Owner’s Manual
Read and understand this entire manual before riding!
For assistance contact Razor®. DO NOT RETURN TO STORE.
NOTE: Manual illustrations are for demonstration purposes only.
Illustrations may not reflect exact appearance of actual product.
Specifications subject to change without notice.
Item Number:
Black 20036090
Silver 20036011
Version_1_01_10
DLX 20036099
CONTENTS
Safety Warnings ............................................................ 1
Before You Begin ........................................................... 2
Set-Up and Usage ....................................................... 3-4
SAFETY WARNINGS
AN IMPORTANT MESSAGE TO PARENTS: This manual contains
many warnings and cautions concerning the consequences of failing to
maintain, inspect or properly use your PowerWing™. Because any incident
can result in serious injury or even death, we do not repeat the warning of
potential serious injury or death each time such a possibility is mentioned.
GENERAL WARNING: Riding the PowerWing™ can be a hazardous
activity. Certain conditions may cause the equipment to fail without fault of
the manufacturer. Like other wheeled products, the PowerWing™ can and is
intended to move, and it is therefore possible to lose control, fall off and/or
get into dangerous situations that no amount of care, instruction or expertise
can eliminate. If such things occur, your child can be seriously injured or die,
even when using safety equipment and other precautions. USE COMMON
SENSE.
APPROPRIATE RIDER USE AND PARENTAL SUPERVISION
Direct adult supervision is required at all times. This manual contains
important safety information. It is your responsibility to review this
information and make sure that all children obey all warnings, cautions,
instructions and safety topics and assure that young riders are able to
safely use this product. Razor® recommends that you periodically review
and reinforce the information in this manual with young riders, and that you
inspect and maintain your children’s product to insure their safety.
The recommended rider age of 5 years and older for PowerWing™ is only an
estimate, and can be affected by the rider’s size, weight or ability. Any child
unable to fit comfortably on the PowerWing™ should not attempt to ride it.
A parent’s decision to allow his or her child to ride this product should be
based on the child’s maturity, skill and ability to follow rules.
PowerWing™ Parts ....................................................... 5
Warranty ........................................................................ 6
ACCEPTABLE RIDING PRACTICES AND CONDITIONS
Direct parental supervision is required. The PowerWing™ is meant to be
used only in controlled environments free of potential traffic hazards and
not on public streets. Do not allow your child to ride the PowerWing™ in
any areas where vehicle traffic is present. Child must maintain a hold on the
handlebars at all times. Never allow more than one child at a time to ride
the PowerWing™. Never use near steps, sloped driveways, hills, roadways,
alleys or swimming pool areas. Keep fingers and other body parts away from
the product when folding or unfolding. Adults must not allow children to
assist in folding or unfolding the PowerWing™.
Do not ride the PowerWing™ in wet weather. The PowerWing™ is intended
for use on solid, flat, clean and dry surfaces such as pavement or level ground
without loose debris such as rocks or gravel. Wet, slick or uneven and rough
surfaces may impair traction and contribute to possible accidents. Do not ride
the PowerWing™ in mud, ice, puddles or water. Avoid excessive speeds that
can be associated with downhill rides. Never risk damaging surfaces such as
carpet or flooring by use of a PowerWing™ indoors. Do not ride at night or
when visibility is impaired.
PROPER RIDING ATTIRE
Always ensure child is wearing proper protective equipment such as an
approved safety helmet. A helmet may be legally required by local law
or regulation in your area. A child should always wear shoes, never ride
barefooted or in sandals, and keep shoelaces tied and out of the way of
the wheels.
FAILURE TO USE COMMON SENSE AND HEED THE ABOVE WARNINGS
INCREASES RISK OF SERIOUS INJURY. USE WITH APPROPRIATE CAUTION
AND SERIOUS ATTENTION TO SAFE OPERATION.
Do not exceed 143 LBS (65 kilograms) on the PowerWing™ and 180 pounds
(81 kilograms) on the PowerWing™ DLX.
Rider weight does not necessarily mean a child’s size is appropriate to fit or
maintain control of the PowerWing™.
Refer to the section on safety for additional warnings.
WARNING: ALWAYS INSPECT POWERWING™ PRIOR TO RIDING.
Properly inspecting and maintaining your scooter can reduce the risk of injury.
Always inspect your PowerWing™ before riding and regularly maintain it.
WARNING: CHECK LOCAL LAWS REGARDING POWERWING™ USE.
Check local laws and regulations to see where and how you may use your
Razor PowerWing™ legally. In many states and local areas PowerWing™
riders are required BY LAW to wear a helmet. Check local laws and
regulations regarding laws governing helmet use and PowerWing™ operation
in your area.
1
BEFORE YOU BEGIN
Remove contents from box and check parts against part diagram below. Remove the foam separators that protect the
components from damage during shipping. Inspect the contents of the box for scratches in the paint, dents or kinked
cables that may have occurred during shipping. Because the PowerWing™ is partially assembled and packed at the
factory, there should not be any problems, even if the box has a few scars or dents.
q Estimated Assembly and Set-Up Time
Allow up to 15–20 minutes for assembly.
Brake
Handlebar assembly
WARNING: DO
NOT USE NON-RAZOR
PRODUCTS WITH YOUR
POWERWING™.
The PowerWing™ has been
built to certain Razor® design
specifications. The original
equipment supplied at the time of
sale was selected on the basis of
its compatibility with the frame,
fork and all other parts. Certain
aftermarket products may or may
not be compatible.
Folding Mechanism
Hex socket bolt
Front Wheel
q Required Tools
Tools needed to assemble are included.
Right foot platform
Coupling bolt
Frame
Left foot platform
Rear caster
Rear Wheel
(2) 5mm hexagonal key
wrenches
(included)
Need Help? Visit our web site for replacement parts and product support at www.razor.com or call
toll-free at 866-467-2967 Monday - Friday 8:00 AM - 5:00 PM Pacific Time.
2
SET-UP AND USAGE
q Attaching the Foot Platforms
Remove black plastic protector
1
at the end of the frame. Using two
5mm hexagonal wrenches, remove
the two hexagonal bolts and the
two coupling bolts from the frame.
4a If necessary, use a mallet /
hammer to tap the two coupling
bolts until they are all the way
through the platforms.
2 Remove black plastic protector
at the end of the platform. Position
the right and left foot platforms up
to the frame and align holes.
4b The platforms should now be
snug against the frame.
3 Insert the two coupling bolts
and two hexagonal bolts. Starting
underneath with the bolt on the
back. Turn product over and insert
the next set of bolts. Tighten with
two 5mm hexagonal wrenches.
3
SET-UP AND USAGE
q Attaching the Handlebars
1 Remove the plastic protector
covering the wedge and loosen the
black folding knob and swing to
the 6 o’clock position to unfold the
handlebar stem.
2 Insert the handlebar stem into
the front fork. You may have to
loosen the wedge to allow it to
slip into the front fork.
3 Slide the handlebar stem
down into the front fork until
it fits snuggly into the lock
nut on the headset.
WARNING: Failure
to properly tighten the wedge
may allow the handlebars to
dislodge while riding and may
cause you to lose control and
fall. When correctly tightened,
the handlebars will not rotate
out of alignment with the
front wheel under normal
circumstances.
WARNING: Keep your
fingers clear of the pivoting
mechanism when folding or
unfolding the PowerWing™, and
make sure others are standing
clear.
Note: The cable and wire
assembly from the handlebar
must not wrap around the
steering tube or handlebar as
shown in step 3. Sharp bends or
twisting of the brake cable can
cause the brake to malfunction.
4 Using a 5mm hexagonal key
wrench to tighten the stem
bolt. The stem bolt is properly
tightened when the handlebars cannot be twisted out of
alignment with the front wheel.
Make sure the handelbars are in
line with the front wheel before
tighten stem bolt all the way.
q Adjusting the Brake
1 To adjust the brake cable
wire, thread the brake lever
adjuster in or out 1/4 to 1/2 turn
until the desired cable tension is
attained.
5 Bring the handlebar stem
back to the upright position.
2 Squeeze the hand lever to
test the brake to make sure it
is working properly. The front
fender should clamp down and
rub against the front wheel. If
brake is not working properly,
proceed to the next step.
6 Swing the black folding knob
to the 12 o’clock position and
tighten by hand until handlebars
are secure.
3 If the brake is too tight or too
loose, use a 8mm open wrench
and a 3mm allen wrench to make
adjustments as needed.
Need Help? Visit our web site for replacement parts and product support at www.razor.com or call
toll-free at 866-467-2967 Monday - Friday 8:00 AM - 5:00 PM Pacific Time.
4
POWERWING PARTS
Keep your PowerWing™ running for years with genuine Razor parts. Visit our web site www.razor.com to purchase replacement parts.
(Specifications subject to change without notice.)
1 Handlebar Stem
2 Handlebar Grip (2)
3 Brake Lever Assembly
4 Brake Cable Guide
5 Folding Knob
6 Wedge
7 Headseat w/Bearing
(Upper/Lower)
8 120mm Front Wheel
8 - 1 Washer (Front Wheel)
8 - 2 608zz Bearing (Front
Wheel)
8 - 3 Front Wheel Spacer
9 Front Axle Bolt
10 Front Fork with Fender
10 - 1 Brake Cable Adjust Screw
10 - 2 Brake Spring
10 - 3 Brake Mounting Coupling
Bolt
10 - 4 Pivoting Mechanism
11 Coupling Bolt (Footstepper)
12 Coupling Bolt
13 Foot Platform (Right/Left)
14 Platform Cover (Right/Left)
15 Stability Bar (Right/Left)
15 - 1 5mm Hexagonal Bolt
16 Caster
17 64mm Rear Wheel
5
SAFETY REMINDERS
PRE-RIDE CHECKLIST
q
q
Loose Parts
Check and secure all fasteners before every ride. Make sure the
steering bolts and foot steppers are tight. There should not be any
unusual rattles or sounds from loose parts or broken components.
If you are not sure, ask an experienced mechanic to check.
Brake
Check the brake for proper function. When you squeeze the lever,
the brake should provide positive braking action.
DO NOT RETURN TO STORE
q
q
Frame, Fork and Handlebars
Check for cracks or broken connections. Although broken frames
are rare, it is possible for an aggressive rider to run into a curb
or wall and wreck and bend or break a frame. Get in the habit of
inspecting yours regularly.
Safety Gear
Always wear proper protective equipment such as an approved
safety helmet, elbow pads and kneepads. Always wear shoes
(lace-up shoes with rubber soles), never ride barefooted or in
sandals, and keep shoelaces tied and out of the way of the
wheels.
Failure to follow these instructions may damage
your product and void your warranty.
WARRANTY
Razor Limited Warranty
The manufacturer warranties this product to be free of manufacturing defects
for a period of 6 months from date of purchase. This Limited Warranty does
not cover normal wear and tear, wheels, or any damage, failure or loss
caused by improper assembly, maintenance, or storage or use of the Razor®
PowerWing™.
This Limited Warranty will be void if the product is ever
• used in a manner other than for recreation;
• modied in any way;
• rented.
The manufacturer is not liable for incidental or consequential loss or damage
due directly or indirectly to the use of this product.
Razor® does not offer an extended warranty. If you have purchased
an extended warranty, it must be honored by the store at which it was
purchased.
For your records, save your original sales receipt with this manual.
__________________________________________
Item Number:
Black 20036090
Silver 20036011
Need Help? Visit our web site for replacement parts and product support at www.razor.com or call
toll-free at 866-467-2967 Monday - Friday 8:00 AM - 5:00 PM Pacific Time.
U.S. Patent 7,597,334 B2
Printed in China for:
Razor USA LLC
PO Box 3610
Cerritos, CA 90703
Copyright © 2003-2010 Razor USA, LLC. All rights reserved. RAZOR® and the Razor Logo
Design are among the registered trademarks of Razor USA LLC in the United States and/or
select foreign countries. PowerWing™ is a trademark of Razor USA LLC.
6
01/2010
Loading...