Page: 1 of 4
MATERIAL SAFETY DATA SHEET
11/28/06
Company Name Address:
Pro-Link, Inc. Canton, MA 02021
Information Telephone Number(s)
781-828-9550
Section 1 - Product Information
Product Name (ID #):
Product Type:
Acid Cleaner
Grout Sytem - Enhancer
EMERGENCY TELEPHONE NUMBER
1-800-535-5053
Section 2 - Information on Ingredients
Chemical Name
Phosphoric Acid
Hydrochloric Acid
*Chemicals marked with an asterick in Section Two are subject to the reporting requirements for Section 313 of Title III of the Superfund Amendments & Reauthorization Act (SARA) of 1986 & 40 CFR Part 372.
% by Weight
< 20%
< 5%
Cas #
7664-38-2
7647-01-0
OSHA PEL
1 mg/m3
NE
ACGIH TLV
1 mg/m3
C 7.5 mg/m3
Section 3 - Hazards Identification
Emergency Overview:
Keep Out of Reach of Children. DANGER: Corrosive. May cause irritation and burns to eyes and skin. Harmful if
swallowed. Inhalation of mist and vapors are harmful
Potential Health Effects
Primary Routes of Exposures
Eyes, skin, oral and inhalation are the principle routes of exposure.
Acute Eye Contact:
Irritation and burns to the eyes.
Acute Skin Contact:
irritation and burns to the skin.
Acute Ingestion:
Severe internal irritation and damage can result if ingested.
Acute Inhalation:
May irritate respiratory system.
Chronic Information:
Unknown
Carcinogenicity:
IARC –
No
NTP –
No
OSHA –
No
ACGIH –
No
Page: 2 of 4 11/28/06
Grout Sytem -
Skin Contact:
Section 4 - First Aid Measures
Wash with plenty of water for 10 - 15 minutes. Remove contaminated clothing and wash before reuse. If irritation
persists, get medical help.
Eye Contact:
Flush with water while holding the eyelid open for 10 - 15 minutes. If irritation persists, call physician.
Ingestion:
DO NOT induce vomiting. Drink plenty of water to dilute stomach contents. Get immediate medical attention.
Inhalation:
Remove to fresh air. If qualified, give artificial respiration if breathing is difficult. Get immediate medical attention.
(If any condition persists - Consult a physician).
Section 5 - Fire Fighting Measures
Flash Point (Method):
None
Flammable Limits:
LFL
NA
NAUFL:
Fire & Explosion Hazards:
Extinguishing Media:
NA
NA
Special Fire Fighting Procedures
NA
Hazardous Combustion Products:
Phosphoric oxide fumes under fire condition. Contact with common metals produces Hydrogen gas.
Section 6 - Accidental Release Measures
Contain spill. Neutralize with weak base solution. Flush with large quantity of water.
Section 7 - Handling and Storage
Store away from bases. Keep out of reach of children. Wash thoroughly after handling.
)
Page: 3 of 4 11/28/06
Grout Sytem -
Eye Protection:
Safety Glasses or Goggles
Skin Protection:
Rubber Gloves
Respiratory Protection:
None normally required unless misting occurs, then use a NIOSH approved respirator.
Ventilation Requirements:
Local exhaust to keep below any listed TLV.
Other:
Impervious clothing to avoid direct skin contact.
Section 9 - Physical / Chemical Properties
Section 8 - Exposure Controls Personal Protection
Physical Form:
Liquid
pH:
< 1.0
Color:
Odor:
Boiling Point:
Evaporation Rate:
Vapor Pressure:
Clear amber
Acid
Over 212°F
About the same as water.
NE
Specific Gravity:
Solubility:
Freezing Point:
% Volatile:
V.O.C.
1.860
100%
NE
83% (Theoretical
0
Section 10 - Stability and Reactivity
Stability:
This product is stable at ambient temperature and pressure.
Hazardous Decomposition Products:
Phosphoric oxide fumes under fire condition. Contact with common metals produces Hydrogen gas.
Hazardous Polymerization:
None
Incompatibility:
Bases, common metals -mild steel, copper, brass, bronze.
)
Page: 4 of 4
Grout Sytem -
11/28/06
Section 11 - Toxicology Information
Not established.
Section 12 - Ecology Information
Not established.
Section 13 - Disposal Considerations
Probable to flush small neutralized, diluted solutions to sanitary sewer system. Check all government regulations.
DOT
Proper Shipping Name:
Packing Group:
Corrosive liquid, basic, inorganic, n.o.s. (Hydrochloric Acid, Phosphoric Acid
II
CorrosiveDOT Label: 8Hazard Class: UN 3264ID Number:
Section 14 - Transport Information
Emergency Guide No:
Section 15 - Regulatory Information
Toxic Substances Control Act:
All components of this product are on the TSCA inventory.
Section 311 / 312:
Immediate health hazard.
Section 313:
See section 2.
OSHA Hazard Communications Standard (29 CFR 1910.1200)
This product is hazardous by definition of the Hazard Communication Standard.
154
NPCA Hazardous Material Identification System (HMIS Rating)
3Health 0Flammability 0Reactivity
Section 16 - Other Information
Disclaimer: No representations or warranties, either expressed or implied, of merchantability, fitness for a
particular purpose or of any other nature, are made with respect to information concerning the product referred to in
this document. The information contained herein is, to the best of our knowledge and belief, accurate. However, it is
impossible to foresee every health effect or exposure risk incurred by the use of this product. All chemicals present
unknown health hazards and should always be used with caution. The information and recommendations contained
herein are presented in good faith and are supplied pursuant to 29 CFR 1910.1200. The user should review this
information in conjunction with their knowledge of the application intended to determine the suitability of this product
for such purpose. In no event will the supplier be responsible for any damages of any nature whatsoever, with all
applicable Federal, State and local regulations governing the use and disposal of this material.
Prepared by: Regulatory Affairs Department.
Loading...