Precor CW-119 User Manual

Assembly Guide

CW-119

CW-119 Assembly Guide

Important Safety Instructions

When using exercise equipment, basic precautions
should always be taken, including the following:

• Read all instructions before assembling the
CW-119. These instructions are written for your
safety and to protect the unit.

• Read each step in the assembly instructions and
follow the steps in sequence. Do not skip ahead. If
you skip ahead, you may learn later that you have
to disassemble components and that you may
have damaged the equipment, which would void
the Precor Limited Warranty.

• Assemble and operate the CW-119 on a solid, level
surface. Locate the unit a few feet from walls or
furniture to provide easy access.

• Do not allow children or those unfamiliar with its
operation on or near the equipment. Do not leave
children unsupervised around the unit.

• Use the equipment only for its intended purpose.
Do not use accessory attachments that are not
recommended by the manufacturer, as such
attachments may cause injuries.

• Do not attempt to service the CW-119 yourself. The
unit does not contain any user-serviceable parts.

Obtaining Service

For information about product operation or service,
refer to the Precor web site at www.precor.com where
you can also find customer support numbers or a list of
Precor authorized service centers.

If you contact Customer Support, have the serial
number available.

You can find the serial number printed on a label
affixed to the CW-119. For future reference, write the
serial number in the space provided below.

Serial number: _______________________

Important Safety Instructions

IMPORTANT SAFETY INSTRUCTIONS

page 3

CW-119 Assembly Guide

Table of Contents

Important Safety Instructions .................................................................................. 3

Obtaining Service ..................................................................................................................................... 3

Preparations............................................................................................................... 5

1

2

Unpacking the Equipment......................................................................................................................... 5

Required Tools .......................................................................................................................................... 5

Installation Requirements ......................................................................................................................... 5

Hardware Kit ............................................................................................................................................. 6

Assembly Instructions .............................................................................................. 7

Open the Box ............................................................................................................................................ 7

Assemble the Unit..................................................................................................................................... 8

Assemble the Pads ................................................................................................................................... 9

Clean the Pads and Assembly .................................................................................................................. 10

Limited Warranty Statement...................................................................................................................... 11

Specifications............................................................................................................................... Back cover

Table of Contents

page 4

CW-119 Assembly Guide

1

Preparations

Required Tools

Tools that you need to obtain before assembling the
unit include:

❏ Wire cutter or utility knife

❏ SAE hex key set

The CW-119 parts are inspected before shipment.
Each unit contains several pieces that require
assembly. You must obtain adult assistance during the
assembly process.

Unpacking the Equipment

When you open the box, carefully unpack the pieces
and lay them on the floor near the location where you
plan to use them.

CAUTION: Be careful when you remove the
packaging material with a utility knife. Do not cut
the upholstery or scratch the paint.

If any items are missing, contact the dealer from whom
you purchased the unit. For more information, refer to
Obtaining Service.

Installation Requirements

Follow these installation requirements when
assembling the unit:

• Review the Important Safety Instructions.

• Assemble the unit where it will be used.
Provide ample space around the unit.

• Install components in the sequence shown.

• Insert all fasteners in the same direction.
For aesthetic purposes, insert all the fasteners
in the same direction unless instructed (in text or
illustrations) to do otherwise.

• Leave room for adjustments. Tighten the
fasteners to keep the unit stable, but leave room for
adjustments. Do not fully tighten fasteners until
instructed to do so.

Preparations

page 5

CW-119 Assembly Guide

Hardware Kit

Fastener Qty

³⁄₈-inch x ¾-inch buttonhead screw (A) 4

³⁄₈-inch split washer (B) 4

⁵⁄₁₆-inch x 1¼-inch buttonhead screw (C) 7

⁵⁄₁₆-inch split washer (D) 7

⁵⁄₁₆-inch washer (E) 7

Preparations, continued

page 6

CW-119 Assembly Guide

Assembly

2

Assembly of the CW-119 takes about 45 minutes to
complete. If this is the first time you have assembled
this type of equipment, plan on allowing more time.

Be careful to open boxes and assemble components
in the sequence presented in this manual.

Instructions

Note: With so many assembled parts, proper alignment
and adjustment is critical. While tightening the fasteners,
be sure to leave room for adjustments. Do not fully

tighten fasteners until instructed to do so.

Open the Box

Use wire cutters to open the box and remove the
packing materials.

The illustration shows how the CW-119 will look when
you have completed its assembly. The callouts identify
specific pieces.

Back Pad

Seat Pad

Main Frame

Stabilizer

Assembly Instructions

page 7

CW-119 Assembly Guide

Assemble the Unit

Attach the Main Frame to the Stabilizer using
four ³⁄₈-inch X ¾-inch buttonhead screws (A)
four ³⁄₈-inch split washers (B)
Wrench tighten.

Note: Make sure the wheels on the Stabilizer are
positioned as shown in the illustration.

4 - ¾" buttonhead screws
4 - split washers

Assemble the Unit

page 8

CW-119 Assembly Guide

Assemble the Pads

1. Attach the Seat Pad to the Seat Adjustment using
three 1¼-inch buttonhead screws (C)
three ⁵⁄₁₆-inch split washers (D)
three ⁵⁄₁₆-inch washers (E)
Wrench tighten.

2. Attach the Back Pad to the Back Adjustment using
four 1¼-inch buttonhead screws (C)
four ⁵⁄₁₆-inch split washers (D)
four ⁵⁄₁₆-inch washers (E)
Wrench tighten.

This completes the assembly of the CW-119.

3 - 1¼" buttonhead screws
3 - split washers
3 - washers

Assemble the Pads

4 - 1¼" buttonhead screws
4 - split washers
4 - washers

page 9

CW-119 Assembly Guide

Clean the Pads and Assembly

To clean the pads, moisten a clean, soft cloth in a mild
solution of soap and water and wipe all the parts
thoroughly. Dry the pad with a clean, dry cloth.

Use the same procedure to clean the Main Frame and
plastic parts.

Frequently vacuum the floor underneath the CW-119 to
prevent the accumulation of dust and dirt. If necessary,
use the Seat Pad to lift the front end and tip the
CW-119 onto its wheels to roll it to a different location.

Clean the Pads and Assembly

page 10

Limited Warranty

Precor, Incorporated (PRECOR) will repair or replace any of the following components which
are defective as to materials or workmanship for products manufactured and sold after June 1,
1990:

ICARIAN & STRETCH CENTER:

Lifetime:Structural Steel Framework
Five Years: Rotary Bearings, Weight Stacks, Pulleys, Guide Rods, Structural Moving

Par ts
One Year: Cable, Linear Bearings, Springs
Ninety Days: Upholstery, Handgrips, All Other Items Not Listed

Not withstanding the above, all warranties provided by PRECOR shall terminate upon transfer
of ownership of the equipment by the original owner. PRECOR may require the Customer to
affirm that he is the original owner of the equipment before providing warranty services. This
warranty does not extend to any components which become defective due to abuse, misuse, or
lack of proper maintenance or if the equipment under warranty has been modified or altered in
anyway. The Customer seeking repair or replacement of defective equipment must notify
PRECOR at the address set forth on the back cover of such defect, admit PRECOR authorized
service representatives during normal business hours to effect repairs and pre-pay all defective
equipment within thirty (30) days of its receipt of notice of the defect from a Customer or the
equipment itself.

THIS WARRANTY IS LIMITED TO REPAIR AND/OR REPLACEMENT OF DEFECTIVE
EQUIPMENT. Except to the extent it is precluded from doing so in a particular state or other
jurisdiction by applicable law. PRECOR DISCLAIMS ANY AND ALL OTHER WARRANTIES
WHETHER EXPRESSED OR IMPLIED, INCLUDING BUT NOT LIMITED TO ANY IMPLIED
WARRANTY OR MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE.
Moreover, if any damage or defect is caused by the transport carrier, such claims must be filed
with the carrier at the time of delivery. PRECOR DISCLAIMS ANY AND ALL RESPONSIBILITY
FOR SUCH DAMAGE OR DEFECT, NO DEALER, EMPLOYEE, SALES REPRESENTATIVE
OR AGENT HAS ANY AUTHORITY TO MAKE ANY WARRANTIES OR REPRESENTATIONS
CONCERNING PRECOR EQUIPMENT BEYOND THOSE SET FORTH IN THIS WARRANTY
AND IN OTHER OFFICIAL PRECOR LITERATURE: AND PRECOR DISCLAIMS ALL
RESPONSIBILITY FOR ANY SUCH UNAUTHORIZED WARRANTIES OR
REPRESENTATIONS.

An individual purchasing PRECOR equipment in California for personal, family or household
purposes has the right to have defective equipment serviced or repaired during the warranty
period. The warranty period will be extended for the number of whole days that the equipment
is out of the buyer’s hands for warranty repairs. If a defect exists within the warranty period, the
warranty will not expire until the defect has been fixed. The warranty period will also be
extended if the warranty repairs have not been performed due to delays caused by
circumstances beyond the control of the buyer, or if the warranty repairs did not remedy the
defect and the buyer notifies PRECOR or its authorized dealer or sales representative of the
failure of the repairs within sixty (60) days after they were completed. If after a reasonable
number of attempts, the defect has not been fixed, the buyer may return the equipment for a
replacement or a refund subject, in either case, to deduction of a reasonable charge for usage.
This time extension does not affect the protections or remedies the buyer has under other laws.
Purchasers of PRECOR strength equipment have the right to bring an action at law or in equity
to resolve disputes concerning or to enforce the provisions of this warranty. Some states do not
allow the exclusion of limitations of incidental or consequential damages and/or limitation on
how long an implied warranty lasts, so the above limitations or exclusions may not apply to all
Customers. This warranty gives Customers specific legal rights; Customers may also have other
rights which may vary from state to state.

Effective 27 November 2006

P/N CW31973-102

page 11

CW-119 Assembly Guide

Notes:

page 12

CW-119 Specifications

Length: 48 inches (122 cm)

Height: 39 inches (99 cm)

Width: 30 inches (76 cm)

Shipping weight: 84 lb (38 kg)

Precor Incorporated
20031 142nd Avenue NE
P.O. Box 7202
Woodinville, WA USA 98072-4002
1-800-347-4404

Precor, Icarian, and Move Beyond are registered trademarks of Precor Incorporated.
Copyright 2008 Precor Incorporated.
Specifications subject to change without notice.

www.precor.com

NOTICE:

Precor is widely recognized for its innovative, award winning designs of exercise equipment. Precor aggressively seeks U.S. and
foreign patents for both the mechanical construction and the visual aspects of its product design. Any party contemplating the use of
Precor’s product designs is hereby forewarned that Precor considers the unauthorized appropriation of its proprietary rights to be a
very serious matter. Precor will vigorously pursue all unauthorized appropriation of its proprietary rights.

CW-119 Assembly Guide CW33677-102

Limited Warranty Statement CW31973-102

16 September 2008