Pride Mobility CELEBRITY DELUXE Owner's Manual

CELEBRITY DELUXE

SAFETY GUIDELINES

WARNING! An authorised Pride Dealer or qualified technician must perform the initial
setup of this scooter and must perform all of the procedures in this manual.

The symbols below are used throughout this owner's manual and on the scooter to identify warnings and
important information. It is very important for you to read them and understand them completely.

WARNING! Indicates a potentially hazardous condition/situation. Failure to follow
designated procedures can cause either personal injury, component damage or
malfunction. On the product, this icon is represented as a black symbol on a yellow
triangle with a black border.

MANDATORY! These actions should be performed as specified. Failure to perform
mandatory actions can cause personal injury and/or equipment damage. On the product,
this icon is represented as a white symbol on a blue dot.

PROHIBITED! These actions are prohibited. These actions should not be performed at
any time or in any circumstances. Performing a prohibited action can cause personal
injury and/or equipment damage. On the product, this icon is represented as a black
symbol with a red circle and a red slash.

Please fill out the following information for quick reference:

Pride Dealer:

Address:

Phone Number:

Purchase Date: Serial Number:

NOTE: This owner’s manual is compiled from the latest specifications and product information avail­able at the time of publication. We reserve the right to make changes as they become necessary. Any
changes to our products may cause slight variations between the illustrations and explanations in this
manual and the product you have purchased. The latest/current version of this manual is available on
our website.

Copyright © 2008
Pride Mobility Products Ltd.

INFMANU3054/Rev. D/September 2008

CONTENTS

I. INTRODUCTION ........................................................................................................................4

II. SAFETY ........................................................................................................................................5

III. YOUR SCOOTER ......................................................................................................................18

IV. BATTERIES AND CHARGING ..........................................................................................23

V. OPERATION .............................................................................................................................28

VI. COMFORT ADJUSTMENTS ..............................................................................................30

VII. DISASSEMBLY AND ASSEMBLY ...................................................................................34

VIII. BASIC TROUBLESHOOTING ..........................................................................................36

IX. CARE AND MAINTENANCE ..............................................................................................38

X. WARRANTY ..............................................................................................................................41

APPENDIX I - SPECIFICATIONS ...............................................................................................42

Celebrity Deluxe www.pridemobility.com

3

I. INTRODUCTION

SAFETY

Welcome to Pride Mobility Products Ltd. (Pride). The product you have purchased combines state-of­the-art components with safety, comfort and styling in mind. We are confident the design features will
provide you with the conveniences you expect during your daily activities. Understanding how to safely
operate and care for this product should bring you years of trouble free operations and service.

Read and follow all instructions, warnings and notes in this manual and all other accompanying literature
before attempting to operate this product for the first time. In addition, your safety depends upon you, as
well as your dealer, carer or healthcare professional in using good judgement.

If there is any information in this manual which you do not understand or if you require additional assis­tance for setup or operation, please contact your authorised Pride Dealer. Failure to follow the instruc-

tions, warnings and notes in this manual and those located on your Pride product can result in
personal injury or product damage and will void Pride’s product warranty.

PURCHASER’S AGREEMENT

By accepting delivery of this product, you promise that you will not change, alter or modify this product
or remove or render inoperable or unsafe any guards, shields or other safety features of this product; fail,
refuse or neglect to install any retrofit kits from time to time provided by Pride to enhance or preserve the
safe use of this product.

SHIPPING AND DELIVERY

Before using your Travel Scooter, make sure your delivery is complete as some components may be indi­vidually packaged. If you do not receive a complete delivery, please contact your authorised Pride Dealer
immediately. Where damage has occurred during transport, either to the packaging or content, please
contact the delivery company responsible.

INFORMATION EXCHANGE

We want to hear your questions, comments and suggestions about this manual. We would also like to hear
about the safety and reliability of your new scooter and about the service you received from your autho­rised Pride Dealer. Please notify us of any change of address, so we can keep you apprised of important
information about safety, new products and new options that can increase your ability to use and enjoy
your scooter. Please feel free to contact us at the address below:

Pride Mobility Products Ltd.

32 Wedgwood Road

Bicester, Oxon OX26 4UL

NOTE: If you ever lose or misplace your product registration card or your copy of this manual, contact
us and we will be glad to send you a new one immediately.

4

www.pridemobility.com Celebrity Deluxe

II. SAFETY

PRODUCT SAFETY SYMBOLS

The symbols below are used on the scooter to identify warnings, mandatory actions and prohibited actions.
It is very important for you to read and understand them completely.

Read and follow the information in the owner’s manual.

Pinch/Crush points created during assembly.

Corrosive chemicals contained in battery.

EMI-RFI- This product has been tested and passed at an immunity level of 20 V/m.

Do not lift the mobility product while seated in it.

Do not place your scooter in freewheel mode while on a decline.

Do not place your scooter in freewheel mode while on an incline.

Explosive conditions exist!

Celebrity Deluxe www.pridemobility.com

5

II. SAFETY

Maximum weight capacity.

Unlocked and in freewheel mode.

Place unit on level ground and stand to one side when changing from drive mode
to freewheel mode or freewheel mode to drive mode.

Locked and in drive mode.

Front-to-rear plug orientation.

Wear safety goggles.

Do not mistake the tiller adjustment lever for a brake.

Use only AGM or Gel-Cell batteries to reduce the risk of leakage or explosive
condition.

6

www.pridemobility.com Celebrity Deluxe

II. SAFETY

Do not raise or lower the power seat while the scooter is in motion.

Keep your hands away from the tyres when driving. Be aware that loose fitting
clothing can become caught in the drive tyres.

Do not remove anti-tip wheels.

Do not use a cell phone, walkie/talkie, laptop or other radio transmitter while
operating.

Avoid exposure to rain, snow, ice, salt or standing water whenever possible.
Maintain and store in a clean and dry condition.

Removal of grounding prong can create electrical hazard. If necessary, properly
install an approved 3-pronged adapter to an electrical outlet having 2-pronged
plug access.

Do not connect an extension lead to the AC/DC converter or the battery charger.

Keep tools and other metal objects away from battery terminals. Contact with
tools can cause electrical shock.

Celebrity Deluxe www.pridemobility.com

7

II. SAFETY

Do not allow unsupervised children to play near the scooter while the batteries
are charging.

Do not use batteries with different amp-hour (Ah) capacities. Do not mix old and
new batteries. Always replace both batteries at the same time.

Battery charger for indoor use only.

Disposal and recycling-contact your authorised Pride Dealer for information on pro­per disposal of your Pride product and its packaging.

Contains Lead.

8

www.pridemobility.com Celebrity Deluxe

II. SAFETY

GENERAL

MANDATORY! Do not operate your new scooter for the first time without completely
reading and understanding this owner’s manual.

Your scooter is a state-of-the-art life-enhancement device designed to increase mobility. Pride provides an
extensive variety of products to best fit the individual needs of the scooter user. Please be aware that the
final selection and purchasing decision regarding the type of scooter to be used is the responsibility of the
scooter user who is capable of making such a decision and his/her healthcare professional (i.e., medical
doctor, physical therapist, etc.).

The contents of this manual are based on the expectation that a mobility device expert has properly fitted
the scooter to the user and has assisted the prescribing healthcare professional and/or the authorised Pride
Dealer in the instruction process for the use of the product.

There are certain situations, including some medical conditions, where the scooter user will need to prac­tice operating the scooter in the presence of a trained attendant. A trained attendant can be defined as a
family member or care professional specially trained in assisting a scooter user in various daily living
activities.

As you begin using your scooter during daily activities, you will probably encounter situations in which
you will need some practice. Simply take your time and you will soon be in full and confident control as
you manoeuvre through doorways, on and off lifts, up and down ramps and over moderate terrain.

Below are some precautions, tips and other safety considerations that will help you become accustomed
to operating the scooter safely.

MODIFICATIONS

Pride has designed and engineered your scooter to provide maximum mobility and utility. However, under
no circumstances should you modify, add, remove or disable any feature, part or function of your scooter.

WARNING! Do not modify your scooter in any way not authorised by Pride. Do not use
accessories if they have not been tested and approved for Pride Products.

REMOVABLE PARTS

WARNING! Do not attempt to lift or move your scooter by any of its removable parts;
including the armrests, seat or shrouds.

PRE-RIDE SAFETY CHECK

Get to know the feel of your scooter and its capabilities. Pride recommends that you perform a safety check
before each use to make sure your scooter operates smoothly and safely.

Celebrity Deluxe www.pridemobility.com

9

II. SAFETY

Perform the following inspections prior to using your scooter:
 Check for proper tyre inflation. Maintain but do not exceed the psi/bar/kPa air pressure rating indicated

on each tyre if equipped with pneumatic tyres.

 Check all electrical connections. Make sure they are tight and not corroded.
 Check all harness connections. Make sure they are secured properly.
 Check the brakes.
 Check battery charge.

If you discover a problem, contact your authorised Pride Dealer for assistance.

TYRE INFLATION

If your scooter is equipped with pneumatic tyres, you should check or have the air pressure checked at least
once a week. Proper inflation pressures will prolong the life of your tyres and help ensure the smooth
operation of your scooter.

WARNING! It is critically important that the psi/bar/kPa air pressure rating indicated on
each tyre be maintained in pneumatic tyres at all times. Do not underinflate or overinflate
your tyres. Low pressure may result in loss of control and overinflated tyres may burst.
Failure to maintain the psi/bar/kPa air pressure rating indicated on pneumatic tyres at all
times may result in tyre and/or wheel failure.

WARNING! Inflate your scooter tyres from a regulated air source with an available
pressure gauge. Inflating your tyres from an unregulated air source could overinflate
them, resulting in a burst tyre.

NOTE: If the tyres on your scooter list the psi rating only, use the following conversion formulas to find
the bar or kPa rating: bar = psi x 0.06895, kPa = psi x 6.89476

WEIGHT LIMITATIONS

Your scooter is rated for a maximum weight capacity. Refer to the specifications table for information.

WARNING! Stay within the specified weight capacity for your scooter. Exceeding the
weight capacity voids your warranty. Pride will not be held responsible for injuries and/
or property damage resulting from failure to observe weight limitations.

WARNING! Do not carry passengers on your scooter. Carrying passengers on your
scooter may affect the centre of gravity, resulting in a tip or fall.

INCLINE INFORMATION

More and more buildings have ramps with specified degrees of inclination, designed for easy and safe
access. Some ramps may have turning switchbacks (180-degree turns) that require you to have good cor­nering skills on your scooter.

 Proceed with extreme caution as you approach the downgrade of a ramp or other incline.
 Take wide swings with your scooter around any tight corners. If you do that, the scooter’s rear wheels

will follow a wide arc, not cut the corner short and not bump into or get hung up on any railing corners.

 When driving down a ramp, keep the scooter’s speed adjustment set to the slowest speed setting to

ensure a safely controlled descent.

 Avoid sudden stops and starts.

10

www.pridemobility.com Celebrity Deluxe

II. SAFETY

When climbing an incline, try to keep your scooter moving. If you must stop, start up again slowly and
then accelerate cautiously. When driving down an incline, do so by setting the speed adjustment dial to the
slowest setting and driving in the forward direction only. If your scooter starts to move down the incline
faster than you anticipated or desired, allow it to come to a complete stop by releasing the throttle control
lever. Then push the throttle control lever forward slightly to ensure a safely controlled descent.

WARNING! When on any sort of an incline or decline, never place the scooter in
freewheel mode, especially while seated on it or standing next to it.

WARNING! When climbing an incline, do not zigzag or drive at an angle up the
face of the incline. Drive your scooter straight up the incline. This greatly
reduces the possibility of a tip or a fall. Always exercise extreme caution when
negotiating an incline.

WARNING! Do not drive your scooter across the side of an incline or diagonally
up or down an incline; do not stop, if possible, while driving up or down an incline.

WARNING! You should not travel up or down a potentially hazardous incline (i.e.,
areas covered with snow, ice, cut grass, or wet leaves).

WARNING! Even though your scooter is capable of climbing slopes greater than
those illustrated in figure 1, do not, under any circumstances, exceed the incline
guidelines or any other specifications presented in this manual. Doing so could
cause instability in your scooter.

Handicap public access ramps are not subject to government regulation in all countries and therefore do
not necessarily share the same standard percent of slope. Other inclines may be natural or, if man-made,
not designed specifically for scooters. Figures 1 and 1A illustrate your scooter’s stability and its ability to
climb grades under various weight loads and under controlled testing conditions.

These tests were conducted with the scooter’s seat in the highest position and adjusted rearward on the seat
base to its farthest rearward position. Use this information as a guideline. Your scooter’s ability to travel
up inclines is affected by your weight, your scooter’s speed, your angle of approach to the incline and your
scooter setup.

Figure 1. Maximum Recommended Incline Angles (3­wheel)

WARNING! Any attempt to climb or descend a slope steeper than what is shown in figures
1 and 1A may put your scooter in an unstable position and cause it to tip.

Figure 1A. Maximum Recommended Incline Angles (4­wheel)

WARNING! Never carry an oxygen tank weighing more than 6 kg (13 lbs.). Never fill the
front or rear basket with contents exceeding 6 kg (13 lbs.).

Celebrity Deluxe www.pridemobility.com

11

II. SAFETY

When you approach an incline, it is best to lean forward. See figures 2 and 2A. This shifts the centre of
gravity of you and your scooter toward the front of the scooter for improved stability.

NOTE: When negotiating ramps, if the throttle control lever is released while moving forward, the
powered scooter may "rollback" approximately 30.5 cm (12 inches) before the brake engages. If the
throttle control lever is released while moving in reverse, the powered scooter may "rollback" approx­imately 1 metre (3 feet) before the brake engages.

Figure 2A. Increased Stability Driving PositionFigure 2. Normal Driving Position

CORNERING INFORMATION

Excessively high cornering speeds can create the possibility of tipping. Factors which affect the possibility
of tipping include, but are not limited to, cornering speed, steering angle (how sharply you are turning),
uneven road surfaces, inclined road surfaces, riding from an area of low traction to an area of high traction
(such as passing from a grassy area to a paved area – especially at high speed while turning) and abrupt
directional changes. High cornering speeds are not recommended. If you feel that you may tip over in a
corner, reduce your speed and steering angle (i.e., lessen the sharpness of the turn) to prevent your scooter
from tipping.

WARNING! When cornering sharply, reduce your speed. When using your scooter at
higher speeds, do not corner sharply. This greatly reduces the possibility of a tip or fall.
Always exercise common sense when cornering.

BRAKING INFORMATION

Your scooter is equipped with these powerful brake systems:
 Regenerative: Uses electricity to rapidly slow the vehicle when the throttle control lever returns to the

centre/stop position.

 Disc Park Brake: Activates mechanically after regenerative braking slows the vehicle to near stop or

when power is removed from the system for any reason.

OUTDOOR DRIVING SURFACES

Your scooter is designed to provide optimum stability under normal driving conditions—dry, level sur­faces composed of concrete or tarmac. However, Pride recognises that there will be times when you will
encounter other surface types. For this reason, your scooter is designed to perform admirably on packed
soil, grass and gravel. Feel free to use your scooter safely on lawns and in park areas.

 Reduce your scooter’s speed when driving on uneven terrain and/or soft surfaces.
 Avoid tall grass that can become tangled in the running gear.
 Avoid loosely packed gravel and sand.
 If you feel unsure about a driving surface, avoid that surface.

12

www.pridemobility.com Celebrity Deluxe

II. SAFETY

PUBLIC STREETS AND ROADWAYS

WARNING! Exercise extreme caution when operating the scooter on footpaths,
pavements, bridleways, pedestrian areas and roads. Obey all local pedestrian traffic
rules.

STATIONARY OBSTACLES (STEPS, KERBS, ETC.)

Proceed with extreme caution when driving near raised surfaces, unprotected ledges and/or drop-offs
(kerbs, porches, stairs, etc.).

To navigate up over a kerb or stationary obstacle:

1. Approach the kerb or obstacle slowly, and make sure the scooter is traveling perpendicular to the obsta­cle. See figure 3.

2. Increase the forward speed just before the front wheel(s) come in contact with the obstacle.

3. Reduce the forward speed only after the rear wheels have cleared the obstacle.

To navigate down a kerb or stationary obstacle:

1. Approach the kerb or obstacle slowly, and make sure the scooter is traveling perpendicular to the obsta­cle. See figure 3.

2. Reduce the forward speed just before the front wheel(s) come in contact with the obstacle.

3. Increase the forward speed only after the rear wheels have cleared the obstacle and you are once again
on a level surface.

WARNING! Do not attempt to have your scooter climb or descend an obstacle that is
inordinately high.

WARNING! Do not attempt to have your scooter proceed rearward down any step, kerb
or other obstacle. This may cause the scooter to tip.

WARNING! Be sure your scooter is traveling perpendicular to any kerb you may be
required to ascend or descend. See figures 3 and 3A.

WARNING! Do not attempt to negotiate a kerb that has a height greater than 5 cm (2 in.).

Figure 3. Correct Kerb Approach Figure 3A. Incorrect Kerb Approach

Celebrity Deluxe www.pridemobility.com

13

II. SAFETY

INCLEMENT WEATHER PRECAUTIONS

Exposure of your scooter to inclement weather conditions should be avoided whenever possible. If sud­denly caught up in rain, snow, severe cold or heat while operating your scooter proceed to shelter at the
earliest opportunity. Thoroughly dry your scooter before storing, charging or operating your scooter.

PROHIBITED! Operating in rain, snow, salt, mist/spray conditions and on icy/slippery
surfaces can cause damage to the scooter and electrical system. Maintain and store
your scooter in a dry and clean condition.

WARNING! Prolonged exposure to hot or cold conditions may affect the temperature of
upholstered and non-upholstered items on the scooter, possibly resulting in skin
irritation. Exercise caution when using your scooter in extremely hot or cold conditions
or when exposing your scooter to direct sunlight for prolonged periods of time.

FREEWHEEL MODE

Your scooter is equipped with a manual freewheel lever that, when engaged, allows the scooter to be
pushed. For more information about how to place your scooter into and out of freewheel mode, see III.
“Your Scooter.”

WARNING! When your scooter is in freewheel mode, the braking system is disengaged.

 Disengage the drive motors only on a level surface.
 Ensure the key is removed from the key switch.
 Stand behind the scooter to engage or disengage freewheel mode. Never sit on a

scooter to do this.

 After you have finished pushing your scooter, always return it to the drive mode to

lock the brakes.

An added feature built into the scooter is “push-too-fast” protection which safeguards the scooter against
gaining excessive speed while in freewheel mode.

“Push-too-fast” operates differently depending on which of two conditions exists:
 If the key is switched “off” while in freewheel mode, the scooter’s controller activates regenerative

braking when the scooter is pushed faster than a maximum threshold which has been preprogrammed.
In this case, the controller is acting as a speed governor.

 If the key is switched “on” while in freewheel mode, you will encounter considerable resistance at any

speed.This prevents the scooter from gaining unwanted momentum should the manual freewheel lever
inadvertently be released while driving the scooter.

STAIRS AND ESCALATORS

Scooters are not designed to travel up or down stairs or escalators. Always use a lift.

WARNING! Do not use your scooter to negotiate steps or escalators.

DOORS

 Determine if the door opens toward or away from you.
 Use your hand to turn the knob or push the handle or push-bar.
 Drive your scooter gently and slowly forward to push the door open. Or drive your scooter gently and

slowly rearwards to pull the door open.

14

www.pridemobility.com Celebrity Deluxe

II. SAFETY

LIFTS

Modern lifts have a door edge safety mechanism that, when pushed, reopens the door(s).
 If you are in the doorway of a lift when the door(s) begin to close, push on the rubber door edge or

allow the rubber door edge to contact the scooter and the door will reopen.

 Use care that handbags, packages or scooter accessories do not become caught in lift doors.

NOTE: If your scooter’s turning radius is greater than 150 cm (60 in.), it may be difficult to manoeuvre
in lifts and building entrances. Use caution when attempting to turn or manoeuvre your scooter in small
spaces and avoid areas that might pose a problem.

LIFT/ELEVATION PRODUCTS

If you will be traveling with your scooter, you may find it necessary to use a lift/elevation product to aid
in transportation. Pride recommends that you closely review the instructions, specifications and safety
information set forth by the manufacturer of the lift/elevation product before using that product.

WARNING! Never sit on your scooter when it is being used in connection with any
type of lift/elevation product. Your scooter was not designed with such use in
mind and any damage or injury incurred from such use is not the responsibility
of Pride.

BATTERIES

In addition to following the warnings below, be sure to comply with all other battery handling information.

MANDATORY! Battery posts, terminals and related accessories contain lead and
lead compounds. Wear goggles and gloves when handling batteries and wash
hands after handling.

WARNING! Scooter batteries are heavy. See specifications table. If you are
unable to lift that much weight, be sure to get help. Use proper lifting techniques
and avoid lifting beyond your capacity.

WARNING! Always protect the batteries from freezing and never charge a frozen
battery. Charging a frozen battery may result in damage to the battery.

WARNING! Connect the battery harnesses in the proper manner. RED (+) cables
must be connected to positive (+) battery terminals/posts. BLACK (-) cables must
be connected to negative (-) battery terminals/posts. Protective caps should be
installed over all battery terminals. REPLACE cables immediately if damaged.

BATTERY DISPOSAL AND RECYCLING

If you encounter a damaged or cracked battery, immediately enclose it in a plastic bag. Contact your local
waste disposal agency or authorised Pride Dealer for instructions on disposal and battery recycling, which
is our recommended course of action.

PREVENTING UNINTENDED MOVEMENT

WARNING! If you anticipate being seated in a stationary position for an extended period
of time, turn off the power. This will prevent unexpected motion from inadvertent throttle
control lever contact.

Celebrity Deluxe www.pridemobility.com

15