RAVE Sports O-Zone Plus Water Bouncer with Slide User Manual [en, es, fr]

O-Zone™ Plus Series

(O-Zone with Slide, O-Zone XL with Slide)

Owner’s Manual

www.ravesports.com

Copyright ©

All rights reserved. No part of this publication may be reproduced or transmitted in any form or by any means,
electronic or mechanical, including photocopy, recording, or any information storage and retrieval system, without
permission in writing from the publisher. Requests should be mailed to RAVE Sports, 3325 Labore Road, Saint
Paul, MN 55110.

Thank you for purchasing the O-Zone Plus. Your new play platform

!!

has been designed and constructed to provide you, your family and
friends lasting memories and hours of exciting fun on the water.

We at RAVE Sports want your experience with the O-Zone Plus to be
the best it can be. Therefore, please take a few minutes to read the
information contained in this manual before inflating and using your
new O-Zone Plus. Although the product is simple to use, this manual
contains important safety information that you and others must
understand to safely enjoy the O-Zone Plus.

W A R N I N G

Using the O-Zone Plus – like any action sports or recreational
activity involving motion – involves a risk of injury. Improper
use of the O-Zone Plus, including reckless or careless
behavior, neglect or misuse of the equipment, or inadequate
supervision of children and others using the O-Zone Plus, can
result in serious personal injury or death.

Read all instructions and warnings provided to you in this
owner’s manual and print ed on the O-Zone Plus. Always act
responsibly, provide proper supervision for children and
others, and make sure that you and all other persons using
the O-Zone Plus are in good physical condition.

It is the owner’s responsibility to inform all users of the
product safety rules and warnings contained herein.
Do not use the O-Zone Plus unless you are fully aware of and
willing to accept these risks and responsibilities.

1

C A U T I O N

!

!

• This product is designed for use in open areas. Be sure

there is adequate clearance from hard surfaces or
obstructions above, below and around the product.

• Do not exceed 1 PSI if filling with compressed air.

Excessive pressure can cause the tube to rupture, with
potentially damaging force to eyes, ears, skin and limbs.

• Do not exceed the recommended weight capacity for your

particular product: O-Zone Plus: 240 lbs.

O-Zone XL Plus: 350 lbs.

Contents in this package

1. Bounce platform

2. Slide with attac hment ropes

3. Boarding platform with attachment rope

4. Anchor bag

5. Owner’s manual

6. Repair patch

(109 Kg)

(159 Kg)

Please make sure you have received the c ontents listed t hen
record the followi ng information for future reference.

Date Purchased: _________________________________
Purchased from: _____________________________ ____

2

Set Up

1. Locate a clean, flat area of approximately 15 ft. in diameter that is
free of hard obstructions, abrasive materials, and sharp objects.
Carefully spread out the tube so the graphics and mesh surface
are facing up.

2. For quick inflation, unscrew the valve body from the base.

3. Using an 110V inflator/deflator or large volume
hand pump, inflate until yellow indicator is
between the A and B marks on the inflation
gauge. Quickly screw in valve body. To top off,
unscrew top valve cap only and add air. To
reduce the amount of air in the tube, turn the
lower main valve body approximately 1 full turn
counter clockwise or until you hear air escaping.
Note: refer to step 4 if the tube feels too soft or
you are unsure whether the gauge is working properly.

4. DO NOT OVERINFLATE! Inflate only until the jump surface is
taut and the bouncer tube reaches a vertical height of
approximately 28” high for the O-Zone Plus and 36” high for the
O-Zone XL Plus.

5. Inflate boarding platform until it becomes firm. Do not over inflate
by continuing to inflate beyond this point. Note: a firm platform
will be easier to board than a soft one.

Note: Some wrinkles may remain in the tube at this proper
pressure and will lessen over time. It is normal for the air
pressure within the tube to fluctuate depending on air and water
temperatures. It may be necessary to check and release some air
pressure from your product throughout the day.

6. Although the O-Zone Plus is not intended to be anchored
continuously for any length of time, a day-use anchor bag is
included. Simply fill the anchor bag with sand from the lake shore
or lake bottom. This will create a 40-lb. anchor that can be
emptied and rinsed after each use.

3

7. Carry (DO NOT DRAG) your O-Zone product to the water. Flip
bouncer upside down in shallow water. Tie a knot in one end of
lacing rope. Align large grommet holes
of apron over the three rope holders on
the underside of the boarding platform.
Starting at the outermost rope holder on
the bottom of the bouncer, lace
alternately between bouncer and
boarding platform. Loosely tie other end
of rope.

Flip entire unit face up in the water. Pull
rope until the platform is snug against
side of bouncer and there is no gap.

Check to make sure rope is spread
evenly between rope holders. Tie off
rope to keep the boarding platform snug
to the bouncer.

Periodically check to ensure the
protective apron is laying flat over the ropes and the ropes are
not exposed between the boarding platform and the bouncer.

Inflating and connecting the slide

1. Inflate the main body chamber of the slide. DO NOT OVER
INFLATE. Inflate until firm and the slide stands upright.

2. Inflate both side rails on top of slide until firm. DO NOT OVER
INFLATE as the heat of the sun will cause the air to expand.
Release air throughout day if necessary.

Note: Moisten the plug of the clear stem valve prior to inserting it
into the valve and push plug into the valve body fully.

4

3. Carry slide to the water and position

E

next to the O-Zone directly opposite
from the boarding platform.

4. Tie a knot at one end of each slide
attachment rope.

5. Working from the top down, feed the
rope through mounts A through F as
shown. Loop twice through point E and

6. Lace other side of slide in the same
fashion.

7. Adjust connection lacing, if necessary,
to provide equal tension on both sides
and to ensure the slide is squarely and
securely fastened to the O-Zone.

8. Move to proper water depth and attach anchor
bag rope to the single rope holder located low
on the outside of the tube, opposite the
boarding platform. Adjust anchor line to a length
slightly greater than the water depth and tie off rope. Leave a little
slack in the anchor line to accommodate the vertical motion of the
O-Zone when in use.

finish by tying at point F.

Before using your O-Zone, please read and follow all warnings and
safety instructions.

5

W A R N I N G

!

!

• This product is intended for use on large bodies of water

only.

• Anchor in at least 8 feet of water and in an area that is

most protected from wind. Do not use in swimming pools
or within 15 feet of boats, docks or other hard
obstructions.

• Not recommended for children under six years of age.

Use only with mature, knowledgeable supervision.

• Do not attempt or allow somersaults or other acrobatic

maneuvers. Improper landing during these maneuvers
can produce serious risk of broken bones, cuts, nerve
damage, spinal cord or brain injury, or death.

• Do not dive off or swim under this product. If you choose

to jump off the product, alw a ys enter the water feet first.

• This is not a personal flotation device. Always wear a

U.S. Coast Guard approved Type III PFD vest.

• Never tow this product behind a boat or other watercraft.

• Inspect the area beneath and around the product before

each use to ensure adequate clearance from
obstructions. Ask about local water conditions before
using the O-Zone Plus in unfamiliar water.

• Secure access. Deflate and store when not in use.

• Never use the product under the influence of alcohol or

drugs.

• Do not attempt to climb on board or stand on the grab

lines around the perimeter of the tube.

• Never use the product after sunset, before dawn, or any

other time when lighting co nditi ons are poor .

6

W A R N I N G

!

!

• Never use the product in rough surface water conditions,

during storms, or when there is lightning. If an
unexpected storm arises while using the O-Zone Plus,
seek shelter on shore. Do not st a y on the produ ct.

• Always stay under control while using the product.

• Inspect the O-Zone Plus before each use for worn or

damaged parts.

• Never use product while tired or fatigued. Use extreme

caution while swimming between the shore and the O­Zone Plus. Do not attempt to swim this distance if you
are tired or fatigued.

Troubleshooting

Won’t hold air:

• Check main valve to insure plastic ring is not caught under the
seal or cap.

• Be sure the valve and cap are screwed in straight and tight. A
cross threaded valve can cause leakage.

• Check stem valves to insure plugs are fully seated down into
valve body.

• Check for holes in product following the procedures in the
“Repairs” section.

Repairs

• Inflate the tube firmly and locate the leak by spraying the tube
with soapy water. Bubbles will appear where there is a leak.

• Determine the hole size and cut a circular patch ½ - 1 inch wider
than the hole.

• Remove air from the tube and dry tube completely where the
patch is to be applied.

7

• Peel off paper back from patch, apply repair patch to area and
work out any air bubbles from beneath the patch.

• Apply weight to the patched area for one hour before re-inflating.

Storage

• Clean the tube and surface with mild soap and water and allow to
dry completely before folding and storing.

• Deflate bouncer, slide, and boarding platform completely by
removing main valve bodies from the valves bases and opening
the plugs.

• Consider packing mothballs for maximum protection from mice
and insects.

• Do not store directly on concrete.

Complement it with Oasis Lounge (Item # 02420, sold separately) so
that parents can have a comfortable place to relax and watch the little
ones!

8

RAVE Sports® Limited One Year Warranty

The Limited One Year Warranty set forth below is provided by RAVE Sports®, A Revel Match, LLC company with
respect to prodcut(s) purchased and used in the United States and Canada.
RAVE Sports’® product(s), when delivered to you in a new condition in original container, are warranted against
defects in material or workmanship for a period of one (1) year from the date of original purchase when used in
a non-commercial application. Product(s) used in a commercial application are warranted against defects or
workmanship for a period of six (6) months from the date of original purchase. Defective product(s) returned to
RAVE Sports® or an authorized service location and are proven to be defective upon inspection, will be repaired
or exchanged for a new product(s) or part(s) at a prorated value where applicable. The warranty period for any
replacement produt shall begin upon shipment of the same, but shall in no event exceed the warranty period of
the defective product.
When returning any product under this Limted One Year Warranty, you must first contact RAVE Sports® to
obtain a return authorization number. The product must be packaged in its original carton or comparable
packaging with a copy of the bill of sale (or invoice of purchase), together with a complete explanation of the
problem. Shipping charges, if any, must be prepaid. Products covered by this Limited One Year Warranty will be
returned to you without charge by RAVE Sports®.
This Limted One Year Warranty covers all defects encountered in normal use of the product and does NOT
apply in the following cases:

a) Loss or damage due to abuse, mishandling, alteration, accident
b) Failure to follow operating, maintenance, or storage instructions
c) Service by a party other than RAVE Sports’® authorized service personnel
d) Any acts of God including storm and animal damage
e) The product has had its serial number(s) or dating altered or removed
f) Normal wear and tear which includes sun damage and other normal weathering of the product

No implied warranty (or condition), including any implied warranty (or condition) of merchantability or fitness
for a particular purpose, applies to the product after the applicable period of express warranty stated above,
and no other express warranty or guaranty, except as mentioned above, given by any person, firm, or
corporation with respect to the product shall bind RAVE Sports®. Some states or provinces do not allow
limitations on how long an implied warranty lasts, so the above limitations may not apply to you.
RAVE SPORTS® SHALL NOT BE LIABLE FOR LOSS OF REVENUE OR PROFIT, FAILURE TO REALIZE SAVINGS OR
OTHER BENEFITS, OR FOR ANY OTHER SPECIAL, INCIDENTAL OR CONSEQUENTIAL DAMAGES CAUSED BY THE
USE, MISUSE OR INABILITY TO USE THE PRODUCT REGARDLESS OF THE LEGAL THEORY ON WHICH THE CLAIM IS
BASED, AND EVEN IF RAVE SPORTS® HAS BEEN ADVISED OF THE POSSIBILITY OF SUCH DAMAGES. NOR SHALL
RECOVER ANY KIND AGAINST RAVE SPORTS® BE GREATER IN AMOUNT THAN THE PURCHASE PRICE OF THE
PRODUCT SOLD BY RAVE SPORTS® AND CAUSING THE ALLEGED DAMAGE.
WITHOUT LIMITING THE FOREGOING, YOU ASSUME ALL RISK AND LIABILITY FOR LOSS, DAMAGE OR INJURY TO
YOU AND YOUR PROPERTY AND TO OTHERS AND THEIR PROPERTY ARISING OUT OF THE USE, MISUSE, OR
INABILITY TO USE ANY PRODUCT SOLD BY RAVE SPORTS® NOT CAUSED DIRECTLY BY THE NEGLIGENCE OF RAVE
SPORTS®. SOME STATES OR PROVINCES DO NOT ALLOW EXCLUSION OR LIMITATION OF INCIDENTAL OR
CONSEQUENTIAL DAMAGES, SO THE ABOVE LIMITATION MAY NOT APPLY TO YOU. THIS LIMITED 1 YEAR
WARRANTY SHALL NOT EXTEND TO ANYONE OTHER THAN THE ORIGINAL PURCHASER OF ANY PRODUCT, OR
THE PERSON FOR WHOM IT WAS PURCHASED AS A GIFT.

This Limited One Year Warranty gives you specific legal rights. To the extent that such rights cannot be
disclaimed under applicable law, this limited warranty does not affect such rights.

9