R&D Batteries Lithium CR User Manual

Article Safety Data Sheet - Lithium Batteries 1)

Edition date: February 05, 2009
Version: 09-02

RENATA SA
Kreuzenstrasse 30
CH-4452 ITINGEN / Switzerland
Tel: [phone]
Fax: [phone]

Section I - Product identification

Product Name: Primary (non-rechargeable) Lithium Battery Nominal Voltage: 3.0 V

Models: Coin Type Cells CR Series see Annex I

Chemical System: Manganese Dioxide Lithium Primary Designated for Recharge: No

Section II - Hazardous ingredients

IMPORTANT NOTE: The battery should not be opened or exposed to heat because exposure of the following
ingredients contained within could be harmful under some circumstances.

Chemical Name CAS No. Content % of total weight

Manganese Dioxide (MnO2) 1313-13-9 17 - 48
Lithium*

7439-93-2 1.1 - 3.3

Propylene Carbonate (PC) 108-32-7 3 - 9
1,2 dimethoxy ethane (DME) 110-71-4 1 - 3.5
Lithium Perchlorate (LiClO4) 7791-03-9 0.2 - 0.8

* Approximate weight content of lithium in each model can be found in Annex I

1) This Article Safety Data Sheet is provided as a service to our customers.

Based on the definition of the term 'article' in the Occupational Safety and Health Administration (OSHA) Hazard Communication Standard, 29
CFR Subpart 1910.1200, there is no requirement for a Material Safety Data Sheet (MSDS) for lithium primary coin cells. Notification is not
required because these products are 'articles' that do not release a covered toxic chemical under the normal conditions of processing or use.

Disclaimer:
The batteries are exempt articles and are not subject to hazard Communication Standard Requirement. This
sheet is provided as technical information only. The information contained in this Product Safety Data Sheet
has been established to the best of RENATA SA's knowledge and belief. RENATA SA makes no
representation and provides no warranty or guarantee regarding the contents of this Product Safety Data
Sheet and excludes its liability, express or implied.

Renata SA Tel. [phone] [e-mail]
CH-4452 Itingen/Switzerland Fax. [phone] www.renata.com

The information and recommendations set forth are made in good faith and believed to be accurate as of the date of preparation. RENATA S.A. makes no warranty, expressed or implied, with
respect to this information and disclaims all liabilities from reliance on it.

Article Safety Data Sheet - Lithium Batteries Version: 09-02 /

Page 1 of 10

Section III - Possible Hazards

The chemicals mentioned in Section II are contained in a sealed can.
Risk of exposure occurs only if the battery is mechanically or electrically abused
(see Safety precautions in Section VII).

The most likely risk is acute exposure when a cell vents.
DME is believed to be slightly to moderately toxic, PC moderately toxic.
LiClO4 is irritating to skin, eyes and mucous membranes.
Lithium can cause thermal and chemical burns upon contact with the skin.

Contact with electrolyte and extruded lithium with skin and eyes should be avoided.

Section IV - First Aid Procedures

None unless internal material exposure.

Skin contact:
Skin contact with contents of an opened battery can cause irritation, flush immediately with copious amounts of
water. Remove contaminated clothing. If irritation persists, get medical help
Eye contact:
Contents of an opened battery can cause severe irritation, flush immediately thoroughly with copious amounts of
water for at least 15 minutes. Get medical attention immediately.
Inhalation:
Do not inhale leaked material. Provide immediately fresh air, if irritation persists, get medical help.

Section V - Fire Fighting Instructions

Flash point of electrolyte solvents (°C): DME: -6°C, PC: 123°C Mixture: 20°C
Extinguishing Media: see Special Fire Fighting Procedure
Flammable Limits: Not available
Special Fire Fighting Procedure: In case of fire in an adjacent area, use water. CO2 or dry chemical

extinguishers if cells are packed in their original containers since the fuel of
the fire is basically paper products.
For bulk quantities of unpackaged cells use for example LITH-X (Graphite
Base). In this case, do not use water.

In a small room, remember that the supply of oxygen is quickly consumed

in feeding a lithium fire.
As with any fire, wear self-contained breathing apparatus to avoid
inhalation of hazardous decomposition products.

Section VI - Accidental Release

Steps to be taken in case material is released or spilled:

The preferred response is to leave the area and allow the batteries to cool and the vapours to dissipate. Avoid
skin and eye contact or inhalation of vapours. Collect all released material in a plastic lined metal container
and remove spilled liquid with absorbent. Doing this, protect your skin and eyes with gloves and protection
glasses. Avoid direct contact with internal components.

Renata SA Tel. [phone] [e-mail]
CH-4452 Itingen/Switzerland Fax. [phone] www.renata.com

The information and recommendations set forth are made in good faith and believed to be accurate as of the date of preparation. RENATA S.A. makes no warranty, expressed or implied, with
respect to this information and disclaims all liabilities from reliance on it.

Article Safety Data Sheet - Lithium Batteries Version: 09-02 /

Page 2 of 10

Section VII - Handling and Storage

When used correctly, lithium batteries provide a safe and dependable source of power. However, if they are
misused or abused, leakage, venting, or in extreme cases explosion and/or fire may result.

Make sure to observe amongst others, following warnings.

Handling:

− Do not insert batteries in reverse. Observe the polarity markings on battery and equipment

− Do not short-circuit batteries

− Do not charge batteries

− Do not force discharge batteries

− Do not mix batteries

− Do not overheat batteries by exposure to high temperatures and direct sunlight.

− Do not weld or solder directly to batteries

− Do not dismantle batteries

− Do not deform batteries

− Do not dispose of batteries in fire

− A battery with a damaged container should not be exposed to water

− Do not allow children to replace batteries without adult supervision

− Keep batteries out of the reach of children. In case of ingestion of a cell or battery, the person involved should

seek medical assistance promptly.

− Equipment intended for use by children should have battery compartments which are tamper-proof

− Do not encapsulate and/or modify batteries

− Exhausted batteries should be immediately removed from equipment and disposed of (see section XIII)

− When discarding batteries with solder tags, insulate the tags by wrapping them with tape, foil, etc.

Storage:

− Store unused batteries in their original packaging and keep them away from metal objects which may short-
circuit them. Storing unpackaged cells together could result in cell shorting and heat build-up.

− Store and display batteries in there original packaging in well ventilated, dry and cool conditions.

− Avoid storing or display batteries in direct sun or in places where they get exposed to rain

− Do not stack battery cartons on top of each other exceeding a specified height. The height is clearly dependent

on the strength of the packaging. As for general rule this height should not exceed 1.5 m for cardboard
packages or 3 m for wooden cases. The above recommendations are equally valid for storage conditions during
prolonged transit. Thus, batteries should be stored away from ship engines and not left for long periods in
unventilated metal box cars (containers) during summer.

Section VIII - Exposure Controls / Personal Protection

Respiratory protection (specify type): Not necessary under conditions of normal use.

Ventilation: Not necessary under conditions of normal use.

Protective gloves: Not necessary under conditions of normal use.

Eye protection: Not necessary under conditions of normal use.

Other protective clothing or equipment: Not necessary under conditions of normal use.

Renata SA Tel. [phone] [e-mail]
CH-4452 Itingen/Switzerland Fax. [phone] www.renata.com

The information and recommendations set forth are made in good faith and believed to be accurate as of the date of preparation. RENATA S.A. makes no warranty, expressed or implied, with
respect to this information and disclaims all liabilities from reliance on it.

Article Safety Data Sheet - Lithium Batteries Version: 09-02 /

Page 3 of 10

Section IX - Physical and Chemical Properties

The chemicals mentioned in Section II are contained in a sealed battery can.
Under conditions of normal use, the chemicals will not be released.

Section X - Stability and Reactivity

Lithium batteries are contained in a stable steel container and are sealed to avoid any chemical release under
conditions of normal use.

Conditions to avoid: See Section VII

Section XI - Toxicological Information

Swallowing:

Ingestion of a battery can be harmful. For US call The National Capital Poison Control Center (1-800-222-1222) day
or night - for advice and follow-up. For other countries please contact the local Tox Centers.

Section XII - Ecological Information

The chemicals mentioned in Section II are contained in a sealed battery can.
Under conditions of normal use, the chemicals will not be released.
It does not pose a physical or health risk to users, see section XIII for disposal.

Section XIII - Disposal Considerations

Waste disposal method:

a) Be sure to comply with your federal, state and local regulation disposal of used batteries.

Dispose in accordance with appropriate national and international regulations, below some references.

European Community: according to Directive 2002/96/EC on Waste Electrical and Electronic Equipment
(WEEE), Annex II, batteries have to be removed from any separately collected
WEEE. The removed batteries have to be treated according to the Battery directive
2006/66/EC

US: Lithium batteries are neither specifically listed nor exempted from the Federal

Environmental Protection Agency (US EPA) hazardous waste regulations. The only
material of possible concern due to its reactivity is lithium metal. However, button
cells contain so little lithium that they can be disposed off in the normal municipal
waste stream.

Use a professional disposal firm for disposal of mass quantities of
undischarged lithium batteries.

b) Open cells should be treated as hazardous waste

DO NOT INCINERATE or subject battery cells to temperatures in excess of 212°F (100°C). Such treatment can
cause cell rupture.

Renata SA Tel. [phone] [e-mail]
CH-4452 Itingen/Switzerland Fax. [phone] www.renata.com

The information and recommendations set forth are made in good faith and believed to be accurate as of the date of preparation. RENATA S.A. makes no warranty, expressed or implied, with
respect to this information and disclaims all liabilities from reliance on it.

Article Safety Data Sheet - Lithium Batteries Version: 09-02 /

Page 4 of 10

Section XIV - Transportation Information

XIV.I Provisions for the international transportation (pursuant to ICAO-TI/IATA-DGR, IMDG Code, ADR, RID,
DOT):

Lithium cells and batteries are subject to:

Area Method Organization

International Air IATA, ICAO Packing Instruction 968 - Part 1
Europe Road and Rail ADR / RID SP188
International Marine IMDG SP188
U.S.A Rail, Road, Marine DOT DOT 49 CFR Section 173.185

Their regulations are based on the UN Recommendations. Each special provision provides specifications on exceptions and
packaging for lithium batteries shipping. All CR batteries of Renata AG meet all special provisions.

Summary of Packing Instruction (IATA Dangerous Goods Regulations 50th Edition):

The minimum requirements necessary to transport as partly regulated goods are as follows;

1) For a lithium metal or lithium alloy cell, the lithium content is not more than 1g. For a lithium metal or lithium alloy battery,
the aggregate lithium content is not more than 2g.

2) Each cell or battery is of the type proven to meet the requirement of each test in the UN Manual of Tests and Criteria,
Part III, subsection 38.3.

3) Each consignment must be accompanied with a certification that the goods meet the conditions for transportation as
"partly regulated" (Specimen See Annex IV).

4) Each package must be displayed a battery handling label (Specimen See Annex V).

5) Each package must be capable of withstanding a 1.2 m drop test.

However, if they meet the following requirements of Special Provision 188 of the UN Model Regulations, Packing
Instruction 968 IATA/ICAO, Special Provision 310 of the IMDG Code, Special Provision 188 of the ADR and RID
(Road and Rail Europe), they are not subject to other provisions of the above mentioned regulations:

(a) For a lithium metal or lithium alloy cell, the lithium content is not more than 1 g
(b) For a lithium metal or lithium alloy battery the aggregate lithium content is not more than 2 g
(c) Each cell or battery is of the type proved to meet the requirements of each test in the Manual of Tests and

Criteria, Part III, sub-section 38.3;

(d) Cells and batteries are separated so as to prevent short circuits and are packed in strong packaging,

except when installed in equipment; and

(e) Except when installed in equipment, each package containing more than 24 lithium cells or 12 lithium

batteries shall in addition meet the following requirements:

(i) Each package shall be marked indicating that it contains lithium batteries and that special procedures

should be followed in the event that the package is damaged (Specimen see Annex II).;

(ii) Each shipment shall be accompanied with a document indicating that packages contain lithium

batteries and that special procedures should be followed in the event a package is damaged
(Specimen see Annex IV);

(iii) Each package is capable of withstanding a 1.2 m drop test in any orientation without damage to cells

or batteries contained therein, without shifting of the contents so as to allow battery to battery (or cell to
cell) contact and without release of contents; and

(iv) Individual packages may not exceed 2.5 kgG and must be labelled with handling label.

Special Provision

Renata SA Tel. [phone] [e-mail]
CH-4452 Itingen/Switzerland Fax. [phone] www.renata.com

The information and recommendations set forth are made in good faith and believed to be accurate as of the date of preparation. RENATA S.A. makes no warranty, expressed or implied, with
respect to this information and disclaims all liabilities from reliance on it.

Article Safety Data Sheet - Lithium Batteries Version: 09-02 /

Page 5 of 10

(Specimen see Annex II), Overpacks are allowed as per Part 1 of Packing Instruction 968, and must
be labelled with handling label (Specimen see Annex II)

(f) All personnel at Renata AG preparing and offering Lithium Batteries received adequate instructions

As used above and elsewhere in these Regulations, "lithium content" means the mass of lithium in the anode of a
lithium metal or lithium alloy cell, except in the case of a lithium-ion cell the "equivalent lithium content" in grams is
calculated to be 0.3 times the rated capacity in ampere-hours.

RENATA's lithium cells and batteries do meet the above mentioned provisions.
They can be described as "Partly Regulated" in the transport documents.

XIV.II Provisions for shipments by air into, out of, or within the U.S. (pursuant to 49 CFR)

In addition to the provisions mentioned under XIV.I for shipments into, out of, or within the US the following provisions
of the 49 CFR apply:

Pursuant to Special Provision A 100 of the 49 CFR primary (non-rechargeable) lithium cells and batteries are
forbidden for transport on passenger carrying aircraft. To avoid these cells and batteries being loaded on board of
passenger carrying aircrafts, packages must be marked pursuant to § 173.185 (b)(5) (Specimen see Annex III),
even if the packaging are shipped via highway, rail or vessel. RENATA's primary lithium cells and batteries do meet
the provisions of § 173.185 (b).

GENERAL HANDLING INSTRUCTIONS

Battery cartons should be handled with care. Rough handling may result in batteries being short circuited or
damaged. This may cause leakage, explosion, or fire. (Refer also to Section VII) (Specimen see Annex V)

Section XV - Regulatory Information

The batteries are in accordance with the directive 2006/66/EC

Section XVI - Other Information

RENATA’s lithium batteries are registered by UNDERWRITERS LABORATORIES INC., NORTHBROOK, IL, U.S.A.,
under file number MH14002.

Further information is given in RENATA Designer’s Guide.

For lithium cells and batteries in general, Safety Standard IEC 60086-4 applies, which also contains detailed
recommendations for manufacturers of equipment and users.

For further information on RENATA’s lithium cells and batteries visit our web site: www.renata.com.

Renata SA Tel. [phone] [e-mail]
CH-4452 Itingen/Switzerland Fax. [phone] www.renata.com

The information and recommendations set forth are made in good faith and believed to be accurate as of the date of preparation. RENATA S.A. makes no warranty, expressed or implied, with
respect to this information and disclaims all liabilities from reliance on it.

Article Safety Data Sheet - Lithium Batteries Version: 09-02 /

Page 6 of 10

ANNEX I

APPROXIMATE WEIGHT CONTENT OF LITHIUM IN RENATA LITHIUM BATTERIES

Model no. % Lithium Max Weight of battery (in g) Qty Li (Max in mg)

CR1025 1.5 % 0.60 8.8
CR1216 1.1 % 0.70 7.5
CR1220 1.4 % 0.80 11.0
CR1225 1.7 % 0.90 15.0
CR1616 1.3 % 1.10 14.5
CR1620 1.8 % 1.20 21.2
CR1632 2.1 % 1.80 37.5
CR2016 1.4 % 1.70 23.5
CR2016 MFR 1.5 % 1.70 25.5
CR2016 alterna 1.1 % 1.80 19.8
CR2025 2.1 % 2.30 48.0
CR2025 MFR 2.0 % 2.50 50.0
CR2025 alterna 2.0 % 2.50 50.0
CR2032 2.4 % 2.80 67.0
CR2032 MFR 2.0 % 2.80 56.0
CR2032 alterna
CR2045 2.2 % 3.70 83.0
CR2045HT 1.9 % 4.10 79.0
CR2320 1.6 % 2.70 43.0
CR2325 1.8 % 3.00 55.0
CR2430 2.0 % 4.10 80.0
CR2450HT 2.0 % 6.70 136.0
CR2450N 2.7 % 5.90 160.0
CR2477N 3.3 % 8.30 270.0

2.0 % 3.00 60.0

Renata SA Tel. [phone] [e-mail]
CH-4452 Itingen/Switzerland Fax. [phone] www.renata.com

The information and recommendations set forth are made in good faith and believed to be accurate as of the date of preparation. RENATA S.A. makes no warranty, expressed or implied, with
respect to this information and disclaims all liabilities from reliance on it.

Article Safety Data Sheet - Lithium Batteries Version: 09-02 /

Page 7 of 10

ANNEX II

Renata SA Tel. [phone] [e-mail]
CH-4452 Itingen/Switzerland Fax. [phone] www.renata.com

The information and recommendations set forth are made in good faith and believed to be accurate as of the date of preparation. RENATA S.A. makes no warranty, expressed or implied, with
respect to this information and disclaims all liabilities from reliance on it.

Article Safety Data Sheet - Lithium Batteries Version: 09-02 /

Page 8 of 10

ANNEX III

This label is required for shipments containing one or more cells/batteries into, out of, or within the U.S. via highway, rail, vessel or cargo-only
aircraft. The label must be in contrasting colour and the letters must be 6 mm (0.25 in) in height for packages weighting not more than 30 kg.

ANNEX IV

Regulatory References: SP 188 UN Model Regulations, 188 ADR/RID, 310 IMDG Code, ICAO/IATA Packing

Instruction 968 Part 1 (Lithium Metal Batteries) and ICAO/IATA Packing Instruction 965 Part 1 (Lithium Ion

Batteries)

SHIPPER'S CERTIFICATION for Lithium Metal Batteries and Lithium Ion Batteries

Hereby we declare that the cells and batteries contained in this shipment qualify in accordance with above provisions

for transportation "partly regulated"

DÉCLARATION DE L'EXPÉDITEUR pour piles au Lithium Metal et Lithium Ion

Par la présente, nous certifions que les piles contenues dans cet envoi sont conformes aux conditions de transport

exigées pour la mention"partiellement réglementés"

ERKLÄRUNG DES VERSENDERS für Lithium Metall Batterien und Lithium Ionen Batterien

Wir bestätigen hiermit, dass die Batterien und Zellen in dieser Sendung entsprechend oben genannten

Bestimmungen als "teilweise eingeschränkt" transportiert werden können

For emergency information call RENATA SA at [phone]

referring to the below Packing List No

This certification is on every packing list for shipments containing Lithium Metal and Lithium Ion
Batteries.

Renata SA Tel. [phone] [e-mail]
CH-4452 Itingen/Switzerland Fax. [phone] www.renata.com

The information and recommendations set forth are made in good faith and believed to be accurate as of the date of preparation. RENATA S.A. makes no warranty, expressed or implied, with
respect to this information and disclaims all liabilities from reliance on it.

Article Safety Data Sheet - Lithium Batteries Version: 09-02 /

Page 9 of 10

ANNEX V

CAUTION

The packages in this consignment consist of

Lithium Metal Batteries

Shipment must be handled with care

Flammable if damaged

If the package is damaged it must be

quarantined, inspected and repacked

For further information contact:

Phone: [phone]

(24 hrs / 7 days per week)

Renata SA Tel. [phone] [e-mail]
CH-4452 Itingen/Switzerland Fax. [phone] www.renata.com

The information and recommendations set forth are made in good faith and believed to be accurate as of the date of preparation. RENATA S.A. makes no warranty, expressed or implied, with
respect to this information and disclaims all liabilities from reliance on it.

Article Safety Data Sheet - Lithium Batteries Version: 09-02 /

Page 10 of 10