Power Wheels Jeep Hurricane J4394, Jeep Hurricane K7112 Owner's Manual
Jeep
• Please read this manual
and save it with your original
sales receipt.
• Tools needed for assembly:
Phillips Screwdriver and Safety
Scissors (both not included).
• Use only with the included
Power Wheels
®
12 Volt LeadAcid, Rechargeable, orange
Battery and a Power Wheels
®
12 Volt Charger with type 12V
connector (both included).
• Requires four "C" (LR14)
alkaline
batteries for
FM Radio/Digital Clock
operation (not included).
• Please read this manual
and save it with your original
sales receipt.
• Tools needed for assembly:
Phillips Screwdriver and Safety
Scissors (both not included).
• Use only with the included
Power Wheels
Acid, Rechargeable, orange
Battery and a Power Wheels
12 Volt Charger with type 12V
connector (both included).
• Requires four "C" (LR14)
alkaline
FM Radio/Digital Clock
operation (not included).
®
12 Volt Lead-
batteries for
®
Owner's Manual
with Assembly Instructions
For Models J4394 and K7112
TABLE OF CONTENTS
Important Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Warnings and Cautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Parts Picture. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Battery Charging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Decoration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Battery Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Battery Care and Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Safe Driving Rules . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23
Vehicle Operation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Vehicle Care. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Problems and Solutions Guide. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
FCC Statement. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31
IMPORTANT INFORMATION
• Your new vehicle requires adult assembly. Please set aside at least
60 minutes for assembly.
• You must charge your battery for 18 - 30 hours before you use
your vehicle for the first time. We recommend that you start
charging your battery before beginning assembly. Please see
Battery Charging beginning on page 7 for detailed instructions.
• Read this manual carefully for important safety information and
operating instructions before using your vehicle. Keep this manual
for future reference as it contains important information.
• This vehicle is appropriate for use on generally level, rough terrain
(including hard surfaces, wet and dry grass, ruts, gravel, mulch
and mud) and by children 3 years of age and older.
• This vehicle has been pre-set so it will only operate in low speed.
See the instructions on page 24 to remove the high speed
lock-out screw.
• Use this vehicle ONLY outdoors. Most interior flooring can be
damaged by riding this vehicle indoors. Fisher-Price® will not be
responsible for damage to the floor if the vehicle is used indoors.
• To prevent damaging the motors and gears, teach your child to
stop the vehicle before switching direction. Do not exceed the
maximum weight capacity of 130 lbs (59 kg).
• If you have any questions about your Power Wheels® vehicle,
please call our toll-free service lines at 1-800-348-0751 from
9 AM to 7 PM (EST) Monday through Friday and 11 AM to 5 PM
(EST) Saturday. Trained customer service representatives are
available to take your call in English or French. Habla Español?
Si usted tiene alguna pregunta ó necesita asistencia llame gratis
1-800-348-0755 para los Estados Unidos. Tenemos representantes
que hablan español para atender su llamada.
• For your convenience, Power Wheels® maintains an independently
owned and operated Authorized Service Center Network with
more than 400 authorized service centers nationwide. Our
authorized service centers will repair or replace parts under
warranty at no extra charge, and can perform non-warranty
repairs for a minimal charge. To find the authorized service center
nearest you, please visit us on-line at www.powerwheels.com
or call 1-800-348-0751.
• Your vehicle includes a 12 volt orange battery that is specially
designed for use with this vehicle. If you need to replace this
battery, please visit us on-line at www.powerwheels.com or call
1-800-348-0751. We do not recommend the use of any other
Power Wheels® 12 volt battery with this vehicle.
• To register your vehicle, please visit us on-line at
www.powerwheels.com.
2
2
J4394pr-0920
ELECTRICAL HAZARD
WARNING
• Battery can fall out and injure a child if vehicle tips over. Always use battery retainer.
• PREVENT FIRE
- Never modify the electrical system. Alterations could cause a fire resulting in serious injury
and could also ruin the electrical system.
- Use of the wrong type battery or charger could cause a fire or explosion resulting in
serious injury.
- Use of Power Wheels
cause overheating, fire or explosion.
• The battery must be handled by adults only. The battery is heavy and contains sulfuric acid
(electrolyte). Dropping the battery could result in serious injury.
• Never allow children to charge the battery. Battery charging must be done by adults only. A child
could be injured by the electricity involved in charging the battery.
• Read the safety instructions on the battery.
• Examine the battery, charger and their connectors for excessive wear or damage each time
you charge the battery. If damage or excessive wear is detected, do not use the charger or the
battery until you have replaced the worn or damaged part.
• HOT motors. Handle carefully.
®
components in products other than Power Wheels® vehicles could
RIDING HAZARD
WARNING
• Prevent Injuries and Deaths
• Direct Adult Supervision Required.
• Never Ride at Night.
• Keep Children Within Safe Riding Areas.
These areas must be:
- away from swimming pools and other bodies of water to prevent drownings
- generally level to prevent tipovers
- away from steps, steep inclines, cars, roads and alleys.
• Riding Rules
Make sure children know and follow these rules for safe driving and riding.
- Always sit on the seat.
- Always wear shoes.
- Only 2 (two) riders at a time.
CAUTION
• In the unassembled state, this package contains small parts. Adult assembly is required.
• Use the charger in dry locations only.
3
J4394pr-0920
PARTS
• If you experience a problem with this product, or are missing a part, please call us at 1-800-348-0751, rather than return this product
to the store.
• Please identify all parts before assembly and save all packaging material until assembly is complete to ensure that no parts are discarded.
• Metal parts have been coated with a lubricant to protect them during shipment. Wipe all metal parts with a paper towel to remove any
excess lubricant.
Vehicle
Front Grille
Brush Guard
2 Rear Wheels
(with grooved hub)
Rear Clip
2 Front Wheels
Seat Bar
Rear Grille
Key
Seat
4 Hubcaps
4
Rear Bumper
4 Fenders
J4394pr-0920
Steering Wheel
Steering Wheel Cap
2 Side Mirrors
Rear Axle
2 Wheel
Retainers
Part Not Shown: Label Sheet
4 Front
Axle Caps
1 Steering
Column Cap
Steering Column
12 Volt Charger
2 Taillights
12 Volt Orange Battery
For your convenience, we included extra fasteners!
Note: Tighten and loosen all screws with a Phillips screwdriver. Do not over-tighten the screws.
3
#8 x
/4" Screw - 53
5
/32" x 11/2" Pin - 1
Fasteners Shown Actual Size
5
J4394pr-0920
PARTS PICTURE
11
12
8
11
15
9
14
13
17
16
23
1
18
11
10
18
5
4
6
12
11
21
20
2
7
3
1 Vehicle
2
Front Grille
3
Brush Guard
4
Rear Clip
5
Rear Bumper
6
Rear Wheel - 2
7 Front Wheel - 2
8
Seats
9 Seat Bar
10
Rear Grille
11
Fender - 4
12 Side Mirror - 2
13 Steering Wheel
14 Steering Pin
15 Steering Wheel Cap
16 Key
21
17 Steering Column
18
19
20 Steering Column Cap
21 Front Axle Cap - 4
22 Hubcap - 4
23 12 Volt Orange Battery
24 12 Volt Charger
22
Taillights - 2
Wheel Retainer - 2
24
Parts Not Shown
2 Label Sheets
3
#8 x
/4" Screw - 53
19
22
6
J4394pr-0920
BATTERY CHARGING
ELECTRICAL HAZARD
WARNING
• Battery can fall out and injure a child if
vehicle tips over. Always use battery retainer.
• PREVENT FIRE
- Never modify the electrical system.
Alterations could cause a fire resulting
in serious injury and could also ruin the
electrical system.
- Use of the wrong type battery or charger
could cause a fire or explosion resulting
in serious injury.
- Use of Power Wheels
products other than Power Wheels
®
components in
®
vehicles could cause overheating, fire
or explosion.
• The battery must be handled by adults only.
The battery is heavy and contains sulfuric
acid (electrolyte). Dropping the battery could
result in serious injury.
• Never allow children to charge the battery.
Battery charging must be done by adults
only. A child could be injured by the electricity involved in charging the battery.
• Read the safety instructions on the battery.
• Examine the battery, charger and their
connectors for excessive wear or damage
each time you charge the battery. If damage
or excessive wear is detected, do not use
the charger or the battery until you have
replaced the worn or damaged part.
CAUTION
Use the charger in dry locations only.
About Thermal Fuses
Your Power Wheels® 12 volt orange battery is equipped with a built-in
thermal fuse. The thermal fuse is a self-resetting safety device which
automatically “trips” and shuts down operation of the vehicle if the
vehicle is overloaded or the driving conditions too severe. Once
a fuse has "tripped", remove your foot from the pedal and wait
approximately 25 seconds before operating the vehicle again. To
avoid repeated automatic shut-downs, do not overload the vehicle by
exceeding the 130 lb. (59 kg) maximum weight capacity or by towing
anything behind the vehicle. Avoid severe driving conditions, such
as driving up slopes or running into fixed objects, which can cause
the wheels to stop spinning while power is still being supplied to
the motors and make sure your child stops the vehicle before
switching direction.
If a thermal fuse in a battery continually trips under normal driving
conditions, please contact your local Power Wheels® Authorized
Service Center. For the location of the Authorized Service Center
nearest to you, visit us on-line at www.powerwheels.com,
or call 1-800-348-0751.
Important Notes
• Your new battery must be charged for at least 18 hours
before you use it in your vehicle for the first time.
• We recommend that you start charging your battery before
beginning assembly of your new vehicle.
• The battery must be upright while charging.
• The charger is not a toy.
• Do not short circuit the battery.
• You do not need to remove the battery from your vehicle to
recharge it.
• Before charging the battery, examine the battery case for cracks
and other damage which may cause sulfuric acid (electrolyte) to
leak during the charging process. If damage is detected, do not
charge the battery or use it in your vehicle. Battery acid is very
corrosive and can cause severe damage to surfaces it contacts.
• Do not charge the battery on a surface (such as a kitchen counter
top) which could be damaged by the acid contained inside the
battery. Take precautions to protect the surface on which you
charge your battery.
• Use only a Power Wheels® 12 volt charger with "12 V" connector
(120 VAC, 60 Hz, 28W with an output of 12 VDC, 1200 mA) to
charge your Power Wheels® 12 volt orange battery.
• Use only the 12 volt orange battery included with this vehicle.
Do not use any other Power Wheels® 12 volt battery with this
vehicle. To replace the 12 volt orange battery, visit us on-line at
www.powerwheels.com or call 1-800-348-0751.
Adults Note: Regularly examine the charger for damage to the
cord, plug, housing or other parts that may result in the risk of fire,
electric shock or injury. In the event of any damage, do not use
the charger until the damage has been properly repaired. Please
call 1-800-348-0751.
• If your battery is old and will not accept a charge, do not leave it
in the vehicle. Always remove a dead battery from the vehicle.
7
J4394pr-0920
Battery
A
Charger
Connector
ASSEMBLY
WARNING
Children can be harmed by small parts,
B
sharp edges and sharp points in the vehicle's
unassembled state, or by electrical items.
Care should be taken in unpacking and
assembly of the vehicle. Children should
not handle parts, including the battery,
or help in assembly of the vehicle.
• Plug the charger connector into the battery
• Plug the charger into a standard wall outlet
Notes:
- Use the charger only in a wall outlet. Do not plug the charger into
a ceiling outlet.
- If power flow to the wall outlet is controlled by a switch, make sure
the switch is “ON”.
• Before first-time use, charge the battery for at least 18 hours.
Never charge the battery longer than 30 hours.
• Recharge the battery for at least 14 hours after each use of your
vehicle. Do not charge the battery longer than 30 hours.
• Once the battery is charged, disconnect the charger connector from
the battery. Unplug the charger from the wall outlet. The battery is
now ready to be installed in your vehicle. Please see the Battery
Installation section on page 21 for detailed instructions on installing
your battery. If your battery is already installed in your vehicle, simply
re-connect the motor harness connector to the battery.
A
.
B
.
Rear Bumper
1
• Fit the rear bumper to the rear end of the vehicle.
• Insert two screws into the rear bumper and tighten.
REAR VIEW
Vehicle
8
J4394pr-0920
Rear Clip
4
• Insert two screws into the trunk and tighten.
2
• Fit the rear clip onto the rear end of the vehicle and over the
rear bumper.
• Make sure the tabs on each side of the rear clip fit into the sides
of the vehicle.
• “Snap” the sides of the rear bumper into the openings on each
side of the rear clip.
Trunk Lid
3
Motor Harness
Connector
5
• Pull the motor harness connector through the opening in the rear
clip and into the trunk.
• Replace the trunk lid.
Rear Grille
• Using safety scissors, cut the plastic tie holding the trunk lid
in place.
• Press the tab on the trunk lid and lift to remove it.
6
• Fit the rear grille to the rear bumper.
• Insert six screws into the rear grille and tighten.
9
J4394pr-0920
TOP
VIEW
Taillights
7
• “Snap” both tail lights to the rear clip.
TOP
VIEW
TOP VIEW
Seat Bar
8
• Fit the seat bar to the back of the seat.
• Insert four screws through the seat bar and into the seat. Tighten
the screws.
Seat
9
Note: The seat is adjustable and has three positions. You can move
the seat back as your child grows.
• Insert the tabs on the front edge of the seat into one of the sets of
slots inside the vehicle.
• Choose the slots closest to the dash for shorter drivers and the
slots furthest from the dash for taller drivers.
10
J4394pr-0920
Loading...