Projecta 1VD-FTV User Manual

HEAVY DUTY DUAL BATTERY TRAY

Tray Fitting Instructions to suit Auxiliary battery for
TOYOTA LANDCRUISER 200 DS SERIES

Years: September 2016 onwards
Models: 1VD-FTV 4.5 Litre V8 Turbo Diesel

P/No. HDBT120

IMPORTANT SAFETY INFORMATION

Please read this instruction thoroughly before fitting the tray.

This product is recommend to be fitted by a workshop or qualified mechanical person.

WARNINGS

• Before installation, make sure that the vehicle is stationary and the wheels chocked.

• Be careful when laying wires, not to cause any electrical shorts or wire breakage.

• After installation ensure the bonnet can close without hitting the newly installed battery
and battery tray.

• Ensure original parts and pipes have sufficient clearance from the tray and battery.
Push them away from the tray if required.

SPECIFICATIONS

Max Battery Size (mm) L300x W174 x H220

Max Battery Weight 28Kg

Recommended batteries Exide LCS27-97and Century NS70TMF

Approximate fitting time 30 minutes

Recommended Dual P/No: IDC25, DBC150, VSR200
Battery System

Tray Location Engine Bay, Drivers Side Front

KIT INCLUDES

Hardware

2 x M6 Countersunk Bolts
1 x M8 Bolt
2 x J Bolts

2

Tray

Special Top
Mount

J Bolts

FITTING INSTRUCTIONS

1. Make sure that the vehicle is stationary, the engine is switched off and cool

Disconnect the negative terminal from the main battery.

2. Locate the tray behind the driver’s side headlight.

3. Locate the two captive nuts with the two holes in the tray and secure with the
2 x M6 countersunk bolts.

4. Remove the radiator cover panel, replace after battery secured.

5. Fit Auxiliary battery.

6. Place the Special Top Mount to secure the battery with the J Bolts and bolt the
front of the Special Top Mount to the radiator support panels using the M8 Bolt
to the captive nut on the panel.

7. Use the factory J bolt mount near the air cleaner in place of the hole in the tray.

8. Replace radiator cover panel.

9. Reconnect the negative battery terminal to the main starter battery. Before closing
the bonnet make sure the battery and tray does not hit the bonnet.

For assistance throughout the installation procedure please call our customer service

representatives on 1800 113 443.

3

WARRANTY STATEMENT

APPLICABLE ONLY TO PRODUCT SOLD IN AUSTRALIA

Brown & Watson International Pty Ltd of 1500 Ferntree Gully Road, Knoxfield, Vic.,
telephone [phone], fax [phone], warrants that all products described in
its current catalogue (save and except for all bulbs and lenses whether made of glass or
some other substance) will under normal use and service be free of failures in material and
workmanship for a period of one (1) year (unless this period has been extended as indicated
elsewhere) from the date of the original purchase by the consumer as marked on the invoice.
This warranty does not cover ordinary wear and tear, abuse, alteration of products or
damage caused by the consumer.

To make a warranty claim the consumer must deliver the product at their cost to the original
place of purchase or to any other place which may be nominated by either BWI or the retailer
from where the product was bought in order that a warranty assessment may be performed.
The consumer must also deliver the original invoice evidencing the date and place of
purchase together with an explanation in writing as to the nature of the claim.

In the event that the claim is determined to be for a minor failure of the product then
BWI reserves the right to repair or replace it at its discretion. In the event that a major
failure is determined the consumer will be entitled to a replacement or a refund as well as
compensation for any other reasonably foreseeable loss or damage.

This warranty is in addition to any other rights or remedies that the consumer may have
under State or Federal legislation.

IMPORTANT NOTE

Our goods come with guarantees that cannot be excluded under the Australian Consumer
Law. You are entitled to a replacement or refund for a major failure and compensation for
any other reasonably foreseeable loss or damage. You are also entitled to have the goods
repaired or replaced if the goods fail to be of acceptable quality and the failure does not
amount to a major failure.

Distributed by

AUSTRALIA
Brown & Watson International Pty Ltd

Knoxfield, Victoria 3180
Telephone [phone]
Facsimile [phone]
National Toll Free 1800 113 443

NEW ZEALAND
Narva New Zealand Ltd

22–24 Olive Road
PO Box 12556 Penrose
Auckland, New Zealand
Telephone [phone]
Facsimile [phone]

IS367
Issue 30.03.17