Pro-Link YA005 User Manual

Page 1

M A T E R I A L S A F E T Y D A T A S H E E T MSDS 031

ITEM NUMBER: YA005
VERSION 3 EFFECTIVE DATE: 10/26/04 SUPERCEDES: 04/04/03 PREPARED BY: Ron Cepa
Section(s) Revised: HMIS, II, III, VI, IX
IDENTITY (As Used On Label and List): All Purpose Cleaner

Emergency Medical Telephone Number 1-866-836-8855 (24 HRS) Outside the U.S.A. Call 952-852-4646
PRODUCT HAZARD RATINGS (NFPA): Health = *2, Fire = 2, Reactivity = 0 , Protective Equipment = B
(Rating Legend: 4 = Extreme, 3 = Serious, 2 = Moderate, 1 = Slight, 0 = Minimal)

SECTION I

PRO-LINK TELEPHONE NUMBER FOR INFORMATION: 1-800-74LINKS

DATE PRINTED: 3/1/05

Canton, MA 02021 NAME OF PREPARER: Regulatory Compliance

SECTION II - HAZARDOUS INGREDIENTS / IDENTITY INFORMATION

Chemical Names CAS # SARA Title III ACGIH OSHA % By Wt.
SEC 313 TLV/TWA PEL
2 Butoxyethanol 111-76-2 Yes 25 ppm/ne 25ppm/ne 1-10
Tetrasodium salt of
Ethylenediaminetetraacetic Acid
Liquified Petroleum Gas Mixture 68476-86-8 No See below

Propane 74-98-69 No 1000 ppm/ NE 1000 ppm/NE (48-55)
n-Butane 106-97-8 No 1000 ppm/ NE NE / NE (45-49)
Balance of ingredients are non-hazardous or below reportable levels.

Boiling Point: NA Vapor Pressure (psig): 125 @ 130F / 44 @ 70F
Specific Gravity, calculated (H20=1): 0.9785 ± 0.005 pH: 12.33 Solubility/Water: Moderate
Vapor Density (AIR=1): ND Evaporation Rate (Ether=1): ND

Appearance and Odor: Hazy, yellowish aerosol spray with floral odor.

SECTION IV - FIRE AND EXPLOSION HAZARD DATA

Aerosol Flammability: This product is considered to be non flammable as described in 16CFR 1500.45.
Flammable Limits - % Volume In Air (Propellant): LEL: 1.8 UEL: 9.2
Extinguishing Media: Carbon dioxide, foam and/or dry chemical may be used.
Special Fire Fighting Procedures: Containers should be cooled with water to prevent vapor pressure build
up. Use equipment or shielding, as required, to protect personnel from bursting, rupturing or venting containers.
Unusual Fire and Explosion Hazards: At elevated temperatures (over 54C-130F) containers exposed to direct
flame or heat contact should be cooled with water to prevent weakening of container structure.

Stability: Stable Hazardous Polymerization: NA
Incompatibility (Materials to Avoid): Strong oxidizers, heat and open flame.
Hazardous Decomposition Products: Carbon monoxide, carbon dioxide and additional toxic chemicals may be
formed in small amounts.
Conditions to Avoid: Do not store above 54C-130F. Keep away from heat, direct sunlight, open flames or
sparks. Dropping of containers may cause bursting.

Route(s) of Entry - Inhalation: Y Eyes: Y Skin: Y Ingestion: N
HAZARDS IDENTIFICATION: EYES: May cause moderate irritation. SKIN: Prolonged or repeated contact may
cause irritation. INHALATION: Can cause dizziness, headaches, shortness of breath and incoordination. Nausea,
vomiting and stomach upset can occur. INGESTION: Exposure by ingestion is unlikely since an aerosol, but if occurs:
Can cause dizziness, faintness, headaches, and incoordination.
AGGRAVATED MEDICAL CONDITIONS: May aggravate pre-existing skin, nervous system, kidney conditions.
CHRONIC EFFECTS/TARGET ORGANS: Liver. Kidneys. Nervous system. Lungs and/or respiratory system. Eyes.
Skin. Heart
and/or circulatory system. Blood and/or blood-forming organs. Mucous membranes.
EMERGENCY AND FIRST AID PROCEDURES: EYES: Immediately flush with plenty of water for at least 15
minutes. Get
prompt medical attention. SKIN: Wash with soap and plenty of water. INHALATION: Remove to fresh air. If symptoms
develop, seek immediate medical attention. INGESTION: Get immediate medical attention. Do NOT induce vomiting
unless
directed by medical personnel. Never give anything by mouth to an unconscious person.
CARCINOGENICITY:

64-02-8 No NA / NA NA / NA 1-10

1-10

ingredient data

SECTION III - PHYSICAL CHARACTERISTICS

SECTION V - REACTIVITY DATA

SECTION VI - HEALTH HAZARD DATA

Page 2

M A T E R I A L S A F E T Y D A T A S H E E T MSDS 031

ACGIH IARC NTP OSHA
2-Butoxyethanol A3 No No No
TOXICITY INFORMATION:
Product:
This product was tested for Acute Oral Toxicity, Acute Dermal Toxicity, Acute Inhalation Toxicity, Primary Eye
Irritation, Primary Skin Irritation, and Skin Sensitization with the results listed below. A single oral
administration of >5000 mg/kg to rats temporarily produced hamaturia (blood in the urine) and failure of defecation.
LD50 Oral (Rat): >5000 mg/kg
LD50 Dermal (Rabbit): >2000 mg/kg
LC50 Inhalation (Rat): >3.4 mg/L (>17.1 mg/L/4hr)
Primary Irritation (Eye): Moderate
Primary Irritation (Skin) Score Draize Method: 1.0 (Not a primary irritant)
Skin Sensitization: None produced
2-Butoxyethanol:
2-butoxyethanol may affect the liver and kidneys and may increase red blood cell hemolysis.
LC50 Inhalation (Rat): 486 ppm (male); 450 ppm (female)

SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE

Releases or Spilled: Remove all sources of ignition and ventilate area. Soak up spill with an inert
absorbent and place into a designated disposal container. Consult local regulatory agency for proper disposition
of material.
Waste Disposal Method: Do not puncture or incinerate containers. When contents are depleted continue
to depress button until all gas is expelled. Dispose of container in accordance with local, state, and federal
regulations.
Handling And Storing: Avoid breathing vapor. Keep away from heat and flame. Use with adequate
ventilation. Do not puncture or incinerate containers. Do not expose to direct sunlight or store at temperatures
above 130F (54C). Store as Level 1 Aerosol (NFPA 30B).
Other Precautions: Please read and follow the directions on the product label; they are your best guide to
using this product in the most effective way, and give the necessary safety precautions to protect your health.

SECTION VIII - EMPLOYEE PROTECTION

Respiratory Protection (Type): None required if good ventilation is maintained. If exposure exceeds
occupational exposure limits (Sec. II), use a NIOSH approved respirator to prevent overexposure.
Ventilation: Local exhaust is adequate under normal conditions, mechanical ventilation is optional.
Protective Gloves: Chemical resistant gloves*.
Eye Protection: Chemical safety glasses are recommended*.
Other Protective Clothing or Equipment: Wear impervious clothing to prevent skin contact.
Work/Hygienic Practices: Ensure strict sanitary conditions are conformed to when working around chemicals.
Protective clothing and equipment should be in accordance with 29 CFR 1910.132 and CFR 1910.133.

SECTION IX - OTHER REGULATORY CONTROLS

FEDERAL:
Toxic Substance Control Act (TSCA): Ingredients of this product are listed on the EPA/TSCA Inventory of Chemical
Substances.
STATE RIGHT-TO-KNOW:
Pennsylvania/New Jersey Right-To-Know (Chemical and CAS No.):
Deionized Water 7732-18-5
2-Butoxyethanol 111-76-2
Tetrasodium salt of
Ethylenediaminetetraacetic Acid 64-02-8
N,N-Dimethyl-1-hexadecylamine-N-oxide 7128-91-8
Liquefied petroleum gas mixture (68476-86-8)
Propane 74-98-6
n-Butane 106-97-8

SECTION X - TRANSPORTATION REQUIREMENTS (D.O.T. CLASSIFICATION)

Shipping Name: Consumer Commodity Hazard Class: ORM-D
NG-- Negligible NA-- Not Applicable NE-- Not Established UN-- Unavailable ND-- Not Determined
While the information set forth herein is believed to be accurate as of the date hereof, the Company makes no
warranty or guarantee, express or implied, and disclaims all liability arising out of the use of this information.
EFFECTIVE DATE: 10/26/04 SUPERCEDES: 04/04/03 PREPARED BY: Ron Cepa