Prem-I-Air ACS16E Instruction Manual

MMOOBBIILLEE AAIIRR CCOONNDDIITTIIOONNEERR

IINNSSTTRRUUCCTTIIOONN MMAANNUUAALL

MMOODDEELL AACCSS1166EE

IMPORTANT

Please read these instructions carefully before use.

Page 2

CCoonntteennttss

Important safety instructions

BS Plug Wiring Instruction

Technical Specification

Energy Saving Advice

Component Layout

Control Panel Operation

Use Of Control Panel

Control of Airflow Direction

Disconnecting The Refrigerant Line

Mounting The Outdoor Unit

Installing The Carbon Filters

Maintenance

End Of Season Storage

Troubleshooting

Service & Warranty

Page 3

IIm

mppoorrttaanntt SSaaffeettyy IInnssttrruuccttiioonnss

1. Transport & store the unit in an upright position only. Leave it in
an upright position for at least 3 hours before first use.

2. Always place the unit on an even, level surface.

3. An opening in a window or wall is required to accommodate the
exhaust hose to expel the hot air.

4. Make sure the unit is connected to an earthed power supply of the
correct rating. (Refer to the rating label located at the back of the
unit).

5. The unit will cool when the room temperature is between
18°C~32°C depending on the thermostat setting.

6. Operate this unit in an ambient temperature of 32°C or lower.

7. Do not operate the unit with a damaged power cord or plug, after
it malfunctions, has been dropped or damaged. If the power cord
is damaged it must be replaced by the manufacturer or a qualified
service engineer to avoid a hazard.

8. DO NOT use this unit for functions other than those described in
this instruction manual.

9. DO NOT tilt the unit.

10. DO NOT cover or obstruct the appliance’ s inlet and outlet grilles.

11. Your air conditioner has been designed to be used only in the
home, office and similar conditions and should not be used for
any other purpose.

12. Never unplug the air conditioner while it is working, this could
damage the electronic circuits.

13. DO NOT use the appliance in a wet room, such as a bathroom or
laundry room to avoid the risk of shock.

14. DO NOT sit or place articles on the appliance.

15. DO NOT use the appliance with wet or damp hands.

16. DO NOT let chemical substances come into contact with the
appliance.

17. DO NOT use the appliance in the presence of inflammable
substances or vapours such as alcoh ol, insecticides, petrol, etc.

18. DO NOT use the plug to start and stop the appliance.

19. ALWAYS use the control panel to start and stop the unit.

20. ALWAYS keep an air path of at least 50cm from walls, furniture or
curtains.

21. ALWAYS turn off the appliance when it is not in use and remove
the mains plug from the socket outlet.

Page 4

22. ALWAYS turn the unit off and remove the mains plug before
cleaning, carrying out maintenance or moving location.

23. Avoid the use of adapter plugs, multiple sockets and /or extension
leads. If their use is necessary, ensure they conform to current
safety standards.

24. Do not pull the electrical cable or place it near a source of heat:
always unroll it completely to avoid dangerous overheating. If the
supply cord becomes damaged, the service agent or a similarly
qualified person must replace it, in order to avoid a hazard.

25. The filter must be used with the product at all times, when
removing it for clearing always turn the unit off and unplug the
mains plug from the socket.

For those who are not aware of the danger that might occur from

the usage of an electrical appliance, they should use the product
under guidance and supervision.

TTHHEE MMAANNUUFFAACCTTUURREERR DDIISSCCLLAAIIMMSS AANNYY

RREESSPPOONNSSIIBBIILLIITTYY IIFF TTH

HEE AABBOOVVEE IINNSSTTRRUUCCTTIIOONNSS

AARREE NNOOTT FFOOLLLLOOWWEEDD..

Page 5

BBSS PPlluugg W

Wiirriinngg

Wiring Instructions: Should it be necessary to change the plug
please note the wires in the mains lead are coloured in accordance
with the following code:

BLUE - NEUTRAL

BROWN - LIVE

GREEN AND YELLOW - EARTH

As the colours of the wires in the mains lead of this appliance may not
correspond with the coloured markings identifying the terminals in your
plug, proceed as follows:

1. The BLUE wire is the NEUTRAL and must be connected to the
terminal which is marked with the letter N or coloured BLACK.

2. The BROWN wire is the LIVE and must be connected to the terminal
which is marked with the letter L or coloured RED.

3. The GREEN/YELLOW is the EARTH and must be connected to the
terminal which is marked with the letter E or or coloured GREEN
OR GREEN/YELLOW.

4. Always ensure that the cord grip is positioned and fastened correctly.

If a 13A (BS 1363) fused plug is used it must be fitted with a 13A fuse. If in
doubt consult a qualified electrician.

Wiring for a 13 Amp Plug (BS1363)

Please note. The Earth Terminal is marked with the letter E or
Earth Symbol

Page 6

TTeecchhnniiccaall SSppeecciiffiiccaattiioonn

Model no.

ACS16E

Power supply

220-240V/ 50Hz / 1 phase

Cooling capacity

16000BTU/hr, 4039Kcal/hr,

4689watts

Heating capacity

16000BTU/hr, 4039Kcal/hr, 4689watts

Power / Ampere consumption for
cooling

1750W/ 7.5A

Power / Ampere consumption for
heating

1280W/ 5.8A

Max. airflow volume (indoor unit)

750 m3/h

Humidity removal capacity

53L/day

Compressor

Rotary

Refrigerant

R-407C

Refrigerant load*

1.25Kg

Fan speed

3

Timer

1 ~ 12 hours

Working temperature

Indoor unit: 18 ~ 32oC

Outdoor unit: 21 ~ 43

o

C

Indoor unit

35 kg

Net weight

Outdoor unit

13 kg

Indoor unit

360 x 590 x 757 mm

Size

Outdoor unit

500 x 310 x 525 mm

Length of connection tube

3 m

Recommended room size

28m

2

* For models with heat function only.

Measuring condition for above is:

Cooling – Indoor: RT27

o

C, RH60%

Outdoor: RT35

o

C, RH50%

Heating - Indoor: RT20

o

C, RH60%

Outdoor: RT7

o

C, RH85%