Pro-Link D10999 User Manual

Page 1
Eyes, skin, oral and inhalation are the principle routes of exposure.
Page: 1 of 4
5/4/07
781-828-9550
MATERIAL SAFETY DATA SHEET
Company Name Address:
Pro-Link, Inc. Canton, MA 02021
Product Name (ID #):
Product Type:
Chemical Name
Spray & Wipe Cleaner Degreaser
ChemiCenter 36 Blitz
Information Telephone Number(s)
Section 1 - Product Information
EMERGENCY TELEPHONE NUMBER
1-800-535-5053
Section 2 - Information on Ingredients
% by Weight
< 80%
< 5%
<15%
Cas #
111-76-2
1310-58-3
34590-94-8
50 ppm (skin)
OSHA PEL
2mg/m3 100 ppm
ACGIH TLV
20 ppm (TWA) (skin)
C 2mg/m3
100 ppm
*Chemicals marked with an asterick in Section Two are subject to the reporting requirements for Section 313 of Title III of the Superfund Amendments & Reauthorization Act (SARA) of 1986 & 40 CFR Part 372.
Section 3 - Hazards Identification
Emergency Overview:
Keep Out of Reach of Children. WARNING: May cause burns to skin and eyes. Harmful if swallowed, Excessive inhalation of mist may cause headache and dizziness.
Potential Health Effects
Primary Routes of Exposures
Acute Eye Contact:
May cause irritation and burns to eyes.
Acute Skin Contact:
May cause irritation and burns to skin. Possibility of harmful absorption through skin.
Acute Ingestion:
If ingested may cause burns to mouth and throat and also nausea, vomiting, abdominal pain.
Acute Inhalation:
Excessive inhalation may cause dizziness and headache.
Chronic Information:
Unknown
Carcinogenicity:
IARC –
No
NTP –
No
OSHA –
No
ACGIH –
No
Page 2
> 150°F
Page: 2 of 4
ChemiCenter 36 Blitz
5/4/07
Skin Contact:
Section 4 - First Aid Measures
Flush with plenty of water for 10 -15 minutes. If irritation persists, call physician.
Eye Contact:
Immediately flush eyes with plenty of water for 5 - 10 minutes. Get medical attention, if irritation persists.
Ingestion:
Do NOT induce vomiting. Give victim a glass of water. Call a physician or poison control center immediately.
Inhalation:
Remove to fresh air. If qualified, give artificial respiration if breathing is difficult. Get immediate medical attention.
(If any condition persists - Consult a physician).
Section 5 - Fire Fighting Measures
Flash Point (Method):
Fire & Explosion Hazards:
Extinguishing Media:
None
CO2, dry chemical, water fog.
Special Fire Fighting Procedures:
None
Hazardous Combustion Products:
Oxides of carbon
Flammable Limits:
LFL
NE
UFL:
NE
Section 6 - Accidental Release Measures
Contain spill. Neutralize with mild acid. Vacuum up or absord on inert material and place in a container for disposal. Rinse with water.
Section 7 - Handling and Storage
Keep out of reach of children. Wash thoroughly after handling.
Page 3
Liquid
Clear, light green
About the same as water.
13.5 ± 0.5
0.93
92.0 %
Page: 3 of 4
ChemiCenter 36 Blitz
5/4/07
Eye Protection:
Safety Glasses or Goggles
Skin Protection:
Rubber Gloves
Respiratory Protection:
None normally required unless misting occurs, then use a NIOSH approved respirator.
Ventilation Requirements:
Local exhaust to keep below any listed TLV.
Other:
Impervious clothing to avoid direct skin contact.
Section 9 - Physical / Chemical Properties
Section 8 - Exposure Controls Personal Protection
Physical Form:
Color:
Odor:
Boiling Point:
Evaporation Rate:
Vapor Pressure:
Citrus
> 300°F
NE
Section 10 - Stability and Reactivity
Stability:
This product is stable at ambient temperature and pressure.
Hazardous Decomposition Products:
Oxide of carbon
pH:
Specific Gravity:
Solubility:
Freezing Point:
% Volatile:
V.O.C.
100%
NE
89.6%
Hazardous Polymerization:
None
Incompatibility:
Strong acids, oxidizers
Page 4
Not established.
Corrosive liquid, basic, inorganic, n.o.s. (Potassium Hydroxide)
Corrosive
8
UN 3266
2
2
0
Page: 4 of 4
ChemiCenter 36 Blitz
5/4/07
Section 11 - Toxicology Information
Section 12 - Ecology Information
Not established.
Section 13 - Disposal Considerations
May be probable to flush to sanitary sewer system with plenty of water. Check with Federal, State and Local regulations.
Section 14 - Transport Information
DOT
Proper Shipping Name:
Packing Group:
DOT Label:
III
Emergency Guide No:
Hazard Class:
Section 15 - Regulatory Information
Toxic Substances Control Act:
All components of this product are on the TSCA inventory.
Section 311 / 312:
Immediate, delay health hazard, fire hazard.
Section 313:
See section 2.
OSHA Hazard Communications Standard (29 CFR 1910.1200)
This product is hazardous by definition of the Hazard Communication Standard.
154
ID Number:
NPCA Hazardous Material Identification System (HMIS Rating)
Health
Flammability
Reactivity
Section 16 - Other Information
Disclaimer:
or of any other nature, are made with respect to information concerning the product referred to in this document. The information contained herein is, to the best of our knowledge and belief, accurate. However, it is impossible to foresee every health effect or exposure risk incurred by the use of this product. All chemicals present unknown health hazards and should always be used with caution. The information and recommendations contained herein are presented in good faith and are supplied pursuant to 29 CFR 1910.1200. The user should review this information in conjunction with their knowledge of the application intended to determine the suitability of this product for such purpose. In no event will the supplier be responsible for any damages of any nature whatsoever, with all applicable Federal, State and local regulations governing the use and disposal of this material.
Prepared by:
No representations or warranties, either expressed or implied, of merchantability, fitness for a particular purpose
Regulatory Affairs Department.
Loading...