Pro-Link XA003 User Manual

Page

M A T E R I A L S A F E T Y D A T A S H E E T MSDS 261

MSDS

ITEM NUMBER: C-261-XA003
IDENTITY (As Used On Label and List): Down & Out Flying Insect Killer

E M E R G E N C Y M E D I C A L Telephone# [phone] (24 Hrs)
Outside of the U.S.A. Call 651-632-9275
PRODUCT HAZARD RATINGS (NFPA): Health = 1, Fire = 2, Reactivity = 0, Protective Equipment = B
(Rating Legend: 4 = Extreme, 3 = Serious, 2 = Moderate, 1 = Slight, 0 = Minimal)

SECTION I

CLAIRE MANUFACTURING TELEPHONE NUMBER FOR INFORMATION: 1-800-252-4731
500 VISTA AVE.
ADDISON, IL 60101 DATE PRINTED: 12/8/03

NAME OF PREPARER: Ron Cepa

SECTION II - HAZARDOUS INGREDIENTS / IDENTITY INFORMATION

Chemical Names CAS# SARA Title III ACGIH OSHA % By Wt.
SEC 313 TLV/TWA PEL
Mineral Spirits 64742-48-9 NO 177 ppm*/NE 177 ppm*/NE 1-5
Synthtic Isoparaffinic Hydrocarbon 64742-47-8 No NE / NE 177 ppm*/NE 1-5
Liquefied Petroleum Gas Mixture See below No --/-- --/-- 30 – 40
Propane 74-98-6 -- 2500 ppm/NE NE/NE -­n-Butane 106-97-8 -- 800 ppm/NE NE/NE --

Balance of ingredients are non-hazardous or below reportable levels.
* ExxonMobil recommendation

SECTION III - PHYSICAL CHARACTERISTICS

Boiling Point: NA Vapor Pressure (psig): 96 @ 130F / 48 @ 70F Specific Gravity (H20=1): 0.7900
pH: 6-8
Solubility/Water: Moderate Vapor Density (AIR=1): ND Evaporation Rate (Ether=1): ND
Appearance and Odor: Aerosol spray with fragrant odor.

SECTION IV - FIRE AND EXPLOSION HAZARD DATA

Aerosol Flammability: Product does not need to be labeled as flammable as described in 40 CFR 156.10.
Flashpoint: <0F (Propellant); >120F (Concentrate)
Flammable Limits - % Volume In Air (Propellant): LEL: 1.9 UEL: 9.5
Extinguishing Media: Carbon dioxide, water spray, foam, or dry chemical.
Special Fire Fighting Procedures: Containers should be cooled with water to prevent vapor pressure build
up.
Use equipment or shielding, as required, to protect personnel from bursting, rupturing or venting containers.
Unusual Fire and Explosion Hazards: At elevated temperatures (over 54C-130F) containers exposed to direct
flame or heat contact should be cooled with water to prevent weakening of container structure.

SECTION V - REACTIVITY DATA

Stability: Stable Hazardous Polymerization: NA
Incompatibility (Materials to Avoid): Strong oxidizing agents. Hazardous Decomposition Products:
Carbon monoxide and hydrocarbon gases may be formed.
Conditions to Avoid: Keep away from heat, sparks and flames. Dropping of containers may cause bursting.

Page

M A T E R I A L S A F E T Y D A T A S H E E T MSDS 261

SECTION VI - HEALTH HAZARD DATA

Route(s) of Entry - Inhalation: X Eyes: X Skin: X Ingestion: X
HAZARDS IDENTIFICATION: EYES: May cause mild irritation. SKIN: Prolonged or repeated contact may cause
irritation.
INHALATION: Prolonged exposure can be irritating to eyes, nose and respiratory tract. Can be harmful or fatal
at high
concentrations. INHALATION: Asphyxiant. Symptoms are dependent on rapidity of oxygen deficiency development
and
duration. Unconsciousness is immediate in sudden acute asphyxia. Slow development may cause rapid breathing,
dizziness, incoordination, fatigue, and progress to nausea, vomiting, and possibly death. INGESTION: May be
harmful if swallowed. Possible aspiration hazard. May cause inflammation of the lungs.
AGGRAVATED MEDICAL CONDITIONS: May aggravate pre-existing skin conditions.
CHRONIC EFFECTS/TARGET ORGANS: None known.

EMERGENCY AND FIRST AID PROCEDURES: EYES: Immediately flush with plenty of water for at least 15 minutes. Get
prompt medical attention. SKIN: Wash with soap and plenty of water. INHALATION: Remove to fresh air. If
symptoms develop, seek immediate medical attention. If not breathing, give artificial respiration. INGESTION:
Get immediate medical attention. Do NOT induce vomiting unless directed by medical personnel. Never give
anything by mouth to an unconscious person.
CARCINOGENICITY: No regulated ingredients.
TOXICITY INFORMATION: No data available.

SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE

Releases or Spills: Remove all sources of ignition and ventilate area. Soak up spill with an inert
absorbent and
place into a designated disposal container. Consult local regulatory agency for proper disposition of
material.
Waste Disposal Method: Do not puncture or incinerate containers. When contents are depleted continue to
depress button until all gas is expelled. Dispose of container in accordance with local, state, and federal
regulations.
Handling And Storing: Avoid breathing vapor. Keep away from heat, sparks and flame. Use with adequate
ventilation. Do not puncture or incinerate containers. Do not expose to direct sunlight or store at
temperatures above 120F (48.9C). Store as Level 1 Aerosol (NFPA 30B).
Other Precautions: Please read and follow the directions on the product label; they are your best guide
to using this product in the most effective way, and give the necessary safety precautions to protect your
health.

SECTION VIII - EMPLOYEE PROTECTION

Respiratory Protection (Type): None required if good ventilation is maintained. If exposure exceeds
occupational
exposure limits (Sec. II), use a NIOSH approved respirator to prevent overexposure.
Ventilation: General ventilation is adequate under normal conditions; mechanical ventilation is
optional.
Protective Gloves: Chemical resistant gloves are recommended – consult glove manufacturer to determine
the proper type for a specific operation.
Eye Protection: Safety glasses are recommended.
Other Protective Clothing or Equipment: Wear impervious clothing to prevent skin contact.
Work/Hygienic Practices: Ensure strict sanitary conditions are conformed to when working around
chemicals.
Protective clothing and equipment should be in accordance with 29 CFR 1910.132 and CFR 1910.133.

SECTION IX - OTHER REGULATORY CONTROLS

Shipping Name: Consumer Commodity Hazard Class: ORM-D

SECTION X - TRANSPORTATION REQUIREMENTS (D.O.T. CLASSIFICATION)

Shipping Name: Consumer Commodity Hazard Class: ORM-D
NG-- Negligible NA-- Not Applicable NE-- Not Established UN-- Unavailable ND-- Not Determined
While the information set forth herein is believed to be accurate as of the date hereof, the Company makes no
warranty or guarantee, express or implied, and disclaims all liability arising out of the use of this information.

EFFECTIVE DATE: 08/09/01 SUPERCEDES: 03/24/00 PREPARED BY: Ron Cepa