety Certifi cate
EMC
Operating Temp.
Cooling
Protection Features for 12V Inverters
Over Voltage Shutdown
Over Voltage Restart
Under Voltage Alarm
Under Voltage Shutdown
Under Voltage Restart
N/A Red/ Orange/ Green LEDs
Overload, Short Circuit, Reverse Polarity (Fuse), Over/Under Voltage, Over Temp.
Hardwire CR-6 12 / CR-8
EN55022:1997, EN55024: 1997, EN61000-3-2: 1998, EN61000-3-3: 1995
Red LED
EN60950-1
0 - 40°C
Loading Controlled Cooling Fan
15.3V
14.3V
11.0V
10.2V
12.7V
Over Temperature Shutdown (Interior)
Over Temperature Restart (Interior)
Over Temperature Shutdown (Heat Sink)
Over Temperature Restart (Heat Sink)
70°C
45°C
90°C
60°C
3
1 INTRODUCTION
1.2 24V Specifi cations
Specifi cation R-24-350S R-24-700S R-24-1000S R-24-1500S R-24-2000S R-24-3000S
Output Power (Cont.)
Output Power (Max.)
Surge Rating (Max.)
Input Voltage (Nom.)
Input Voltage (Min.)
Input Voltage (Max.)
Output Voltage
Frequency
Output Waveform
Effi ciency (full load)
No Load Current Draw
Stand-By Current Draw
Input Voltage Regulation
Input Level Indicator
350W 700W 1000W 1500W 2000W 3000W
385W 770W 1100W 1650W 2200W 3300W
700W 1400W 2000W 3000W 4000W 6000W
24V 24V 24V 24V 24V 24V
21.0V 21.0V 21.0V 21.0V 21.0V 21.0V
30V 30V 30V 30V 30V 30V
220/ 230/ 240V AC ± 3%
50 / 60Hz ± 0.05%
Pure Sine Wave (THD < 3%)
93.0% 93.0% 94.0% 93.0% 94.0% 93.0%
0.60A 0.65A 0.70A 1.32A 1.50A
0.15A 0.15A 0.15A 0.25A 0.35A
21.0 - 30.0V
N/A Red/ Orange/ Green LEDs
Load Level Indicator
Failure Indicator
Protection
Remote Control Unit
Safety Certifi cate
EMC
Operating Temp.
Cooling
Protection Features for 24V Inverters
Over Voltage Shutdown
Over Voltage Restart
Under Voltage Alarm
Under Voltage Shutdown
Under Voltage Restart
N/A Red/ Orange/ Green LEDs
Overload, Short Circuit, Reverse Polarity (Fuse), Over/Under Voltage, Over Temp.
Hardwire CR-6 24 / CR-8
EN55022:1997, EN55024: 1997, EN61000-3-2: 1998, EN61000-3-3: 1995
Red LED
EN60950-1
0 - 40°C
Loading Controlled Cooling Fan
30.6V
28.8V
22.0V
20.3V
25.2V
Over Temperature Shutdown (Interior)
Over Temperature Restart (Interior)
Over Temperature Shutdown (Heat Sink)
Over Temperature Restart (Heat Sink)
70°C
45°C
90°C
60°C
4
1 INTRODUCTION
1.3 Dimensions
F
G
A
C
E
B
D
Dimension 350S 700S 1000S 1500S 2000S 3000S
A 180mm 270mm 340mm 370mm 370mm 400mm
B 125mm 150mm 150mm 160mm 180mm 180mm
C 60mm 70mm 85mm 85mm 165mm 165mm
D 145mm 175mm 180mm 190mm 210mm 210mm
E 132mm 195mm 195mm 195mm 245mm 245mm
F 135mm 160mm 165mm 175mm 195mm 195mm
G 6mm 8mm 8mm 8mm 9mm 9mm
5
Loading...