Pro-Link 06775 User Manual

Detail Plus

NFPA/HMIS : Health -2

Flammability - 0
Reactivity - 0

Complies With USDL Safety and Health Regulations, (29
CFR 1910.200)
Material Safety Data Sheet
US Department Of Labor

SECTION - 1 CHEMICAL AND COMPANY

PRODUCT USE: Degreaser

PRO-LINK
510 Chapman Street
Canton, MA 02021

EMERGENCIES: 1-866-303-6948

REVISION DATE: 02/14/05

SECTION - 2 COMPOSITION OF INGREDIENTS

CAS # CHEMICAL NAMES Wt% TLV (UNITS)

111-76-2 Glycol Ether EB < 10 25 (PPM) skin

SECTION - 3 HAZARDS INFORMATION

Primary Route(s) of Entry: Skin contact /absorption and
inhalation
Signs and Symptoms of Overexposure: Gastrointestinal
irritation (nausea, vomiting, diarrhea), irritation to nose,
throat, and respiratory tract.
Target Organ Effects:Overexposure to this material (or its
components) has been suggested as a cause of the
following
effects in laboratory animals and may aggravate pre-existing
disorders or these organs in humans:chronic ingestion may
cause kidney and liver lesions at high doses.

IMMEDIATE HEALTH EFFECTS
EYES:Exposure may cause noticeable pain, and severe

irritation and transient corneal injury.

SKIN:Exposure may cause mild skin irritation. Prolonged or
repeated exposure may dry the skin. Symptoms may include
redness, burning, drying and cracking and skin burns.
Additional symptoms: of skin contact may include: allergic
reaction. Skin absorption is possible, but harmful effects are
not expected from this route of exposure under normal
handling and use.
INHALATION: Exposure to vapor or mist is possible. Short
term inhalation is not likely to cause harmful effects:
breathing l arge amounts may be harmful. Symptoms are
more typically seen at air concentrations exceeding the
recommended exposure limits.

IDENTIFICATION

INGESTION: Single dose oral toxicity is low. Swallowing

small amounts during normal handling is not likely to cause
harmful effects: swallowing large amounts may be harmful.
REPRODUCTIVE / DEVELOPMENTAL INFORMATION: No
Data
CARCINOGENIC INFORMATION:This material is not listed
as a carcinogen by IARC, NTP, or OSHA

LONG TERM EFFECTS:No Data

SECTION - 4 FIRST AID MEASURES

EYES- Immediately flush with water. Remove contact

lenses, if applicable, and continue flushing with water for 15
minutes. Call physician immediately.
SKIN-Immediately flush with water for 15 minutes. Call a
physician if irritation persists. Completely decontaminate
clothing, shoes, and leather goods before reuse or discard.
INHALATION- If symptoms develop move victim to fresh air.
If symptoms persist, call a physician.
INGESTION- Do not induce vomiting. Rinse mouth with
water, then drink one or two glasses of water or milk. Call a
physician, immediately. Never give anything by mouth if
victim is unconscious, is rapidly losing consciousness or is
convulsing.

SECTION - 5 FIRE FIGHTING MEASURES

Flash Point: No Flash at Boil (C.C. method)
Explosive limits: Not Applicable
Autoignition Temperature: Not Applicable
Hazardous Products of Combustion: Not Applicable
Extinguishing Media: Not Applicable
Fire Fighting Instructions: Avoid contact with this material.

Avoid wallking in spilled material. Wear protective clothing
for skin and eyes

SECTION - 6 ACCIDENTAL RELEASE MEASURES

Small Spill: Absorb with an inert solid and scoop up for

disposal, then rinse soiled area with water down the drain.
Large Spill: Stop leak at the source and collect into a
suitable container, then treat as a small spill.

SECTION - 7 HANDLING AND STORAGE

Handling: Containers of this material may be hazardous

when emptied. Since emptied containers retain product
residues (vapor, liquid, and/or solid), all hazard precautions
given in the data sheet must be observed.
Storage:Store in a cool, dry place. Keep container closed
when not in use.

SECTION - 8 EXPOSURE CONTROLS / PERSONAL

PROTECTION

Eye Protection: Chemical Splash goggle in compliance with

OSHA regulations are advised: however , OSHA regulations
also permit other type safety glasses. Consult your safety
representative.
Skin Protection: Wear rubber gloves (consult your safety
equipment supplier). To prevent repeated or prolonged skin
contact, wear impervious clothing and boots.
Respiratory Protection: If workplace exposure limits of
product or any component are exceeded (see exposure
guidelines),
NIOSH/OSHA approved air supplied respirator is advised in
the absence of proper environmental control. OSHA relations

also permit other NIOSH/OSHA respirators (negative
pressure type) under specific conditions (see your industrial
hygienist). Engineering or administrative controls should be
implemented to reduce exposure.
Engineering Controls: Provide sufficient mechanical
(general and local exhaust) ventilation to maintain exposure
below level of overexposure (from known, suspected or
apparent adverse effects).

SECTION - 9 PHYSICAL AND CHEMICAL PROPERTIES

Appearance and odor: Thin, lgreen liquid with a glycol
ether odor

pH Concentrate: 12.5 - 13.5
Vapor Pressure: Unknown
Vapor Density: Unknown
Boiling Point: 212 Degrees Fahrenheit
Solubility in Water: Complete
Percent Volatile: 98%
Specific Gravity: (H2O =1) 1.01 +/- 0.02

SECTION - 10 STABILITY AND REACTIVITY

Chemical Stability: Stable
Conditions to Avoid: Temperature Extremes
Incompatibility: None
Hazardous Decomposition: None
Hazardous Polymerization: Will not Occur

SECTION - 11 TOXICOLOGICAL INFORMATION

No Data Available

SECTION - 12 ECOLOGICAL INFORMATION

No Data Available

SECTION - 13 DISPOSAL CONSIDERATION

Waste Disposal Information:Dispose of in accordance with

all applicable Federal, State, and Local regulations.
RCRA Information: If this material becomes a waste, it
would be considered hazardous under 40 CFR 261.22. and
would be classified as EPA Waste Number D002.

SECTION - 14 TRANSPORT INFORMATION

DOT Information 49 CFR 172.101

DOT Description: 33440 Class 55
DOT Hazard Class: Non Hazardous
Hazardous Component: None
Reportable Quantity (RQ) - 49 CFR 172.101
Not Applicable

SECTION - 15 REGULATORY INFORMATION

US Federal Regulations:

TSCA (Toxic Substances Control Act) Status
TSCA (United States) The intentional ingredients of this
product are listed.

CERCLA RQ - 40 CFR 355 Appendix A: None
SARA 302 Components 40 CFR Appendix A: None
Section 311/312 Hazard Class 40 CFR 370.2
Immediate (X) Delayed (X) Fire ( ) Reactivity ( ) Sudden
Release of Pressure ( )

SARA 313 Components - 40 CFR 372.65
CAS # Chemical Names %
N/A * Glycol Ethers < 10.0
* Listed in Section 2 as Ethylene Glycol Monobutyl Ether

State and Local Regulations
California Proposition 65: None
California SCAQMD Rule 443.1 VOC’s > 250g/L
North Carolina Administrative Code 2D.1104 and 2B.0610:
None
South Carolina Regulation 62.5 Standard Number 8
Ethylene Glycol Monobutyl Ether <10.0

The information accumulated herein is believed to be
accurate but is not warranted to be whether originating with
the company or not. Recipients are advised to confirm in
advance of need that the information is current, applicable
and suitable to their circumstances.

This information was compiled from current manufacturer’s
MSDS’s of the component parts of the product. as well as
other sources, such as:

Code of Federal Regulations 29, Revised as of July 1. 1994.
Code of Federal Regulations 40, Revised as of July 1, 1994.
ACGIH, Guide to Occupational Exposure Values, 1996.
ANSI Z129.1-1994, Precautionary Labeling for Hazardous

Industrial Chemicals.
Hazard Communication Handbook, A Right To Know

Compliance Guide. Craig A. Moyer & Michael Francis. Clark
Broadman Company. Ltd. New York, NY 1992

RCRA Regulations and Keyword Index, Compiled and
Published by McCoy and Associates, Inc Lakewood,
Colorado. 1992.

SECTION - 16 OTHER INFORMATION