Q.V.P. NU-Matic 2, NU-Matic 4, NU-Matic 6 User Manual

INSTRUCTIONS FOR THE NU-MAtic

Nu - 2,4, or 6

8/18/06 - Nu-Matic Standard.cdr

Place your VCA6 connector under the bag
wherever it is most convenient for you.

VAKuum Bag

or

Frame Press

T wo very important items to note about the NU-Matic. The air pressure must be kept between 85 and 100
psi. Having the pressure exceed 100 psi could cause damage to some components.

The second item is to provide clean air. If you have filtered air and are using quick disconnects, make sure
that the female connector is clean. Having filtered air will not do you any good if you pick up the female
connector off the floor and it has sawdust and chips in it. These will blow into the components and possibly
cause a problem.

VAKuum Line

Air Regulator

Compressed Air

Toggle Switch

VAKuum Sensor

The NU-Matic has a three position toggle switch in the top center of the box. This allows you to turn the unit
on to run continuously or to be regulated when used with a V AKuum Bag or frame Press.

1. Attach your air line to the right side fitting (1/4 NPT).

2. Attach one end of the vacuum line to the barb on the left side of the unit. Block the other end with your
thumb and flip the toggle switch to V AK Bag. The unit should go up to 25“Hg and shut off.

The black knob on the front center of the box is an air regulator, adjust it when the unit is running. The air
pressure gauge must be between 85 and 100 psi when the unit is running. If not, the unit will not get to
vacuum level and shut off.

The VAKuum sensor is just below the toggle switch. T urning it counter clockwise will cause the unit to shut
off at a lower vacuum level. Do not adjust this unless you want less pressure (weak form) or you do not have
enough air to get to vacuum level.

CALL 1-800-547-5484 TODAY!

Or visit our site at www.qualityvak.com

Quality VAKuum Products, Inc.

74 Apsley St. - Hudson, MA 01749
Tel: [phone] - Fax: [phone]

Conditions of sale
WARRANTIES AND DISCLAIMERS. SELLER MAKES NO WARRANTY, EXPRESSED OR IMPLIED,
CONCERNING THE PRODUCT OR MERCHANTABILITY OR FITNESS THEREOF FOR ANY PURPOSE,
except; (a) that the product shall conform to the description contained herein and to the specifications, if
any, attached hereto; and (b) that the product does not infringe on any valid United States patent. Seller
does not warrant, however, that the use of the product, or articles made therefrom, either alone or in
conjunction with other material, will not infringe any United States Patent.

Liability Limitations. Buyer's exclusive remedy shall be for damages and no claim of any kind, whether as
to product delivery or for non delivery of product, and whether based on contract, breach of warranty,
negligence or otherwise, shall be greater in amount than the purchase price of the quantity of product in
respect of which damages are claimed. In no event shall Seller be liable for incidental or consequential
damages, whether Buyer's claim is based on contract, breach of warranty, negligence or otherwise.
June 26, 2012