Pro-Link B14209 User Manual

LF6 MATERIAL SAFETY DATA SHEET N/A= Not Applicable

Prepared by: Regulatory Affairs Dept. (Prepared According to 29 CFR 1910.1200) Effective Date: 3/12 Revision: n/a

SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION

Supplier’s Name:

Supplier’s Name: Pro-Link, Inc.

Misco Products Corporation

Supplier’s Address:

Supplier’s Address: Canton, MA 02021

Reading, PA

Supplier’s Phone #:

Supplier’s Phone: 1-800-74-LINKS

(610) 926-4106

Product Name: High Performance Degreaser Generic Name: Heavy Duty Cleaner Degreaser Chemical Family: Detergent Blend Formula: Proprietary

Blitz

SECTION 2-INGREDIENT INFORMATION

CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV

Water 7732-18-5 to 100 Dipropylene Glycol Methyl Ether 34590-94-8 10 to 15 N/A N/A N/A 2-butoxyethanol 111-76-2 5 to 10 25ppm 25ppm 50ppm NonIonic Surfactant 9016-45-9 5 to 10 N/A Sodium Metasilicate Pentahydrate Sodium Xylene Sulfonate Tetrasodium EDTA Potassium Hydroxide Dye N/A 0 to 5 N/A

6834-92-0 1300-72-7 64-02-8 1310-58-3

0 to 5 0 to 5 0 to 5 0 to 5

SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA

Boiling Point (°F): 212 F. Specific Gravity: 1.074 Vapor Pressure: 20mm Hg @ 68 F. Vapor Density (Air=1): >1 % Volatile: 70+ pH: 13.0 – 14.0 Solubility in Water: Complete Evaporation Rate (Water=1): <1 Physical Description: Thin purple liquid with characteristic odor.

Flash Point (Method Used): None (TCC) Upper Explosion Limit: N/A Lower Explosion Limit: N/A Extinguishing Media: CO Special Firefighting Procedures: Use self-contained breathing apparatus

in confined areas. Unusual Fire and Explosion Hazards: Keep fire exposed containers cool with water to prevent bursting.

SECTION 5-REACTIVITY DATA

Stability: Stable Hazardous Polymerization: None Hazards Decomposition Products: Alkaline vapors in a fire. Incompatibility (Materials to Avoid): Strong acids.

HMIS Hazardous Materials Identification System

(Ready-to-Use product ONLY)

Health - 1 Flammability - 0 Reactivity – 0 Protection - A

N/A N/A N/A 2mg/m

, Dry Foam, Water Mist

2mg/m

DANGER: Corrosive. Severe Eye and Skin Irritant. Avoid contact with eyes, skin and clothing. Wash thoroughly after handling. Avoid breathing of vapors or mists. Use in well-ventilated area. Keep out of reach of children. For use by trained personnel only. Keep container closed during storage. For institutional and industrial use only.

SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION

SECTION 6-STORAGE AND HANDLING INFORMATION

Effects of Overexposure: Skin: Severe skin irritant. May cause moderate reddening with prolonged contact Eyes: Corrosive. Eye irritant. Liquid and mists may damage eyes, causing corneal

damage. Inhalation: Mists may be irritating to mucous membranes in the nose, throat, and lungs. Ingestion: Irritating to the mouth and throat. May cause headache, nausea, abdominal pain, and diarrhea. Excessive amounts may cause collapse.

First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES Skin: Flush with water. Seek medical attention if irritation persists. Eyes: Flush with large quantities of water, holding eyelids open. Seek medical

attention if irritation persists.

Inhalation: Get to fresh air. Seek medical attention if irritation persists. Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical

attention immediately.

Respiratory Protection: Use in well-ventilated area. Ventilation Requirements: Provide local exhaust to keep TLV of Section 2

ingredients below acceptable limit.

Protective Gloves: Chemical resistant rubber or neoprene. Eye Protection: Safety glasses or chemical splash goggles. Other Protective Equipment: Eyewash station provided nearby.

Steps to be taken in Case Material is Released or Spilled: Floors will become

slippery. Avoid walking in product. Ventilate area well. Keep unessential personnel away. Mop up or otherwise absorb and hold disposal. Avoid discharge to sewer or open waterways. Waste Disposal Method: Any method in accordance with local, state and federal laws. Best method is to recycle or reuse for intended purpose. If discarded, this material and containers should be treated as hazardous waste based on the characteristic of corrosivity as defined under federal RCRA regulations (40 CFR

261). Consult local authorities for disposal in public sewer. Do not dispose of into storm drain, stream, river or to ground. Rinse container thoroughly before discarding in trash.

SECTION 10-REGULATORY INFORMATION

SARA Title III - Section 311/312 -Hazard Categories: Shipping Information:

No - Fire Hazard FOR CONTAINERS > 1 Gallon: Compounds, cleaning liquid, No - Sudden Release of Pressure Hazard (Potassium Hydroxide), 8, NA-1760, PG III No - Reactivity Hazard FOR 1 GALLON CONTAINERS: Cleaning Compound LQ Yes - Immediate (acute) Health Hazard No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON: Cleaning Compound LQ

FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)

This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 and of 40 CFR 372.

CAS# Chemical Name Percent by Weight

111-76-2 2-butoxyethanol (glycol ether) 7% max.

This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.

CAS# Chemical Name Percent by Weight

None

HMIS Hazardous Materials Identification System Health 3 Flammability 0 Reactivity 0 Personal Protection D

SECTION 11-OTHER INFORMATION

This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the application of this information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to provide a safe workplace, using the health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the improper handling and use of this product

REVISION: 3/16/12- Revised Sec. 10 Shipping Information