Quik N' Crispy DIP-R-SPRAY User Manual

Page 1 of 2

Date Prepared: February 2005

COMPLIES WITH OSHA’S HAZARD COMMUNICATION STANDARD (29CFR1910.1200)

SECTION I – PRODUCT IDENTIFICATION

PRODUCT NAME: DIP-R-SPRAY Chemical Family: Mixture
FORMULA NUMBER: 1007A Emergency Phone: CHEMTEL 1-800-255-3924
Information Phone: M-F, 8-4 1-714-548-6820
SUPPLIER’S NAME: WALJAN PRODUCTS
SUPPLIER’S ADDRESS: 23905 Clinton Keith 114-129 HAZARD RATING INFORMATION
Wildomar, CA 92595 NFPA
Telephone: [phone] Health 2 0 - Minimal
FAX: [phone] Flammability 0 1 - Slight
Reactivity 2 2 - Moderate
D.O.T. HAZARD CLASS: Corrosive Liquid Personal Protection 1 3 - Serious
D.O.T. LABEL: Corrosive 4 - Extreme
D.O.T. SHIPPING NAME: Compound, Liquid, Corrosive
D.O.T. PG: III

CHEMICAL NAME CAS NO. % WT 313/CHEMICAL PEL SKIN TWA/TLV
CARCINOGEN

Potassium Hydroxide 1310-58-3 608 N/E N/E N/E 2 mg/cu.m None
Known

Ingredients not precisely identified are proprietary or non-hazardous. All chemicals appear on the EPA TSCA Inventory.
SECTION III – PHYSICAL DATA SECTION IV – FIRE AND EXPLOSION DATA
BOILING POINT: Approx. 100º C FLASH POINT: No Flash to 94º C

VAPOR PRESSURE: Approx. 18 mm Hg @ 20º C EXPLOSIVE HAZARD: N/A
SOLUBILITY IN WATER: Complete EXTINGUISHING MEDIA:
PH: 14 Foam, Carbon Dioxide, Dry Chemical, Water Spray, Water
SPECIFIC GRAVITY: 1.03 @ 20º c SPECIAL FIRE FIGHTING PR OCEDURES: None
EVAPORATION RATE: Approx. 0.4 UNUSUAL FIRE AND EXPLOSION HAZARDS: Contact with amphoteric
APPEARANCE/ODOR; Clear Yellow Liquid; Mild Fragrance metals will result in generation of flammable hydrogen gas
VOC CONTENT: 0

SECTION V – REACTIVITY DATA SECTION VI – STORAGE AND HANDLING

STABILITY: Stable
HAZARDOUS POLYMERIZATION: Will not occur

INCOMPATIBILITY: Acid materials; Amphoteric metals (i.e. aluminum, galvaniz ing) KEEP OUT OF THE REACH OF CHILDREN:
HAZARDOUS DECOMPOSITION PRODUCTS: None FOR INDUSTRIAL AND INSTITUTIONAL USE ONLY: Yes

DO NOT STORE AT TEMPERATURES ABOVE: N/A

PRIMARY ROUTES OF ENTRY AND EFFECTS OF OVEREXPOSURE FIRST AID PROCEDURES
EYES: Product is destructive to eye tissue EYES: Flush immediately with water for 15 minutes. Get medical attention
SKIN: Prolonged contact may cause corrosion of tissue SKIN: Wash with soap and water. Remove contaminated clothing and
footwear

INHALATION: May cause irritation of respiratory tract INHALATION: Remove victim to fresh air. Get medical attention.
INGESTION: Severe burns and possible tissue perforation of mucous membranes INGESTION: Do not induce vomiting. Give large quantities of water.
LONG TERM EFFECTS: None Known Consult a physician

SECTION VIII – SPECIAL PROTECTION DATA SECTION IX – SPILL OR LEAK PRECAUTIONS
RESPIRATORY PROTECTION: Not normally needed STEPS TO BE TAKEN IN CASE OF SPILL OR LEAK:

SMALL SPILL: Wipe up
VENTILATION: General LARGE SPILL: Dike area. Pump into suitable tank for rework or disposal

WASTE DISPOSAL METHOD: Dilute with water. Neutralize pH to about 7
with
EYE PROTECTION: Safety glasses or face shield vinegar or phosphoric acid. Pump neutralized material down
drain in

accordance with applicable regulations.
WASTE DISPOSAL CAUTION: Store in cool place. Wash hands after using
product. Keep containers closed when not in use. Flush all containers
with water before discarding.

N/A = NOT APPLICABLE N/E = NOT ESTABLISHED N/D = NOT DETERMINED < = LESS THAN > = MORE THAN

NOTICE: The information contained on this Material Safety Data Sheet is considered accurate as of date of publication. It is not necessarily
all inclusive
nor fully accurate in every circumstance. The suggestions should not be confused with nor followed in violation of applicable laws,

Yes

STORE IN A COOL, DRY AREA AWAY FROM HEAT AND FLAMES:

Prepared By: Dr. D.C. Atkins & Son

MATERIAL SAFETY DATA SHEET

SECTION II – INGREDIENTS

SECTION VII – HEALTH AND FIRST AID

g

Page 2 of 2

re

ulations,

rules or insurance requirements. No warranty, expressed or implied, of merchantability, fitness, accuracy of data, or the results to be
obtained
from the use thereof is made. The vendor assumes no responsibility for in jury or damages resulting from the inappropriate use of this
product.

2/2005