Pride Mobility SC151, SC155 User Manual
Owner’s Manual
ATTENTION:
Please read the content
of your owners manual
before operating your
scooter.
®
The Ultimate In Style & Performance
Exeter, PA
St. Catharines, ON 1-800-800-8586
www.pridemobility.com
SAFETY GUIDELINES
Please read and follow all instructions in this owners manual before attempting to operate your scooter for the first
time. If there is anything in this manual you do not understand, or if you require additional assistance for setup,
contact your local authorized Pride provider.
Using your Pride product safely depends upon your diligence in following the warnings, cautions, and instructions
in this owners manual. Using your Pride product safely also depends upon your own good judgement and/or
common sense, as well as that of your provider, caregiver, and/or healthcare professional. Pride is not responsible
for injuries and/or damage resulting from any persons failure to follow the warnings, cautions, and instructions in
this owners manual. Pride is not responsible for injuries and/or damage resulting from any persons failure to
exercise good judgement and/or common sense.
The symbols below are used throughout this owners manual to identify warnings and cautions. It is very important
for you to read and understand them completely.
WARNING! Failure to heed the warnings in this owners manual may result in personal injury.
CAUTION! Failure to heed the cautions in this owners manual may result in damage to your
scooter.
Copyright © 2003
Pride Mobility Products Corp.
INFMANU1762
2 www.pridemobility.com Rally/RevF/September 03
CONTENTS
I. INTRODUCTION......................................................................................................................... 4
II. SAFETY ......................................................................................................................................... 6
III. EMI/RFI ........................................................................................................................................ 15
IV. SPECIFICATIONS ................................................................................................................... 17
V. YOUR RALLY ............................................................................................................................ 19
VI. BATTERIES AND CHARGING ........................................................................................... 24
VII. OPERATION ............................................................................................................................... 28
VIII.COMFORT ADJUSTMENTS ................................................................................................ 30
IX. DISASSEMBLY AND ASSEMBLY ..................................................................................... 32
X. OPTIONAL ACCESSORIES................................................................................................. 34
XI. TROUBLESHOOTING............................................................................................................ 35
XII. CARE AND MAINTENANCE ............................................................................................... 36
XIII. WARRANTY ................................................................................................................................38
3Rally/RevF/September 03 www.pridemobility.com
I. INTRODUCTION
SAFETY
WELCOME to Pride Mobility Products Corporation (Pride). The scooter you have purchased combines stateof-the-art components with safety, comfort, and styling in mind. We are confident that these design features will
provide you with the conveniences you expect during your daily activities. Once you understand how to safely
operate and care for your scooter, it should give you years of trouble free operation and service.
Read and follow all instructions, warnings, and notes in this manual before attempting to operate your scooter for
the first time. In addition, your safety depends upon you, as well as your Provider, caretaker, or healthcare
professional in using good judgement.
If there is any information in this manual in which you do not understand, or if you require additional assistance for
setup or operation, please contact your authorized Pride Provider. Failure to follow the instructions in this
manual and those located on your scooter can lead to personal injury and/or damage to the scooter,
including voiding the warranty.
EXPRESSED AGREEMENT OF INDEMNIFICATION
In accepting delivery of this product, the Purchaser specifically promises that s/he will not change, alter, or modify
this product or remove or render inoperable or unsafe any guards, shields, or other safety features of the product;
or remove, obliterate, or obstruct any safety and instruction signs, or fail, refuse, or neglect to install any retrofit kits
from time to time provided by Pride to enhance user safety. Purchaser also specifically agrees that if s/he breaches
any such promises, or if s/he is remiss, neglect, or deficient in the safe operation or maintenance of this product, the
purchaser will indemnify and hold harmless Pride from any and all types of actions, suits, claims, or demands,
including products liability claims by purchaser, for injuries or loss arising out of the operation, maintenance, repair,
or other use of this product. Purchaser specifically agrees that this Express Agreement of Indemnification is a
condition of sale supported by adequate consideration and was read and understood by the purchaser before
purchasing and delivery of the product.
INFORMATION EXCHANGE
We want to hear your questions, comments, and suggestions about this manual. We would also like to hear about
the safety and reliability of your new scooter, and about the service you received from your authorized Pride
Provider.
Please notify us of any change of address, so we can keep you apprised of important information about safety, new
products, and new options that can increase your ability to use and enjoy your scooter. Please feel free to contact
us at the address below:
Pride Mobility Products Corporation
Attn: Customer Care Department
182 Susquehanna Avenue
Exeter, PA 18643-2694
customercare@pridemobility.com
1-800-424-8205
4 www.pridemobility.com Rally/RevF/September 03
I. INTRODUCTION
PRIDE OWNERS CLUB
As an owner of a Pride product, you are invited to register your product's warranty and enroll in the Pride Owners
Club. You may do so by filling out and returning your enclosed product registration card or by visiting Pride's web
site at www.pridemobility.com. As a registered member, each time you visit our site, you will have access to the
most interactive and honest educational venue available today for people with mobility needs, their families, and
friends.
From our home page, select "Owners Club" to enter a page dedicated to current and potential Pride product
owners. You will gain access to interviews, stories, recreation ideas, daily living tips, product and funding information, and interactive message boards. These message boards invite you to communicate with other Pride customers as well as Pride representatives who are available to assist you with any questions or concerns you may have.
My authorized Pride Provider:
Name:_______________________________________________________________________________
Address:______________________________________________________________________________
Phone Number:_________________________________________________________________________
Purchase Date:_________________________________________________________________________
NOTE: If you ever lose or misplace your product registration card or this owners manual, contact us and
we will be glad to send you a new one immediately.
5Rally/RevF/September 03 www.pridemobility.com
II. SAFETY
GENERAL
WARNING! Do not operate your new scooter for the first time without completely reading
and understanding this owners manual.
Your scooter is a state-of-the-art life-enhancement device designed to increase mobility. Pride provides an extensive variety of products to best fit the individual needs of the scooter user. Please be aware that the final selection
and purchasing decision regarding the type of scooter to be used is the responsibility of the scooter user who is
capable of making such a decision and his/her healthcare professional (i.e., medical doctor, physical therapist,
etc.).
The contents of this manual are based on the expectation that a mobility device expert has properly fitted the
scooter to the user and has assisted the prescribing healthcare professional and/or the authorized Provider in the
instruction process for the use of the product.
There are certain situations, including some medical conditions, where the scooter user will need to practice
operating the scooter in the presence of a trained attendant. A trained attendant can be defined as a family member
or care professional specially trained in assisting a scooter user in various daily living activities.
As you begin using your scooter during daily activities, you will probably encounter situations in which you will
need some practice. Simply take your time and you will soon be in full and confident control as you maneuver
through doorways, on and off elevators, up and down ramps, and over moderate terrain.
MODIFICATIONS
Your scooter has been designed and engineered to provide maximum mobility and utility. A wide range of accessories is available from your authorized Pride Provider to further customize your scooter to better suit your needs
and/or preferences. However, under no circumstances should you modify, add, remove, or disable any feature,
part, or function of your scooter.
WARNING! Do not modify your scooter in any way not authorized by Pride. Unauthorized
modifications may result in personal injury and/or damage to your scooter.
REMOVABLE PARTS
WARNING! Do not attempt to lift or move your scooter by any of its removable parts.
Personal injury and damage to the scooter may
ELECTROMAGNETIC FIELDS
Your scooters road performance features may be influenced by electromagnetic fields caused by cellular telephones or other radiating devices, such as hand-held radios, radio and television stations, wireless computer links,
microwave sources, and paging transmitters. Learn more about this topic in III. EMI/RFI.
6 www.pridemobility.com Rally/RevF/September 03
II. SAFETY
PRE-RIDE SAFETY CHECK
Get to know the feel of your scooter and its capabilities. It is recommended that you perform a safety check before
each use to make sure your scooter operates smoothly and safely. For details on how to perform these necessary
inspections, see XII. Care and Maintenance.
Perform the following inspections prior to using your scooter:
n Check for proper tyre inflation. Maintain 30-35 psi in each tyre (if equipped with pneumatic tyres).
n Check all electrical connections. Make sure they are tight and not corroded.
n Check all harness connections. Make sure they are secured properly.
n Check the brakes.
n Check battery charge.
TIRE INFLATION
If your scooter is equipped with pneumatic tires, you should check or have the air pressure checked at least once
a week. Proper inflation pressures will prolong the life of your tires and help ensure the smooth operation of your
scooter.
WARNING! It is critically important that 30-35 psi tire pressure be maintained in pneumatic
tires at all times. Do not underinflate or overinflate your tires. Low pressure may result in
loss of control, and overinflated tires may burst. Failure to maintain 30-35 psi tire pressure
in pneumatic tires at all times may result in tire and/or wheel failure, causing serious
personal injury and/or damage to your scooter.
WARNING! Inflate your scooter tires from a regulated air source with an available pressure
gauge. Inflating your tires from an unregulated air source could overinflate them, resulting
in a burst tire and/or personal injury.
WEIGHT LIMIT ATIONS
Your scooter is rated for a maximum weight capacity. Refer to the specifications table for information.
WARNING! Exceeding the weight limit voids your warranty and may result in personal
injury and damage to your scooter. Pride will not be held responsible for injuries and/or
property damage resulting from failure to observe weight limitations.
WARNING! Do not carry passengers on your scooter. Carrying passengers on your scooter
may result in personal injury and/or property damage.
INCLINE INFORMATION
More and more buildings have ramps with specified percents of inclination, designed for easy and safe access.
Some ramps may have turning switchbacks (180-degree turns) that require you to have good cornering skills on
your scooter.
n Proceed with extreme caution as you approach the downgrade of a ramp or other incline.
n Take wide swings with your scooters front wheel(s) around any tight corners. If you do that, the scooters rear
wheels will follow a wide arc, not cut the corner short, and not bump into or get hung up on any railing corners.
n When driving down a ramp, keep the scooters speed adjustment set to the slowest speed setting to ensure a
safely controlled descent. See V. Your Rally.
n Avoid sudden stops and starts.
7Rally/RevF/September 03 www.pridemobility.com
II. SAFETY
When climbing an incline, try to keep your scooter moving. If you must stop, start up again slowly, and then
accelerate cautiously. When driving down an incline, do so by setting the speed adjustment to the slowest setting
and driving in the forward direction only. If your scooter starts to move down the incline faster than you anticipated
or desired, allow it to come to a complete stop by releasing the throttle control lever. Then push the throttle control
lever forward slightly to ensure a safely controlled descent.
WARNING! When climbing an incline, do not zigzag or drive at an angle up the face of the
incline. Drive your scooter straight up the incline. This greatly reduces the possibility of a
tip or a fall. Always exercise extreme caution when negotiating an incline.
WARNING! Do not drive your scooter across the side of a hill or diagonally up or down a
hill; do not stop, if possible, while driving up or down an incline.
WARNING! You should not travel up or down a potentially hazardous incline (i.e., areas
covered with snow, ice, cut grass, or wet leaves).
WARNING! When on any sort of an incline or decline, never place the scooter in freewheel
mode while seated on it or standing next to it.
WARNING! Even though your scooter is capable of climbing slopes greater than those
illustrated in figures 1 and 1A, do not, under any circumstances, exceed the incline
guidelines or any other specifications presented in this manual. Doing so could cause
instability in your scooter, resulting in personal injury and/or damage to your scooter.
Handicap public access ramps are not subject to government regulation in all countries, and therefore do not
necessarily share the same standard percent of slope. Other inclines may be natural or, if man-made, not designed
specifically for scooters. Figures 1 and 1A illustrate your scooters stability and its ability to climb grades under
various weight loads and under controlled testing conditions.
These tests were conducted with the scooters seat in the highest position and adjusted backward on the seat base
to its farthest backward position. Use this information as a guideline. Your scooters ability to travel up inclines is
affected by your weight, your scooters speed, your angle of approach to the incline, and your scooter setup.
150 lbs.
5°
Figure 1. Maximum Recommended
3-Wheel Incline Angles
WARNING! Any attempt to climb or descend a slope steeper than what is shown in figures
1 and 1A may put your scooter in an unstable position and cause it to tip, resulting in
personal injury.
WARNING! Never carry an oxygen tank weighing more than 15 lbs. Never fill the rear
basket with contents exceeding 15 lbs.
200 lbs.
4°
300 lbs.
2°
150 lbs.
5°
Figure 1A. Maximum Recommended
4-Wheel Incline Angles
200 lbs.
5°
300 lbs.
3°
8 www.pridemobility.com Rally/RevF/September 03
II. SAFETY
When you approach an incline, it is best to lean forward. See figures 2 and 2A. This shifts the center of gravity of
you and your scooter toward the front of the scooter for improved stability.
Figure 2. Normal Driving Position
Figure 2A. Increased Stability Driving Position
CORNERING INFORMATION
Excessively high cornering speeds can create the possibility of tipping. Factors which affect the possibility of
tipping include, but are not limited to, cornering speed, steering angle (how sharply you are turning), uneven road
surfaces, inclined road surfaces, riding from an area of low traction to an area of high traction (such as passing
from a grassy area to a paved area especially at high speed while turning), and abrupt directional changes. High
cornering speeds are not recommended. If you feel that you may tip over in a corner, reduce your speed and
steering angle (i.e., lessen the sharpness of the turn) to prevent your scooter from tipping.
WARNING! When cornering sharply, reduce your speed. When using your scooter at
higher speeds, do not corner sharply. This greatly reduces the possibility of a tip or fall.
To avoid personal injury or property damage, always exercise common sense when
cornering.
9Rally/RevF/September 03 www.pridemobility.com
II. SAFETY
OUTDOOR DRIVING SURFACES
Your scooter is designed to provide optimum stability under normal driving conditionsdry, level surfaces composed of concrete, blacktop, or asphalt. However, Pride recognizes that there will be times when you will encounter other surface types. For this reason, your scooter is designed to perform admirably on packed soil, grass, and
gravel. Feel free to use your scooter safely on lawns and in park areas.
n Reduce your scooters speed when driving on uneven terrain and/or soft surfaces.
n Avoid tall grass that can become tangled in the running gear.
n Avoid loosely packed gravel and sand.
n If you feel unsure about a driving surface, avoid that surface.
STATIONARY OBSTACLES (STEPS, CURBS, ETC.)
WARNING! Do not drive near raised surfaces, unprotected ledges, and/or drop-offs (curbs,
porches, stairs, etc.).
WARNING! Do not attempt to have your scooter climb or descend an obstacle that is
inordinately high. Serious personal injury and/or damage may result.
WARNING! Do not attempt to have your scooter proceed backward down any step, curb, or
other obstacle. This may cause the scooter to tip and cause personal injury.
WARNING! Be sure your scooter is traveling perpendicular to any curb you may be required
to ascend or descend. See figures 3 and 3A.
WARNING! Do not attempt to negotiate a curb that has a height greater than 2 in.
Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb approach
BRAKING INFORMATION
Your scooter is equipped with two powerful brake systems:
1. Regenerative: Uses electricity to rapidly slow the vehicle when the throttle control lever returns to the center/
stop position; and
2. Disc Park Brake: Activates mechanically after regenerative braking slows the vehicle to near stop, or when
power is removed from the system for any reason.
10 www.pridemobility.com Rally/RevF/September 03
II. SAFETY
PUBLIC STREETS AND ROADWAYS
WARNING! You should not operate your scooter on public streets and roadways. Be aware
that it may be difficult for traffic to see you when you are seated on your scooter. Obey all
local pedestrian traffic rules. Wait until your path is clear of traffic, and then proceed with
extreme caution.
NOTE: Safety accessories like fluorescent flags are available to order from your authorized Pride Provider.
INCLEMENT WEATHER PRECAUTIONS
WARNING! Pride recommends that you do not operate your scooter in icy or slippery
conditions or on salted surfaces (i.e., walks or roads). Such use may result in an accident,
personal injury, or adversely affect the performance and safety of your scooter.
WARNING! Do not operate or store your scooter where it may be exposed to inclement
weather conditions such as rain, snow, mist, and below freezing temperatures (such as
storage on an outside car/van lift). Attempting to operate the scooter in such conditions
can damage the electronics and potentially result in loss of control.
FREEWHEEL MODE
Your scooter is equipped with a manual freewheel lever that when pulled up allows the scooter to be pushed. For
more information about how to place your scooter into and out of freewheel mode, see V. Your Rally.
WARNING! When your scooter is in freewheel mode, the braking system is disengaged.
n Disengage the drive motors only on a level surface.
n Ensure the key is removed from the key switch.
n Stand behind the scooter to engage or disengage freewheel mode. Never sit on a
scooter to do this.
n After you have finished pushing your scooter, always return it to the drive mode to lock
the brakes.
Failure to heed the above could result in personal injur y and/or damage to your scooter.
An added feature built into the scooter is push-too-fast protection which safeguards the scooter against gaining
excessive speed while in freewheel mode.
Push-too-fast operates differently depending on which of two conditions exists:
n If the key is removed from the key switch while in freewheel mode, the scooters controller activates regenera-
tive braking when the scooter is pushed faster than a maximum threshold which has been preprogrammed. In
this case, the controller is acting as a speed governor.
n If the key is fully inserted into the key switch while in freewheel mode, you will encounter considerable
resistance at any speed.This prevents the scooter from gaining unwanted momentum should the manual freewheel lever inadvertently be released while driving the scooter.
11Rally/RevF/September 03 www.pridemobility.com
II. SAFETY
STAIRS AND ESCALATORS
Scooters are not designed to travel up or down stairs or escalators. Always use an elevator.
WARNING! Do not use your scooter to negotiate steps or escalators. You may cause injury
to yourself and to others and/or damage your scooter.
DOORS
n Determine if the door opens toward or away from you.
n Use your hand to turn the knob or push the handle or push-bar.
n Drive your scooter gently and slowly forward to push the door open. Or drive your scooter gently and slowly
backward to pull the door open.
ELEVATORS
Modern elevators have a door edge safety mechanism that, when pushed, reopens the elevator door(s).
n If you are in the doorway of an elevator when the door(s) begin to close, push on the rubber door edge or
allow the rubber door edge to contact the scooter and the door will reopen.
n Use care that pocketbooks, packages, or scooter accessories do not become caught in elevator doors.
LIFT/ELEVATION PRODUCTS
If you will be traveling with your scooter, you may find it necessary to use a lift/elevation product to aid in transportation. It is recommended that you closely review the instructions, specifications, and safety information set forth by
the manufacturer of the lift/elevation product before using that product.
WARNING! Never sit on your scooter when it is being used in connection with any type of
lift/elevation product. Your scooter was not designed with such use in mind, and any
damage or injury incurred from such use is not the responsibility of Pride.
BATTERIES
In addition to following the warnings below, be sure to comply with all other battery handling information. For
more information about your scooters batteries, see VI. Batteries and Charging.
WARNING! Scooter batteries are heavy (refer to specifications table). Lifting weight
beyond your capacity could result in personal injury. If necessary, get someone physically
able to lift the scooter batteries for you.
WARNING! Battery posts, terminals, and related accessories contain lead and lead
compounds. Wash hands after handling.
WARNING! Always protect the batteries from freezing and never charge a frozen battery.
Charging a frozen battery may result in personal injury and/or damage to the battery.
WARNING! RED (+) cables must be connected to positive (+) battery terminals/posts. BLACK
(-) cables must be connected to negative (-) battery terminals/posts. Failure to connect
your battery harnesses in the proper manner may result in personal injury and/or damage
to your scooter. REPLACE cables immediately if damaged.
12 www.pridemobility.com Rally/RevF/September 03
Loading...