Prince Castle 102, 107-CE Operators Manual
INSPECT CARTONINSPECT CARTON
INSPECT CARTON
INSPECT CARTONINSPECT CARTON
Remove product from carton ...........
If damaged :
Operating Instructions
SHORTENING FILTERSHORTENING FILTER
SHORTENING FILTER
SHORTENING FILTERSHORTENING FILTER
MODEL NO'S 102 & 107 CE SeriesMODEL NO'S 102 & 107 CE Series
MODEL NO'S 102 & 107 CE Series
MODEL NO'S 102 & 107 CE SeriesMODEL NO'S 102 & 107 CE Series
Notify carrier
Save carton and packing material
Contact your Dealer, Distributor or Prince
Castle.
If you find a part, or parts missing, contact our
Europeon Distribution Center,Catequip SA, located in Bouilly France at (33)-25-40-29-10 or
Fax to (33)-25-40-26-69
PARTSPARTS
PARTS
PARTSPARTS
1. Always refer to the Parts List in this manual
you will then have a part number for reference
when ordering.
2. All replacement parts should be purchased
from your local PRINCE CASTLE Distributor.
SPECIFICATIONSSPECIFICATIONS
SPECIFICATIONS
SPECIFICATIONSSPECIFICATIONS
ELECTRICAL:ELECTRICAL:
ELECTRICAL:
ELECTRICAL:ELECTRICAL:
All Models 220-230v 1/3 HP 50-60Hz 3 AmpsAll Models 220-230v 1/3 HP 50-60Hz 3 Amps
All Models 220-230v 1/3 HP 50-60Hz 3 Amps
All Models 220-230v 1/3 HP 50-60Hz 3 AmpsAll Models 220-230v 1/3 HP 50-60Hz 3 Amps
Prince Castle Inc.Prince Castle Inc.
Prince Castle Inc.
Prince Castle Inc.Prince Castle Inc.
Printed 2001Printed 2001
Printed 2001
Printed 2001Printed 2001
102-516102-516
102-516
102-516102-516
LIMITED WARRANTYLIMITED WARRANTY
LIMITED WARRANTY
LIMITED WARRANTYLIMITED WARRANTY
This product is warrantied to be free from defects in
material and/or workmanship for a period of 1 year
from date of original installation, not to exceed 18
months from date of shipment from our factory.
Any component which proves faulty in material and/or
workmanship within the warranty period will be replaced or repaired without cost to the customer for
parts or labor (at the option of Prince Castle Inc).
This warranty is subject to the following exceptions/
conditions:
This equipment is portable, charges for on location
service (e.g., trip charges, mileage) are not included in
the provisions of the warranty. All labor should be
performed during regular working hours. Overtime
premium will not be covered.
Damage caused by carelessness, neglect, and/or
abuse and misuse (e.g., using wrong electrical current, dropping,tampering with or improper maintenance) is not covered.
3. Place Filter Paper over thread on top of screen.
IMPORTANT : Center paper properly so it laysIMPORTANT : Center paper properly so it lays
IMPORTANT : Center paper properly so it lays
IMPORTANT : Center paper properly so it laysIMPORTANT : Center paper properly so it lays
flat on screen and overlaps on each end. Ifflat on screen and overlaps on each end. If
flat on screen and overlaps on each end. If
flat on screen and overlaps on each end. Ifflat on screen and overlaps on each end. If
incorrect,torn or no filter paper are used, theincorrect,torn or no filter paper are used, the
incorrect,torn or no filter paper are used, the
incorrect,torn or no filter paper are used, theincorrect,torn or no filter paper are used, the
unit will not filter properly.unit will not filter properly.
unit will not filter properly.
unit will not filter properly.unit will not filter properly.
4. Spread approximately 16oz, by volume, of filter
powder ( Prince Castle No. 712 ) over filter paper
before installing ring weight
5. Place the ring weight on the filter paper.
Running water through the pump rusts internal parts
and will void this warranty.
Equipment damaged in shipment, by fire,flood or an
act of God is not covered.
Any use of non-genuine Prince Castle Replacement
Spare Parts voids this warranty. All genuine Prince
Castle Replacement Spare Parts are warrantied for
ninety (90) days from date of purchase. All Service
shall be performed by a Prince Castle Authorized and
Qualified Service Technician.
HOW TO SET - UPHOW TO SET - UP
HOW TO SET - UP
HOW TO SET - UPHOW TO SET - UP
1. Insert ( 4 ) casters into caster bracket weldments.
2. Place Screen assembly, with thread facing up
inside filter tank.
IMPORTANT: Make sure paper is not folded orIMPORTANT: Make sure paper is not folded or
IMPORTANT: Make sure paper is not folded or
IMPORTANT: Make sure paper is not folded orIMPORTANT: Make sure paper is not folded or
creased under the ring.creased under the ring.
creased under the ring.
creased under the ring.creased under the ring.
6. Hand tighten standpipe to screen.
22
2
22
7. Place safety guard on tank.
IMPORTANTIMPORTANT
IMPORTANT
IMPORTANTIMPORTANT
8. Grasp motor assembly by handle on motor and set
it on edge of tank so that the pump lines up with the
standpipe. Hand tighten the union nut to the standpipe
making sure the connection is tight.
HOW TO USEHOW TO USE
HOW TO USE
HOW TO USEHOW TO USE
REQUIRED PROTECTIVE EQUIPMENT :REQUIRED PROTECTIVE EQUIPMENT :
REQUIRED PROTECTIVE EQUIPMENT :
REQUIRED PROTECTIVE EQUIPMENT :REQUIRED PROTECTIVE EQUIPMENT :
Face ShieldFace Shield
Face Shield
Face ShieldFace Shield
HANDLE AND HOSE ARE HOTHANDLE AND HOSE ARE HOT
HANDLE AND HOSE ARE HOT
HANDLE AND HOSE ARE HOTHANDLE AND HOSE ARE HOT
BEFORE PERFORMING SERVICEBEFORE PERFORMING SERVICE
BEFORE PERFORMING SERVICE
BEFORE PERFORMING SERVICEBEFORE PERFORMING SERVICE
MAXIMUM NORMAL OPERATINGMAXIMUM NORMAL OPERATING
MAXIMUM NORMAL OPERATING
MAXIMUM NORMAL OPERATINGMAXIMUM NORMAL OPERATING
PRESSURE 50PSI (35, 155 KGS/SQ METERPRESSURE 50PSI (35, 155 KGS/SQ METER
PRESSURE 50PSI (35, 155 KGS/SQ METER
PRESSURE 50PSI (35, 155 KGS/SQ METERPRESSURE 50PSI (35, 155 KGS/SQ METER
1. Remove cooking computer probes from fryer, if
present.
2. Turn on fryer and set thermostat to cooking temperature.
ARE READY TO FILTER,THIS WILL ALLOWARE READY TO FILTER,THIS WILL ALLOW
ARE READY TO FILTER,THIS WILL ALLOW
ARE READY TO FILTER,THIS WILL ALLOWARE READY TO FILTER,THIS WILL ALLOW
SHORTENING TO REMAIN HOT FOR FILTERING.SHORTENING TO REMAIN HOT FOR FILTERING.
SHORTENING TO REMAIN HOT FOR FILTERING.
SHORTENING TO REMAIN HOT FOR FILTERING.SHORTENING TO REMAIN HOT FOR FILTERING.
DO NOT TURN OFF FRYER UNTIL YOUDO NOT TURN OFF FRYER UNTIL YOU
DO NOT TURN OFF FRYER UNTIL YOU
DO NOT TURN OFF FRYER UNTIL YOUDO NOT TURN OFF FRYER UNTIL YOU
Rubber GlovesRubber Gloves
Rubber Gloves
Rubber GlovesRubber Gloves
CAUTIONCAUTION
CAUTION
CAUTIONCAUTION
IMPORTANTIMPORTANT
IMPORTANT
IMPORTANTIMPORTANT
DISCONNECT POWER PLUGDISCONNECT POWER PLUG
DISCONNECT POWER PLUG
DISCONNECT POWER PLUGDISCONNECT POWER PLUG
ON MOTOR OR PUMPON MOTOR OR PUMP
ON MOTOR OR PUMP
ON MOTOR OR PUMPON MOTOR OR PUMP
NOTENOTE
NOTE
NOTENOTE
ApronApron
Apron
ApronApron
9.Attach anti-splash tube on the filter tank by hooking
the tube over the rim of the tank so the diffuser end of
the tube is closest to the safety guard.
(See drawing above)
10. Hand tighten hose to pump union nut, making
sure the connection is tight.
IMPORTANT: This hose is flexible. However,IMPORTANT: This hose is flexible. However,
IMPORTANT: This hose is flexible. However,
IMPORTANT: This hose is flexible. However,IMPORTANT: This hose is flexible. However,
excessive bending can crease or crack theexcessive bending can crease or crack the
excessive bending can crease or crack the
excessive bending can crease or crack theexcessive bending can crease or crack the
hose causing hot oil to leak. Do not use ahose causing hot oil to leak. Do not use a
hose causing hot oil to leak. Do not use a
hose causing hot oil to leak. Do not use ahose causing hot oil to leak. Do not use a
creased or cracked hose.creased or cracked hose.
creased or cracked hose.
creased or cracked hose.creased or cracked hose.
3. Slowly agitate shortening in all fryers with wood
paddle provided. This will blend hot and cold shortening, boil off excess moisture, and bring any debris to
the surface.
CAUTION,EXCESSIVE MOISTURE COULDCAUTION,EXCESSIVE MOISTURE COULD
CAUTION,EXCESSIVE MOISTURE COULD
CAUTION,EXCESSIVE MOISTURE COULDCAUTION,EXCESSIVE MOISTURE COULD
CAUSE FRYER TO BOIL OVER. CONTINUECAUSE FRYER TO BOIL OVER. CONTINUE
CAUSE FRYER TO BOIL OVER. CONTINUE
CAUSE FRYER TO BOIL OVER. CONTINUECAUSE FRYER TO BOIL OVER. CONTINUE
AGITATION UNTIL ALL BOILING CEASES.AGITATION UNTIL ALL BOILING CEASES.
AGITATION UNTIL ALL BOILING CEASES.
AGITATION UNTIL ALL BOILING CEASES.AGITATION UNTIL ALL BOILING CEASES.
4. Skim off any debris from shortening surface (use
a Prince Castle Fry Vat Skimmer).
IMPORTANT: Failure to skim the fryer thor-IMPORTANT: Failure to skim the fryer thor-
IMPORTANT: Failure to skim the fryer thor-
IMPORTANT: Failure to skim the fryer thor-IMPORTANT: Failure to skim the fryer thoroughly could cause excess food particles tooughly could cause excess food particles to
oughly could cause excess food particles to
oughly could cause excess food particles tooughly could cause excess food particles to
clog the drain valve or the filter machineclog the drain valve or the filter machine
clog the drain valve or the filter machine
clog the drain valve or the filter machineclog the drain valve or the filter machine
pump.pump.
pump.
pump.pump.
33
3
33
Loading...