Pro-Link 06104 User Manual

Sledge Hammer

NFPA/HMIS : Health -1 Flammability - 0 Reactivity - 0

Complies With USDL Safety and Health Regulations, (29 CFR

1910.200) Material Safety Data Sheet US Department Of Labor

SECTION - 1 CHEMICAL AND COMPANY IDENTIFICATION

PRODUCT USE: Carpet Pre-Spray

Pro-Link 510 Chapman Street Canton, MA 02021

EMERGENCIES: 1-866-303-6948 REVISION DATE: 09/02/03

SECTION - 2 COMPOSITION OF INGREDIENTS

CAS # CHEMICAL NAMES Wt% TLV (UNITS)

34590-94-8 Dipropylene Glycol Monomethyl ether <20 100ppm Skin 9016-47-9 Nonoxanol <10 N/E

N/E=No established

SECTION - 3 HAZARDS INFORMATION

Primary Route(s) of Entry: Skin contact /absorption and inhalation Signs and Symptoms of Overexposure: Gastrointestinal irritation (nausea, vomiting, diarrhea), irritation to nose, throat, and respiratory tract. Target Organ Effects: Overexposure to this material (or its components) has been suggested as a cause of the following effects in laboratory animals and may aggravate pre-existing disorders or these organs in humans: chronic ingestion may cause kidney and liver lesions at high doses.

IMMEDIATE HEALTH EFFECTS EYES: Exposure may cause noticeable pain, and severe irritation and

transient corneal injury. SKIN: Exposure may cause mild skin irritation. Prolonged or repeated exposure may dry the skin. Symptoms may include redness, drying and cracking. Additional symptoms: of skin contact may include: allergic reaction. Skin absorption is possible, but harmful effects are not expected from this route of exposure under normal handling and use. INHALATION: Exposure to vapor or mist is possible. Short-term inhalation is not likely to cause harmful effects: breathing large amounts may be harmful. Symptoms are more typically seen at air concentrations exceeding the recommended exposure limits. INGESTION: Single dose oral toxicity is low. Swallowing small amounts during normal handling is not likely to cause harmful effects: swallowing large amounts may be harmful.

REPRODUCTIVE / DEVELOPMENTAL INFORMATION: No Data CARCINOGENIC INFORMATION:This material is not listed as a

carcinogen by IARC, NTP, or OSHA

LONG TERM EFFECTS: No Data

SECTION - 4 FIRST AID MEASURES

Eyes: Flush with water for 15 minutes and contact a physician. S

Thoroughly wash exposed skin with soap a INGESTION: If swallowed, do not induce vomiting. Drink 2 to 3 gl

asses of water and contact a physician.

N ALL CASES : If symptoms persist, seek medical attention.

Flash Point: No flash to boil (C.C. method) Explosive limits: Not Applicable Autoignition Temperature: Not Applic Hazardous Products of Combustion: Not Applicable Extinguishing Media: Not Applicable

ire Fighting Instructions: Avoid contact with this material. Avoid

walking in spilled material. Wear es

Small Spill: Absorb with an inert solid and scoop up for disposa rinse soiled area with water down the

arge Spill: Stop leak at the source and collect into a suitable

container, then treat as a small spill.

Handling: Containers of this material may be hazardous when emptied. Since emptied containers retain product residues (vapor, liquid, and/or solid), all hazard precautions given in the data sheet must

torage: Store in a cool, dry place. Keep container closed when not in

use.

SECTION - 8 EXPOSURE CONTROLS / PERSONAL PROTECTION

Eye Protection: Chemical Splash goggle in compliance with OSHA

regulations are advised: however , OSHA regulations also permit other type safety glasses. Consult your safety representative. Skin Protection: Wear rubber g supplier). To prevent repeated or prolonged skin contact, wear impervious clothing and boots. Respiratory Protection: If workplace exposure limits of product component are exceeded (see exposure guidelines), NIOSH/OSHA approved air supplied respirator is advised in the absence of proper environmental control. OSHA relations other NIOSH/OSHA respirators (negative pressure type) under speci conditions (see your industrial hygienist). Engineering or administrative controls should be implemented to reduce expo Engineering Controls: Provide sufficient mechanical (general and lo

cal exhaust) ventilation to maintain exposure below level of

overexposure (from know

Appearance and odor: Thin, amber liquid with a fresh scentr pH Concentrate: 10.5-11.5 Vapor Pressure: Unknown Vapor Density: Unknown Boiling Point: 212 Degrees Fahrenheit Solubility in Water: Complete

ercent Volatile: 90%

P Specific Grav

Chemical Stability: Stable Conditions to Avoid: Temperature Incompatibility: None

azardous Decomposition: None

azardous Polymerization: Will not Occur

SECTION - 5 FIRE FIGHTING MEASURES

protective clothing for skin and ey

SECTION - 6 ACCIDENTAL RELEASE MEASURES

SECTION - 7 HANDLING AND STORAGE

be observed.

loves (consult your safety equipment

n, suspected or apparent adverse effects).

SECTION - 9 PHYSICAL AND CHEMICAL PROPERTIES

ity: (H2O =1) 1.01 +/- 0.02

SECTION - 10 STABILITY AND REACTIVITY

nd water.

able

drain.

Extremes

KIN:

l, then

or any

also permit

fic

sure.

No Data Available

Waste Disposal Information: Dispose of in accordance with all

applicable Federal, State, and Local regulations.

CRA Information: If this material becomes a waste, it would not be

considered hazardous under 40 CFR 261.22

SECTION - 11 TOXICOLOGICAL INFORMATION

SECTION - 12 ECOLOGICAL INFORMATION

SECTION - 13 DISPOSAL CONSIDERATION

SECTION - 14 TRANSPORT INFORMATION

DOT Information 49 CFR 172.101 DOT Description: 33440 Class 55 DOT Hazard Class: Non Hazardous Hazardous Com

eportable Quantity (RQ) - 49 CFR 172.101

Not Applicable

US Federal Regulations: TSCA (Toxic Substances Control Act) Status TSCA (United States) the intentional ingredients listed. CERCLA RQ - 40 CFR 355 Appendix A: None SARA 302 Components 40 CFR Appendix A: None Section 311/3 Immediate (X) Delayed (X) Fire ( ) Reactiv Pressure ( ) SARA 313 Co CAS # Chemical Names none State and Local Regulations California Proposition 65: None California SCAQMD Rule 443.1 VOC’s < 250g/L N

orth Carolina Administrative Code 2D.1104 and 2B.0610: None

South Carolina Regulation 62.5 Standard Number 8 none

The information accumulated herein is believed to be accurate not warranted to be whether originating with the company or not. Recipients are advised to confirm in advance of need that the information is current, applicable and suitable to their circumstances. This

information was compiled from current manufacturer’s MSDS’s of the component parts of the product. as well as other sources, as: Code of Federal Regulations 29, Revised as of July 1. 19 Code of Federal Regulations 40, Revised as of July 1, 1994. ACGIH, Guid ANSI Z129.1-1994, Precautionary Labeling for Hazardous Industria Chemicals. Hazard Communication H Guide. Craig A. Moyer & Michael Francis. Clark Broadman Company Ltd. New York, NY 1992 \RCRA Regulations and Keyword Index, Compiled and Published by McCoy and Associates, Inc Lakewood, Colorado. 1992.

ponent: None

SECTION - 15 REGULATORY INFORMATION

of this product are

12 Hazard Class 40 CFR 370.2

ity ( ) Sudden Release of

mponents - 40 CFR 372.65

SECTION - 16 OTHER INFORMATION

but is

such

94.

e to Occupational Exposure Values, 1996.

andbook, A Right To Know Compliance