Proform 831299201 Owner’s Manual

Model No. 831.299202
Serial No.

The serial number is found in the location
shown below. Write the serial number in

the space above for future reference.

PRO"r

Serial Number

Decal

EXERCISE

EQ U I PM ENT

HELPLINE!

1-800-736-6879

P 0 W E R I N C L I N E

CAUTION

Read all precautions and in-
structions inthis manual before

using this equipment. Save this
manual for future reference.

USER'S MANUAL

SEARS, ROEBUCK AND CO., HOFFMAN ESTATES, IL 60179

TABLE OF CONTENTS

IMPORTANT PRECAUTIONS ................................................................. 2

BEFORE YOU BEGIN ....................................................................... 4

ASSEMBLY ............................................................................... 5

OPERATION AND ADJUSTMENT ............................................................. 7

HOW TO FOLD AND MOVE THE TREADMILL .................................................. 10

TROUBLE-SHOOTING ..................................................................... 12

CONDITIONING GUIDELINES ............................................................... 14

ORDERING REPLACEMENT PARTS .................................................. Back Cover

FULL 90 DAY WARRANTY ........................................................... Back Cover

Note: An EXPLODED DRAWING and a PART LIST are attached in the center of this manual. Save the
EXPLODED DRAWING and PART LIST for future reference.

IMPORTANT PRECAUTIONS

WARN ING: TO reduce the risk of burns, fire, electric shock, or injury to persons, read the

following important precautions and information before operating the treadmill.

1. It is the responsibility of the owner to ensure

that all users of this treadmill are adequately
informed of all warnings and precautions.

2. Use the treadmill only as described.

3. Place the treadmill on a level surface, with 8

feet of clearance behind it. Do not place the

treadmill on a surface that blocks any air

openings. To protect the floor or carpet from
damage, place a mat under the treadmill.

.

Keep the treadmill indoors, away from mois- or more amps. No other appliance should be
ture and dust. Do not put the treadmill in a on the same circuit. Do not use an extension
garage or covered patio, or near water, cord.

5. Do not operatethe treadmill where aerosol

products are used or where oxygen is being
administered.

6. Keep children under the age of 12 and pets

away from the treadmill at all times.

7. The treadmill should be used only by persons
weighing 250 pounds or less.

8. Never allow more than one person on the sor away from heated surfaces.

treadmill at a time.

9. Wear appropriate exercise clothing when

using the treadmill. Do not wear loose cloth-

ing that could become caught in the treadmill.

Athletic support clothes are recommended for
both men and women. Always wear athletic

shoes. Never use the treadmill with bare feet,
wearing only stockings, or in sandals.

10. When connecting the power cord (see page 7),
plug the power cord into a surge suppressor
(not included) and plug the surge suppressor

into a grounded circuit capable of carrying 15

11. Use only a single-outlet surge suppressor
that is UL 1449 listed as a transient voltage
surge suppressor (TVSS). The surge suppres-
sor must have a UL suppressed voltage rating
of 400 volts or less and a minimum surge dis-
sipation of 450 joules. The surge suppressor
must be electrically rated for 120 volts AC and
15 amps.

12. Keep the power cord and the surge suppres-

13. Never move the walking belt while the power

is turned off. Do not operate the treadmill if
the power cord or plug is damaged, or if the
treadmill is not working properly. (See BE-
FORE YOU BEGIN on page 4 if the treadmill
is not working properly.)

14. Never start the treadmill while you are
standing on the walking belt. Always hold
the handrails while using the treadmill.

to raise, lower, or move the treadmill.

18. When folding or moving the treadmill, make
sure that the storage latch is fully closed.

19. Inspect and tighten all parts of the treadmill
every three months.

20. Never drop or insert any object into any
opening.

15.

The treadmill is capable of high speeds.
Adjust the speed in small increments to
avoid sudden jumps in speed.

16.

Never leave the treadmill unattended while
it is running. Always remove the key and un-

plug the power cord when the treadmill is
not in use.

17.

Do not attempt to raise, lower, or move the rized service representative only.

treadmill until it is properly assembled. (See
ASSEMBLY on pages 5 and 6, and HOW TO 22. This treadmill is intended for in-home use

MOVE THE TREADMILL on page 10.) You only. Do not use this treadmill in any com-
must be able to safely lift 45 pounds (20 kg) mercial, rental, or institutional setting.

21. DANGER: Always unplug the power

cord immediately after use, before cleaning
the treadmill, and before performing the

maintenance and adjustment procedures

described in this manual. Never remove the

motor hood unless instructed to do so by
an authorized service representative.
Servicing other than the procedures in this

manual should be performed by an autho-

WARN ING: Before beginning this or any exercise program, consult your physician. This

is especially important for persons over the age of 35 or persons with pre-existing health problems.
Read all instructions before using. SEARS assumes no responsibility for personal injury or property

damage sustained by or through the use of this product.

SAVE THESE INSTRUCTIONS

The decal shown below has been placed on your treadmill. If the
decal is missing, or if it is not legible, please call our toll-free
HELPLINE to order a free replacement decal (see the back cover
of this manual). Apply the decal in the location shown.

Note: Decal is shown at 38% of actual size.

3

BEFORE YOU BEGIN

Thank you for selecting the new PROFORM ®T35
treadmill. The T35 treadmill combines advanced tech-

nology with innovative design to let you enjoy an excel-
lent form of cardiovascular exercise in the convenience

and privacy of your home. And when you're not exer-
cising, the unique T35 can be folded up, requiring less
than half the floor space of other treadmills.

For your benefit, read this manual carefully before
using the treadmill. If you have additional questions,

please call our toll-free HELPLINE at 1-800-736-6879,

Storage Latch
Handrail

Monday through Saturday, 7 a.m. until 7 p.m. Central
Time (excluding holidays). To help us assist you,
please note the product model number and serial num-
ber before calling. The model number of the treadmill

is 831.299202. The serial number can be found on a
decal attached to the treadmill (see the front cover of

this manual for the location).

Before reading further, please review the drawing
below and familiarize yourself with the parts that are

labeled.

Console

Water Bottle Holder

(Bottle not included)

Walking Belt

Foot

Rear Roller
Adjustment Bolts

BACK

Upright

RIGHT SIDE

Circuit

Breaker

Power

Cord

Cushioned Walking Platform

for maximum exercise comfort

Incline Leg

ASSEMBLY

Assembly requires two people. Set the treadmill in a cleared area and remove all packing materials. Do not

dispose of the packing materials until assembly is completed. Assembly requires the included allen wrench _
and your own phillips screwdriver

Note: The underside of the treadmill walking belt is coated with high-performance lubricant. During shipping, a
small amount of lubricant may be transferred to the top of the walking belt or the shipping carton. This is a normal
condition and does not affect treadmill performance. If there is lubricant on top of the walking belt, simply wipe off

the lubricant with a soft cloth and a mild, non-abrasive cleaner.

©

Extension Leg Screw (53)-2 Handrail Screw (88)-2

,

With the help of a second person, carefully raise the

Uprights (11) until the treadmill is in the position shown.

,

Insert one of the Extension Legs (34) into the treadmill

as shown. Note: It may be helpful to tip the Uprights (11)

in the direction shown by the arrow, as you insert the
Extension Leg. Make sure that the Base Pad (40) is on

the indicated side of the Extension Leg. Attach the

Extension Leg with an Extension Leg Screw (53). Be

sure to push on the head of the Extension Leg

Screw while tightening it.

Latch Screw (35)-2

_--53

Next, attach the other Extension Leg (34) inthe same

way.

,

Insert one of the Handrails (1) into the tube at the upper
end of the right Upright (11). Make sure that the flat part

of the Handrail is on top.

4. Align the hole in the Handrail (1)with the hole in the
Upright (11). Using the Allen Wrench, tighten a Handrail
Screw (88) into the Upright and the Handrail.

Attach the other Handrail to the left Upright (not shown)
as described above.

,

Attach the Storage Latch (14) to the left Upright (11) with
two Latch Screws (35). Be careful not to overtighten

the Latch Screws.

Jl 1

1\

88

Bottom View

14

6. Make sure that all parts are tightened before you use the treadmill. Keep the included allen wrench in a
secure place. The allen wrench is used to adjust the walking belt (see page 13). To protect the floor or carpet,

place a mat under the treadmill.