Pro-Link D12589 User Manual

X

X

X

0

0

0

10-10-09

X

1

HAZARD RATING

4-EXTREME
3-HIGH
2-MODERATE
1-SLIGHT
0-INSIGNIFICANT

Fire

Health

Reactivity

Special

MATERIAL SAFETY DATA SHEET

(Prepared according to 29 CFR 1910. 1200)

Date Prepared:

SECTION 1 - PRODUCT IDENTIFICATION

Company Name

Address

Product Name / ID#

500 Chapman St., Canton, MA 02021

Pro-Link, Inc.

BioLink ChemiCenter #58 High Performance Degreaser

Product Type

Emergency Telephone No.

Information Telephone No.

All purpose degreaser

800-535-5053
781-828-9550

Proprietory Product

X

SECTION 2 - HAZARDOUS INGREDIENTS

Chemical Name/Common Name Cas No. Percent (optional) TLV (Source)

None

* Substances Contains no substances

- subject to the reporting requirements of SARA 313 and 40 CFR Part 372.

SECTION 3 - PHYSICAL DATA

Boiling Point (°F)

Solubility In Water

Evaporation Rate (vs H2O)

Appearance and Odor

> 600°F

NE

Golden yellow clear liquid, mild odor.

Specific Gravity

Faster Slower About the SameNEVapor Pressure

(H2O=1.0)

Complete

1.000

Insoluble

± 0.005

Emulsifiable or (Dispersible) Slight (or Partial)

SECTION 4 - FIRE AND EXPLOSION HAZARD DATA

> 300°FFlash Point (T.C.C.) None to boiling NEUpper NELower

Extinguishing Media

Unusual Fire Explosion Hazards

Water spray, dry chemical, foam and CO2.

Treat as oil fire. Use water spray to cool fire-exposed containers.Special Fire Fighting Procedures

Improperly stored rags soaked with material can create conditions that lead to oxidation. Oxidation, can lead to spontaneous combustion.

Flammable Limits

SECTION 5 - REACTIVE DATA

StableStability Strong oxidizing agents. Acids.Incompatibility

Hazardous Decomposition Products

Carbon monoxide and dioxide

SECTION 6 - HEALTH HAZARDS

Threshold Limit Value Product

See Section 2 for Ingredients TLV

Signs Symptoms of Over-exposure (Acute)

if swallowed

Signs Symptoms of Over-exposure (Chronic)

Medical Conditions Aggravated by Over-exposure

Carcinogen/Suspected Carcinogen Ingredients:

SECTION 7 - FIRST AID PROCEDURES -

Eyes

Skin

Ingestion

Inhalation

Do NOT rub eyes. Immediately flush eyes thoroughly with plenty of water for 15 minutes. If irritation persists, get medical

Wash thoroughly with water and soap. Remove contaminated clothing and wash before reuse.

Do NOT induce vomiting. Get medical attention immediately.

Remove to fresh air.

None Established

May cause eye and skin irritation. May cause abdominal discomfort, nausea, and diarrhea

No known adverse effects.

Unknown

Not Applicable Eyes Skin Oral Inhalation

(If any Condition persists - Consult a physician.)

Primary routes of

Exposure

SECTION 8 - SPECIAL PROTECTION INFORMATION

None required if ventilation is adequate.Respiratory Protection

Ventilation requirements Local Exhaust Mechanical

Protective Gloves Safety glassesEye Protection

Other Protective Clothing

Rubber gloves

Impervious clothing to avoid direct skin contact.

As needed for general good ventilation.

SECTION 9 - SPILL OR LEAK PROCEDURES

Avoid uncontrolled releases of this material into the environment. Contain spilled materialSteps to be Taken if Released or Spilled

using absorbent media. Transfer to labeled containers for proper disposal.

Waste Disposal Methods

Check Federal, State and Local regulations.

SECTION 10 - STORAGE AND HANDLING INFORMATION

Precautions to be Taken in handling and Storage

from combustible materials. Keep away from children. Wash thoroughly after handing.

Store upright in a cool dry well ventilated area, in tightly closed containers away

pH

8.5 ± 0.5

X

NTP IARC OSHA None

% VOC (ww)

Vapor Density

X XX

0

NE