Pro-Link B14102 User Manual

OPU MATERIAL SAFETY DATA SHEET N/A= Not Applicable

Prepared by: Regulatory Affairs Dept. (Prepared According to 29 CFR 1910.1200) Effective Date: 8/08 Revision: 3/12

SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION

Manufacturer’s Name:

Misco Products Corporation

Manufacturer’s Address:

1048 Stinson Drive Reading, PA 19605

Manufacturer’s Phone #: [phone]

Product Name: One Pass
Generic Name: Ultra Concentrated Speed Stripper
Chemical Family: Solvent Detergent Blend
Formula: Proprietary

1-2-20

Supplier’s Name:

Supplier’s Address:

Supplier’s Phone #:

SECTION 2-INGREDIENT INFORMATION

CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV

Water 7732-18-5 to 100
2-Butoxyethanol 111-76-2 15 to 20 50 ppm 25 ppm N/A
Monoethanolamine 141-43-5 20 to 25 N/A 8mg/M
Benzyl Alcohol 100-51-6 50 to 55 N/A 3 ppm 6 ppm
Nonionic Surfactant 9016-45-9 0 to 5
Fluorochemical Dispersion N/A 0 to 5
Perfume Oils N/A 0 to 5

SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA

Boiling Point (°F): 212 F. Specific Gravity: 1.012
Vapor Pressure: 20mm Hg @ 68 F. Vapor Density (Air=1): >1
% Volatile: 90+ pH: 11.0 – 12.0
Solubility in Water: Complete Evaporation Rate (Water=1): <1
Physical Description: Thin liquid with characteristic odor.

Flash Point (Method Used): >200˚ F. (TCC)
Upper Explosion Limit: N/A Lower Explosion Limit: N/A
Extinguishing Media: Foam, water fog, CO
Special Firefighting Procedures: Wear self-contained breathing apparatus

for confined areas. Keep fire exposed containers cool with water spray.

Unusual Fire and Explosion Hazards: Vapors heavier than air.

SECTION 5-REACTIVITY DATA

Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Alkaline vapors in a fire. Incompatibility (Materials to Avoid): Strong acids, Oxidizers.

SECTION 6-STORAGE AND HANDLING INFORMATION

DANGER Corrosive Liquid. Severe Eye and/or skin damage will result with contact. Avoid contact with eyes, skin and clothing. Wear protective eyewear, gloves and
footwear when handling. Avoid breathing of vapors. Keep out of reach of children. For use by trained personnel only. Keep unauthorized personnel away when
applying to floor. Keep container closed during storage. For institutional and industrial use only. Use in well-ventilated area only. Avoid contact with heat, spark or
open flame.

SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION

Effects of Overexposure:
Skin: Severe skin irritant. May cause moderate reddening, swelling, blistering, and

possible skin damage.
Eyes: Severe eye irritant. Liquid and mists will damage eyes, causing corneal
damage and blindness.
Inhalation: Vapors and mists are irritating to mucous membranes in the nose,
throat, and lungs; characterized by coughing, choking, shortness of breath.
Ingestion: Irritating and corrosive to the mouth and throat. May cause headache,
nausea, abdominal pain, vomiting, and diarrhea. Excessive amounts may cause
collapse.

First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Immediately flush with water. Remove contaminated clothing and shoes.

Seek medical attention immediately.
Eyes: Contact damage is immediate. Immediately flush with large quantities of
water, holding eyelids open. Seek medical attention immediately.

Inhalation: Get to fresh air. Seek medical attention if irritation persists.
Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical

attention immediately.

Respiratory Protection: Use NIOSH approved organic vapor respirator or self­contained breathing apparatus in confined or poorly ventilated areas.
Ventilation Requirements: Provide mechanical exhaust to keep TLV of Section 2
ingredients below acceptable limits.

Protective Gloves: Chemical resistant rubber or neoprene.
Eye Protection: Chemical splash goggles or full-face shield.
Other Protective Equipment: Eye wash station nearby. Protective outerwear and

rubber boots should be worn when using.

Steps to be taken in Case Material is Released or Spilled: Floors will become slippery.
Avoid walking in product. Keep unessential personnel away. Mop up or otherwise absorb
and hold disposal. Avoid discharge to sewer or open waterways.
Waste Disposal Method: Any method in accordance with local, state and federal laws. Best
method is to recycle or reuse for intended purpose. If discarded, this material and containers
should be treated as hazardous waste based on the characteristic of corrosivity as defined
under federal RCRA regulations (40 CFR 261).Consult local authorities for disposal in public
sewer. Do not
thoroughly before discarding in trash.

dispose of into storm drain, stream, river or to ground. Rinse container

SECTION 10-REGULATORY INFORMATION

SARA Title III - Section 311/312 -Hazard Categories: Shipping Information:

No - Fire Hazard FOR CONTAINERS > 1 Gallon: Compounds, cleaning liquid,
No - Sudden Release of Pressure Hazard

No - Reactivity Hazard FOR 1 GALLON CONTAINERS: Cleaning Compound LQ
Yes - Immediate (acute) Health Hazard
Yes - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON : Cleaning Compound LQ

(Monoethanolamine Solution), 8, NA-1760, PG III

Pro-Link, Inc.

Canton, MA 02021

1-800-74-LINKS

3

6 ppm

or dry chemical.

2

HMIS Hazardous Materials
Identification System
Health 3

Flammability 1
Reactivity 0
Personal Protection D

FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)

This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act
of 1986 and of 40 CFR 372.

CAS# Chemical Name Percent by Weight

111-76-2 2-butoxyethanol (Glycol Ether) N-230 15%

This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.

CAS# Chemical Name Percent by Weight

None

SECTION 11-OTHER INFORMATION

This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the application of this
information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to provide a safe workplace, using the
health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the improper handling and use of this product

REVISION: 3/16/12- Revised Sec. 10 Shipping Information