Page 1
Material Safety Data Sheet
Printed: 08.11.2004
Revised: 03.11.2004
Lithofin MN Easy-Clean
—————————————————————————————————————————————
1 Identification of substance:
Product details:
Trade name: Lithofin MN Easy-Clean
Application of the substance / the preparation Cleaning agent/cleaner
Distributor:
GranQuartz, L. P.
P.O. Box 2206
Tucker, GA 30085-2206/USA
Information Department:
see above
Emergency Information:
information department
24-Hour Emergency Telephone Number:
1-800-255-3924 (USA & Canada) or 813-248-0585
—————————————————————————————————————————————
2 Composition/Data on components:
Chemical characterization
Description: Mixture of the substances listed below with non hazardous additions.
Dangerous components:
64-17-5 ethanol 2.5-10 %
RTECS: KQ 6300000
TSCA
All ingredients are listed.
—————————————————————————————————————————————
3 Hazards identification
Hazard description: not applicable
Information pertaining to particular dangers for man and environment
not applicable
Classification system
The classification is in line with internationally approved calculation standards. It is expanded,
however, by information from technical literature and by information furnished by supplier companies.
NFPA ratings (scale 0-4)
Health = 0
Fire = 0
Reactivity = 0
—————————————————————————————————————————————
4 First aid measures
General information
Immediately remove any clothing soiled by the product.
After inhalation No special measures required.
After skin contact Wash with water and soap and rinse carefully.
After eye contact
First check the victim for contact lenses and remove if present.
Rinse opened eye for several minutes under running water.
If symptoms persist consult a doctor.
After swallowing
Rinse out mouth and then drink plenty of water.
Do not induce vomiting
1
Page 2
Material Safety Data Sheet
Printed: 08.11.2004
Revised: 03.11.2004
Lithofin MN Easy-Clean
Never give anything by mouth to a unconscious person.
If larger quantities are swallowed unintentionally or if symptoms occur consult a doctor.
—————————————————————————————————————————————
5 Fire fighting measures
Suitable extinguishing agents
The product is not combustible and does not support combustion.
Use fire fighting measures that suit the environment.
Special hazards caused by the material, its products of combustion or resulting gases:
Formation of toxic gases is possible during heating or in case of fire.
Protective equipment:
Wear self-contained respiratory protective device.
Additional information
Dispose of fire debris and contaminated fire fighting water in accordance with official regulations.
Collect contaminated fire fighting water separately. It must not enter the sewage system.
—————————————————————————————————————————————
6 Accidental release measures
Person-related safety precautions:
Ensure adequate ventilation
Wear protective clothing.
Particular danger of slipping on leaked/spilled product.
Measures for environmental protection:
Do not allow product to reach sewage system or any water course.
Do not allow to penetrate the ground/soil.
Measures for cleaning/collecting:
Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust).
Send for recovery or disposal in suitable receptacles.
Dispose contaminated material as waste according to item 13.
—————————————————————————————————————————————
7 Handling and storage
Handling
Information for safe handling:
No special precautions are necessary if used correctly.
Information about protection against explosions and fires:
No special measures required.
Storage
Requirements to be met by storerooms and receptacles:
Store receptacles tightly closed at a cool and dry place with sufficient ventilation
Information about storage in one common storage facility: Not required.
Further information about storage conditions: None.
—————————————————————————————————————————————
8 Exposure controls and personal protection
Additional information about design of technical systems:
No further data; see item 7.
Components with limit values that require monitoring at the workplace:
64-17-5 ethanol
PEL: 1900 mg/m³, 1000 ppm
REL: 1900 mg/m³, 1000 ppm
TLV: 1880 mg/m³, 1000 ppm
Additional information:
The lists that were valid during the creation were used as basis.
Personal protective equipment
General protective and hygienic measures
2
Page 3
Material Safety Data Sheet
Printed: 08.11.2004
Revised: 03.11.2004
Lithofin MN Easy-Clean
Keep away from foodstuffs, beverages and feed.
Avoid contact with the eyes and skin.
Use skin protection cream for skin protection.
The usual protective measures based on the application have to be followed.
All protective equipment used shall be according to 29 CFR.1910 Subpart I Personal Protective
Equipment
Breathing equipment:
Not necessary if room is well-ventilated.
A respiratory protection program that meets OSHA's 29 CFR 1910.134 and ANSI Z88.2 requirements
or European Standard EN 149 must be followed whenever workplace conditions warrant a respirator's
use.
Always use a NIOSH or European Standard EN 149 approved respirator when necessary.
Protection of hands:
Wear chemically resistant protective gloves (tested according to DIN EN 374)
The glove material has to be impermeable and resistant to the product/ the substance/ the
preparation.
Selection of the glove material on consideration of the penetration times, rates of diffusion and the
degradation
After use of gloves apply skin-cleaning agents and skin cosmetics.
Material of gloves
Butyl rubber, BR
The selection of the suitable gloves does not only depend on the material, but also on further marks of
quality and varies from manufacturer to manufacturer.
Penetration time of glove material
The exact break trough time has to be found out by the manufacturer of the protective gloves and has
to be observed.
As protection from splashes gloves made of the following materials are suitable:
Nitrile rubber, NBR
Eye protection: Goggles recommended during refilling.
Body protection: Protective work clothing.
—————————————————————————————————————————————
9 Physical and chemical properties:
General Information
Form: Fluid
Color: Colorless, clear
Odor: Pleasant
Value/Range Unit Method
Change in condition
Melting point/Melting range: undetermined
Boiling point/Boiling range: > 90 ° C
Flash point: Does not support combustion.
Auto igniting: Product is not self igniting.
Danger of explosion: Product does not present an explosion hazard.
Density: at 20° C ~ 0.99 g/cm³
Solubility in / Miscibility with Water: Fully miscible
pH-value: at 20° C ~ 6.9-9.5 in delivery state
—————————————————————————————————————————————
10 Stability and reactivity
Thermal decomposition / conditions to be avoided:
No decomposition if used and stored according to specifications.
Dangerous reactions No dangerous reactions known
3
Page 4
Material Safety Data Sheet
Printed: 08.11.2004
Revised: 03.11.2004
Lithofin MN Easy-Clean
Dangerous products of decomposition:
No dangerous decomposition products known
—————————————————————————————————————————————
11 Toxicological information
Acute toxicity:
LD/LC50 values that are relevant for classification:
No toxicity data are available for the product itself.
Primary irritant effect:
on the skin: No irritant effect.
on the eye: No irritating effect.
Sensitization: No sensitizing effects known.
Additional toxicological information:
When used and handled according to specifications, the product does not have any harmful effects
according to our experience and the information provided to us.
—————————————————————————————————————————————
12 Ecological information:
Ecotoxical effects:
Acquatic toxicity:
Presently there are no ecotoxicological values available.
General notes:
Water hazard class 1 (Self-assessment): slightly hazardous for water.
Do not allow undiluted product or large quantities of it to reach ground water, water course or sewage
system. Danger to drinking water is possible if large quantities leak into the ground or into water
course.
—————————————————————————————————————————————
13 Disposal considerations
Product:
Recommendation
Disposal according to instructions of local authorities.
Uncleaned packagings:
Recommendation:
Disposal must be made according to official regulations.
—————————————————————————————————————————————
14 Transport information
DOT regulations:
Hazard class: -
No hazardous material according to the regulations
Land transport ADR/RID (cross-border)
ADR/RID class: -
No hazardous good according to the regulation.
Maritime transport IMDG:
IMDG Class: -
No hazardous material according to the regulations
Marine pollutant: No
Air transport ICAO-TI and IATA-DGR:
ICAO/IATA Class: -
No hazardous material according to the regulations
—————————————————————————————————————————————
15 Regulations
Cancerogenity categories
4
Page 5
Material Safety Data Sheet
Printed: 08.11.2004
Revised: 03.11.2004
Lithofin MN Easy-Clean
EPA (Environmental Protection Agency)
78-93-3 butanone: D
IARC (International Agency for Research on Cancer)
void
NTP (National Toxicology Program)
void
TLV (Threshold Limit Value established by ACGIH)
64-17-5 ethanol: A4
MAK (German Maximum Workplace Concentration)
64-17-5 ethanol: 5
NIOSH-Ca (National Institute for Occupational Safety and Health)
void
OSHA-Ca (Occupational Safety & Health Administration)
void
Markings according to EU guidelines:
The product has been classified and marked in accordance with directives on hazardous materials.
Regulation or reporting requirements USA
Sara section 355
not listed
Sara section 313
not listed
Prop. 65 - Cancer
not listed
Prop. 65 - Repr. tox.
not listed
—————————————————————————————————————————————
16 Other information:
This information is based on our present knowledge. However, this shall not constitute a guarantee for
any specific product features and shall not establish a legally valid contractual relationship.
Department issuing MSDS:
KFT-Chemieservice Marienstr. 3 D-64347 Griesheim
Postfach 1451 D-64345 Griesheim
Tel.: +49-6155-823241
Fax: +49-6155-823246
Contact: Angelika Torges
————————————————————————————————————————————
5
Loading...