Prince Castle 428-BX Parts List
Operation
Conveyor Toaster
Manual
LIMITED WARRANTY
Model No. 428-BX
TABLE OF CONTENTS PAGE
This product is warranted to be free from defects in material and/
or workmanship for a period of two (2) years from date of original
installation. On-location service for failure within 1 year of
installation, proof of purchase will be required.
Any component which proves to be faulty in material and/or
workmanship will be replaced or repaired (at the option of Prince
Castle, Inc.) without cost to the customer for parts or labor.
This warranty is subject to the following exceptions/conditions:
z Use of any non-genuine Prince Castle parts voids this
warranty.
z All labor shall be performed during regular work hours. Overtime
premium will be charged to the buyer.
z Damage caused by carelessness, neglect, and/or abuse
(e.g., dropping, tampering or altering parts), equipment
damaged in shipment, by fire, flood or an act of God is not
covered under this warranty.
z Motors that fail due to the lack of monthly lubrication will not
necessarily be covered under warranty.
z This toaster must be serviced by a Prince Castle Authorized
Service Center or a Prince Castle Service Technician. Failure
to do so can void this warranty.
Installation............................................................................................. 2
Electrical Specifications .................................................................... 2
Product Identification.......................................................................... 2
Operation ..............................................................................................3
Preventive Maintenance .................................................................... 4
Cleaning ................................................................................................. 4
Troubleshooting Chart ........................................................................ 5
Exploded View ..................................................................................... 6
Parts List ............................................................................................... 6
Wiring Diagram .....................................................................................7
355 East Kehoe Blvd. z Carol Stream, IL 60188
Tel: (630) 462-8800 z Fax: (630) 462-1460
Toll Free: 1-800-PCASTLE (1-800-722-7853)
428-BX 428-513 Printed in the USA 0101 2002
Conveyor Toaster
Model No. 428-BX
INTENDED USE
This toaster is designed to toast breads bagels or English
muffins. Do not attempt to toast croissants. Their butter
content will cause them to stick to the conveyor. Do not
attempt to toast products that have been buttered or spread
with jam or other coating Do not attempt to bake in the
toaster.
ELECTRICAL INFORMATION
Model Volts Watts Amps Hz Plug
428-BX 208 2600 12.5 50/60 6-2OP
INSTALLATION
1. After you have removed the toaster from the carton, inspect the unit for signs of damage. If there is damage to the
unit:
z Notify carrier within 24 hours after delivery.
z Save carton and packing materials for inspection purposes.
z Contact your local dealer or, if purchased directly, the Prince Castle Customer Sales Department at 1-630-462-8800 to
arrange for a replacement to be sent.
2. Verify that all parts have been received. Remove Protective Coating.
3. Adjust legs so toaster is level.
4. Remove packaging from bun slide and install bun slide in toaster by hooking it into the two pins in the rear of the
chamber.
5. The toaster fan located on the bottom of the toaster in the rear draws in cool room air and circulates it through the
toaster sides and tops. To insure adequate heat dissipation do not position the toaster where the fan would draw in
hot discharge from another appliance.
Power
Switch
Speed
Control
Switch
Upper Heater
Control Switch
Lower Heater
Control Switch
PRODUCT IDENTIFICATION
Extended
Conveyor
Assembly
Bun Ramp
428-BX 428-513 Printed in the USA 0101 2002
2
OPERATION
Plug unit into the proper voltage receptacle.
1
Set Power switch to “l” for On.
Conveyor Toaster
Model No. 428-BX
Allow 20 minutes for toaster to warm up.
3
Lay Bread, Bagel or Muffin, cut side up
on the extended conveyor and push into
toaster until it slides on to the conveyor
chain. To control toast color, vary the
conveyor speed or the heater settings.
Turn upper and lower heater controls to
2
maximum.
428-BX 428-513 Printed in the USA 0101 2002
3
Loading...