Powermate PMC496500 User Manual
PMC496500
Insert
Additif
Adición
ELECTRIC GENERATOR - GROUPE ELECTROGENE - GENERADOR ELECTRICO
12/05 0063699
Thank you for selecting a Black Max™ Generator. The
Black Max™ generator has been made to supply reliable,
portable electrical power when utility power is not
available. We hope you will enjoy your new generator.
Merci d'avoir choisi le groupe électrogène Black Max™.
Ce groupe électrogène Black Max™ a été conçu pour
fournir le pouvoir électrique, portatif et fiable quand le
pouvoir d'utilité n'est pas disponible. Nous espérons que
votre groupe électrogène vous donnera entière
satisfaction.
Gracias por seleccionar un generador Black Max™. El
generador Black Max™ ha sido diseñado para
proporcionar energía eléctrica confiable y portátil cuando
no hay servicio disponible de energía pública. Esperamos
que disfrute de su nuevo generador.
IMPORTANT – Please make certain that persons who are to use this equipment thoroughly read and
understand these instructions and any additional instructions provided prior to operation.
IMPORTANT - Prière de vous assurer que les personnes destinées à utiliser cet appareil ont pris soin d'en lire
et d'en comprendre le mode d'emploi ou les directives avant de le mettre en marche.
IMPORTANTE. Asegúrese que las personas que utilizarán este equipo lean y entiendan completamente estas
instrucciones y cualquier instrucción adicional proporcionada antes del funcionamiento.
www.powermate.com
MAJOR GENERATOR FEATURES
*13 HP Honda OHV engine
E.CordKeeper™ Restraint
The CordKeeper™ restraint is a unique feature used to
prevent plugs from being pulled out of the receptacles.
*Cast-iron cylinder sleeve
*Low oil sensor
*Receptacles on control panel
*CordKeeper™
*8 gallon plastic fuel tank
*Spark arrester
*Portability Kit
CONTROL PANEL
A.120 V, 20 Ampere Duplex Receptacle
20 amps of current may be drawn from each half of the
receptacle. However, total power drawn must be kept within
nameplate ratings. These receptacles may be used along with
the twistlock receptacle provided the generator is not
overloaded.
B.120/240 V, 30 Ampere Twistlock Receptacle
A maximum of 30 amps may be drawn from the 120/240
volt receptacle, provided it is the only receptacle used.
However, current must be limited to the nameplate rating. If the
120/240 volt receptacle is used along with the 120 volt
receptacle, the total load drawn must not exceed the nameplate
ratings.
C.Circuit Breakers
The receptacles are protected by an AC circuit breaker. If
the generator is overloaded or an external short circuit occurs,
the circuit breaker will trip. If this occurs, disconnect all
electrical loads and try to determine the cause of the problem
before attempting to use the generator again. If overloading
causes the circuit breaker to trip, reduce the load. NOTE:
Continuous tripping of the circuit breaker may cause
damage to generator or equipment. The circuit breaker may
be reset by pushing the button of the breaker.
D.Engine On/Off Switch
LIMITED WARRANTY
Warranty Coverage: Powermate Corporation (the Company)
warrants to the original retail customer in North America that it
will repair or replace, free of charge, any parts found by the
Company or its authorized service representative to be
defective in material or workmanship. This warranty covers the
cost of replacement parts and labor for defects in material or
workmanship.
Not Covered:
· Transportation charges for sending the product to the
Company or its authorized service representative for
warranty service, or for shipping repaired or replacement
products back to the customer; these charges must be
borne by the customer.
· Engine is covered exclusively by a separate warranty from
the engine manufacturer, included with the engine Manual.
· Damages caused by abuse or accident, and the effects of
corrosion, erosion and normal wear and tear.
· Warranty is voided if the customer fails to install, maintain
and operate the product in accordance with the instructions
and recommendations of the Company set forth in the
owner's manual, or if the product is used as rental
equipment.
· The Company will not pay for repairs or adjustments to the
product, or for any costs or labor, performed without the
Company's prior authorization.
Warranty Period: Two (2) years from the date of purchase on
products used solely for consumer applications; if a product is
used for business or commercial applications, the warranty
period will be limited to one (1) year from the date of purchase.
For warranty service, the customer must provide dated proof of
purchase and must notify the Company within the warranty
period.
For warranty service: Call toll free 800-445-1805, or write
to Powermate Corporation, Product Services, 4970 Airport
Road, P. O. Box 6001, Kearney, NE 68848.
EXCLUSIONS AND LIMITATIONS: THE COMPANY MAKES
NO OTHER WARRANTY OF ANY KIND, EXPRESS OR
IMPLIED. IMPLIED WARRANTIES, INCLUDING
WARRANTIES OF MERCHANTABILITY AND OF FITNESS
FOR A PARTICULAR PURPOSE, ARE HEREBY
DISCLAIMED. THE WARRANTY SERVICE DESCRIBED
ABOVE IS THE EXCLUSIVE REMEDY UNDER THIS
WARRANTY; LIABILITY FOR INCIDENTAL AND
CONSEQUENTIAL DAMAGES IS EXCLUDED TO THE
EXTENT PERMITTED BY LAW.
This warranty gives you specific legal rights, and you may also
have other rights which vary from state to state. Some states
do not allow a disclaimer of implied warranties, or the exclusion
or limitation of incidental and consequential damages, so the
above disclaimers and exclusions may not apply to you.
2
English
3
PORTABILITY KIT INSTALLATION
TOOLS REQUIRED: 7/16”, 1/2” and 9/16" sockets and ratchets, block(s) of wood (minimum of 6” tall).
Refer to the parts list on page 9.
WHEEL INSTALLATION
1.Block up end of generator opposite the fuel tank cap to install wheel kit.
2.Insert wheel spacer (item 45) into the center of the wheel (item 31).
3.Slide 3/8 x 4.25” bolt (item 35) and 3/8 washer (item 30) through the wheel (item 31), then through the wheel bracket on the
carrier, with the offset side of the wheel hub against the wheel bracket.
4.Thread 3/8 nyloc nut (item 36) onto the bolt and tighten to securely clamp the wheel assembly to the carrier.
5.Repeat above instructions for the remaining wheel.
FOOT INSTALLATION
1.Assemble the rubber feet (item 32) to the foot bracket (item 49) using a 1/4-20 x 1.5” bolt (item 48). Thread a 1/4 washer
(item 39) and a 1/4 nyloc nut (item 13) to the bolt to secure the assembly. Caution: Do not over tighten so that the foot
material collapses.
2.Blocking up the alternator side of the generator, place the foot bracket under the carrier channel. Thread a 5/16-18 x 1” bolt
(item 47) with a 5/16 wide washer (item 34) through the mounting holes and thread a 5/16 wide washer (item 34) and a 5/16
nyloc nut (item 16) to the bolt to secure the foot bracket to the carrier.
HANDLE INSTALLATION
1.Place handle (item 28) and spacer (item 52) on carrier on same end as feet, as shown in the diagram.
2.Slide 5/16 x 2.25” bolt (item 29) and 5/16 washers (item 15) through handle and handle bracket as shown in diagram and
secure with 5/16” nyloc nut (item 16). Tighten until handle is securely clamped to the carrier.
3.Apply aerosol hairspray or similar adhesive to the handle (item 28), and then slide the handle grip (item 46) onto the handle.
The aerosol hairspray will allow for easier assembly and will adhere the grip to the handle.
4.Insert cap (item 38) into end of handle (item 28).
5.Repeat above instructions for the remaining handle.
LOCKING HANDLE
1.Attach the lanyards (item 33) to the release
pins (item 37) and carrier as shown in the
illustration.
2. To lock the handle (item 28) in the extended
position, align the holes in the handle brackets
with the holes in the carrier brackets and insert
the release pins (item 37).
1
3733
2
English
CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT
YOUR WARRANTY RIGHTS AND OBLIGATIONS
The California Air Resources Board and Powermate Corporation (herein "Powermate") are pleased to explain the evaporative emission
control system (EECS) warranty on your 2006 generator. In California, new generators must be designed, built and equipped to meet the
State's stringent anti-smog standards. Powermate must warrant the EECS on your generator for the periods of time listed below, provided
there has been no abuse, neglect or improper maintenance of your generator.
Your EECS includes parts such as: fuel hoses.
MANUFACTURER'S WARRANTY COVERAGE:
This evaporative emission control system is warranted for two years. The warranty period begins on the date the generator is delivered to
an ultimate purchaser.
Powermate warrants to the ultimate purchaser and any subsequent owner that the generator is (i) designed, built and equipped so as to
conform with all applicable regulations; and (ii) free from defects in materials and workmanship that cause the failure of a warranted part
to be identical in all material respects to that part as described in Powermate's application for certification.
If any evaporative emission-related part on your generator is defective, the part will be repaired or replaced by Powermate.
OWNER'S WARRANTY RESPONSIBILITIES:
As the generator owner, you are responsible for performance of the required maintenance listed in your owner's manual. Powermate
recommends that you retain all receipts covering maintenance on your generator, but Powermate cannot deny warranty solely for the lack
of receipts. You should, however, be aware that Powermate may deny you warranty coverage if your generator or a part has failed due to
abuse, neglect or improper maintenance or unapproved modifications.
You are responsible for presenting your generator to an authorized Powermate warranty service center as soon as the problem exists. The
warranty repairs should be completed in a reasonable amount of time, not to exceed 30 days. If you have a question regarding your
warranty coverage, you should call Powermate Product Service at 1-800-445-1805.
DETAILS OF YOUR WARRANTY
Subject to certain conditions and exclusions as stated below, the warranty on emission-related parts is as follows:
(1)Any warranted part that is not scheduled for replacement as required maintenance in the written instructions supplied, is warranted
for the period stated above. If the part fails during the period of warranty coverage, the part will be repaired or replaced by
Powermate according to Subsection (4) below. Any such part repaired or replaced under warranty will be warranted for the
remainder of the period.
(2)Any warranted part that is scheduled only for regular inspection in the written instructions supplied, is warranted for the warranty
period stated above. Any such part repaired or replaced under warranty will be warranted for the remaining warranty period.
(3)Any warranted part that is scheduled for replacement as required maintenance in the written instructions supplied, is warranted for
the period of time before the first scheduled replacement date for that part. If the part fails before the first scheduled replacement
date, the part will be repaired or replaced by Powermate according to Subsection (4) below. Any such part repaired or replaced under
warranty will be warranted for the remainder of the period prior to the first scheduled replacement date for the part.
(4)Repair or replacement of any warranted part under the warranty provisions herein must be performed at an authorized Powermate
warranty service center at no charge to the owner.
(5)The generator owner will not be charged for diagnostic labor that is directly associated with diagnosis of a defective,
emission-related warranted part, provided that such diagnostic work is performed at an authorized Powermate warranty service
center.
(6)Powermate is liable for damages to other engine or generator components proximately caused by a failure under warranty of any
warranted part.
(7)Throughout the generator warranty period stated above, Powermate will maintain a supply of warranted parts sufficient to meet the
expected demand for such parts.
(8)Any replacement part may be used in the performance of any warranty maintenance or repairs and must be provided without charge
to the owner. Such use will not reduce the warranty obligations of Powermate.
(9)Add-on or modified parts that are not exempted by the Air Resources Board may not be used. The use of any non-exempted add-on
or modified parts by the ultimate purchaser will be grounds for disallowing a warranty claims. Powermate will not be liable to war
rant failures or warranted parts caused by the use of a non-exempted add-on or modified part.
(10)The repair or replacement of any warranted part otherwise eligible for warranty coverage may be excluded from such warranty
coverage if the generator has been abused, neglected or improperly maintained, and such abuse, neglect or improper maintenance
was the direct cause of the need for repair or replacement of the part.
WARRANTED PARTS:
The following emission warranty parts list is covered:
Fuel Hose.
4
English
compagnie ou à son représentant du service autorisé pour
distincte du fabricant du moteur. Cette garantie est incluse
5
CARACTÉRISTIQUES PRINCIPALES DU
GROUPE ELECTROGENE
*Moteur 13 HP Honda OHV
*Chemise de cylindres en fonte
*Détecteur de bas niveau d'huile
*Prises sur tableau de commande
*CordKeeper™
*Réservoir de carburant en plastique d'une
contenance de 30.3 litres (8 gallons)
*Pare-étincelles
*Kit de transport
TABLEAU DE COMMANDE
A.Prise double de 120 V, 20 A
20 ampères de courant peuvent être dessinés de chaque
moitié de la prise. La charge totale doit cependant rester dans
les limites indiquées sur la plaque signalétique. Ces prises
peuvent s’utiliser en conjonction avec la prise à verrouillage à
condition que le générateur ne soit pas surchargée.
B.Prise à verrouillage de 120/240 V, 30 A
Cette prise de 120/240 V fournit un maximum de 30 A à
condition que ce soit la seule utilisée. La charge totale doit par
ailleurs rester dans les limites indiquées sur la plaque
signalétique. Si la prise de 120/240 V est utilisée en
conjonction avec les prises de 120 V, la charge totale ne doit
pas dépasser les limites indiquées sur la plaque.
C.Disjoncteurs
Les prises sont protégées par un disjoncteur alternatif. En
cas de surcharge ou de court-circuit extérieur, le disjoncteur
saute. Si cela se produit, débrancher tout appareil relié au
groupe électrogène et essayer de déterminer la cause du
problème avant d’essayer de le réutiliser. Si le disjoncteur
saute en raison d’une surcharge, réduire la charge.
REMARQUE : Le groupe électrogène ou les appareils
branchés dessus peuvent se trouver abîmés si le
disjoncteur saute continuellement. Appuyer sur le bouton du
disjoncteur pour le réenclencher.
D.Commutateur On/Off (Sur/De) du moteur
E.CordKeeper™ la Restriction
Le CordKeeper™ la restriction est un dispositif unique qui
empêche la fiche de ressortir accidentellement d’une prise.
GARANTIE LIMITÉE
Couverture limitée : Powermate Corporation (la compagnie)
garantit au revendeur d'origine en Amérique du Nord qu'elle
réparera ou remplacera, sans frais, toutes les pièces que la
compagnie ou que son représentant du service autorisé auront
déterminé comme étant défectueuses du point de vue du
matériel ou de la fabrication. La garantie couvre les coûts de
remplacement des pièces et de main-d'œuvre pour tout défaut
matériel ou de fabrication.
Ce qui n'est pas couvert :
· Les frais de transport pour envoyer le produit à la
effectuer le travail couvert par la garantie, les frais
d'expédition au client des produits réparés ou remplacés.
Ces frais doivent être assumés par le client.
· Le moteur est couvert exclusivement par une garantie
dans le guide d'utilisation du moteur.
· Les dommages causés par un abus ou un accident, et les
effets de la corrosion, de l'érosion ainsi que de l'usure
normale.
· La garantie est annulée si le client n'arrive pas à installer,
garder et faire fonctionner le produit conformément aux
directives et aux recommandations de la compagnie
formulées dans le guide d'utilisation, ou si le produit est
utilisé comme équipement de location.
· La compagnie ne paiera pas de réparation ou des
ajustements au produit, ou pour les coûts ou maind'œuvre, exécuté sans l'autorisation préalable de la
compagnie.
Période couverte par la garantie : Deux (2) ans à partir de la
date d'achat sur les produits utilisés uniquement pour les
applications de consommateur. Si le produit est utilisé à des
fins d'affaires ou commerciales, la période couverte par la
garantie se limite à un (1) an à partir de la date d'achat. En ce
qui concerne l'entretien couvert par la garantie, le client doit
présenter une preuve de la date d'achat et il doit aviser la
compagnie au cours de la période couverte par la garantie.
Pour tout ce qui touche l'entretien couvert par la garantie :
Composez sans frais le 1 800 445-1805, ou écrivez à
Powermate Corporation, Product Services, 4970 Airport
Road, P. O. Box 6001, Kearney, NE 68848 É.-U.
EXCLUSIONS ET LIMITATIONS : LA COMPAGNIE NE
PRÉSENTE AUCUNE AUTRE GARANTIE, EXPRESSE OU
IMPLICITE. LES GARANTIES IMPLICITES, INCLUANT LES
GARANTIES DE QUALITÉ MARCHANDE ET DE
CONFORMITÉ AUX BESOINS SONT, PAR LA PRÉSENTE,
ABANDONNÉES. L'ENTRETIEN COUVERT PAR LA
GARANTIE DÉCRIT CI-DESSUS EST UN RECOURS
EXCLUSIF EN VERTU DE CETTE GARANTIE. LA
RESPONSABILITÉ POUR DES DOMMAGES ACCESSOIRES
ET INDIRECTS EST EXCLUE JUSQU'À LA LIMITE
AURORISÉE PAR LA LOI.
Français
Cette garantie vous donne des droits spécifiques reconnus par
la loi. Vous pouvez également bénéficier de certains autres
droits, lesquels varient d'une province (État) à l'autre. Certaines
provinces (ou certains États) n'autorisent pas de clauses de
renonciation des garanties implicites ou de limites à l'égard de
dommages accessoires ou indirects, ainsi, les clauses de
renonciation et les exclusions ci-dessus peuvent ne pas
s'appliquer à vous.
Loading...