Powermate PMC401857 User Manual
PMC401857
12/05 0063573
ELECTRIC GENERATOR - GROUPE ELECTROGENE - GENERADOR ELECTRICO
Insert
Additif
Adición
Thank you for selecting a Coleman® Powermate®
Generator. The Coleman® Powermate® generator has
been made to supply reliable, portable electrical power
when utility power is not available. We hope you will
enjoy your new generator. Welcome to our worldwide
family of Coleman® Powermate® generator users.
Merci d'avoir choisi le groupe électrogène Coleman®
Powermate®. Ce groupe électrogène Coleman®
Powermate® a été conçu pour fournir le pouvoir
électrique, portatif et fiable quand le pouvoir d'utilité n'est
pas disponible. Nous espérons que votre groupe
électrogène vous donnera entière satisfaction. Bienvenue
dans la famille mondiale des utilisateurs de groupes
électrogènes Coleman® Powermate®.
Gracias por seleccionar un generador Coleman®
Powermate®. El generador Coleman® Powermate® ha
sido diseñado para proporcionar energía eléctrica
confiable y portátil cuando no hay servicio disponible de
energía pública. Esperamos que disfrute de su nuevo
generador. Bienvenido a nuestra familia de usuarios de
generadores Coleman® Powermate® a nivel mundial.
IMPORTANT – Please make certain that persons who are to use this equipment thoroughly read and
understand these instructions and any additional instructions provided prior to operation.
IMPORTANT - Prière de vous assurer que les personnes destinées à utiliser cet appareil ont pris soin d'en lire
et d'en comprendre le mode d'emploi ou les directives avant de le mettre en marche.
IMPORTANTE. Asegúrese que las personas que utilizarán este equipo lean y entiendan completamente estas
instrucciones y cualquier instrucción adicional proporcionada antes del funcionamiento.
www.powermate.com
MAJOR GENERATOR FEATURES
FUEL TANK VENTING
*3.5 HP Briggs & Stratton engine
*Receptacles on endbell
*1.35 gallon plastic fuel tank
*Spark arrester
*Brushless generator
ENDBELL
A .120 V, 15 Ampere Duplex Receptacles
15 amps of current may be drawn from each half of the
receptacle. However, total power drawn must be kept within
nameplate ratings.
B.Circuit Breaker
The receptacles are protected by an AC circuit breaker. If
the generator is overloaded or an external short circuit occurs,
the circuit breaker will trip. If this occurs, disconnect all
electrical loads and try to determine the cause of the problem
before attempting to use the generator again. If overloading
causes the circuit breaker to trip, reduce the load. NOTE:
Continuous tripping of the circuit breaker may cause
damage to generator or equipment. The circuit breaker may
be reset by pushing the button of the breaker.
CAUTION: Keep fuel tank area free of all
debris, water, and ice. Do not block vent.
“Tank must breathe.”
SPARK ARRESTER MUFFLER
This engine is equipped with a U.S. Forest Service
approved spark arrest muffler. It should periodically be cleaned
to prevent the screen from becoming clogged, which could
hamper engine performance.
To clean, remove the muffler shield. Remove the four
screws and pull the plate with the screen attached. Clean off
any particles with a brush and reinstall. Be sure gasket is in
place.
C.Engine Switch
RECEPTACLE PANEL RECOIL PANEL
ENGINE MAINTENANCE SCHEDULE
Check engine oil . . . . . . . . . . . . . . . . . . . . . . Before each use
Change engine oil . . . . . . . . . . . . After first 20 hours and then
every 50 hours of operation
Clean air filter. . . . . . . . . . . . . . . . Every 50 hours of operation
Clean spark plug . . . . . . . . . . . . Every 100 hours of operation
Clean spark arrestor . . . . . . . . . . Every 50 hours of operation
Oil Type. Use new good quality oil such as SC, SD, and
SE grades. The oil to be used depends upon the temperature
at which the engine is operated:
Summer: (temperatures of over 40 degrees F/10 degrees
C) SAE 30 or SAE 10W-30, SAE 10W-40
Winter: (temperatures of below 40 degrees F/10 degrees
C) SAE 20 or SAE 10W-30
2
English
3
LIMITED WARRANTY
Warranty Coverage: Powermate Corporation (the Company) warrants to the original retail customer in North America that it will
repair or replace, free of charge, any parts found by the Company or its authorized service representative to be defective in
material or workmanship. This warranty covers the cost of replacement parts and labor for defects in material or workmanship.
Not Covered:
· Transportation charges for sending the product to the Company or its authorized service representative for warranty service,
or for shipping repaired or replacement products back to the customer; these charges must be borne by the customer.
· Engine is covered exclusively by a separate warranty from the engine manufacturer, included with the engine Manual.
· Damages caused by abuse or accident, and the effects of corrosion, erosion and normal wear and tear.
· Warranty is voided if the customer fails to install, maintain and operate the product in accordance with the instructions and
recommendations of the Company set forth in the owner's manual, or if the product is used as rental equipment.
· The Company will not pay for repairs or adjustments to the product, or for any costs or labor, performed without the
Company's prior authorization.
Warranty Period: Two (2) years from the date of purchase on products used solely for consumer applications; if a product is
used for business or commercial applications, the warranty period will be limited to one (1) year from the date of purchase. For
warranty service, the customer must provide dated proof of purchase and must notify the Company within the warranty period.
For warranty service: Call toll free 800-445-1805, or write to Powermate Corporation, Product Services, 4970 Airport
Road, P. O. Box 6001, Kearney, NE 68848.
EXCLUSIONS AND LIMITATIONS: THE COMPANY MAKES NO OTHER WARRANTY OF ANY KIND, EXPRESS OR IMPLIED.
IMPLIED WARRANTIES, INCLUDING WARRANTIES OF MERCHANTABILITY AND OF FITNESS FOR A PARTICULAR
PURPOSE, ARE HEREBY DISCLAIMED. THE WARRANTY SERVICE DESCRIBED ABOVE IS THE EXCLUSIVE REMEDY
UNDER THIS WARRANTY; LIABILITY FOR INCIDENTAL AND CONSEQUENTIAL DAMAGES IS EXCLUDED TO THE EXTENT
PERMITTED BY LAW.
This warranty gives you specific legal rights, and you may also have other rights which vary from state to state. Some states do
not allow a disclaimer of implied warranties, or the exclusion or limitation of incidental and consequential damages, so the above
disclaimers and exclusions may not apply to you.
English
CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT
YOUR WARRANTY RIGHTS AND OBLIGATIONS
The California Air Resources Board and Powermate Corporation (herein "Powermate") are pleased to explain the evaporative emission
control system (EECS) warranty on your 2006 generator. In California, new generators must be designed, built and equipped to meet the
State's stringent anti-smog standards. Powermate must warrant the EECS on your generator for the periods of time listed below, provided
there has been no abuse, neglect or improper maintenance of your generator.
Your EECS includes parts such as: fuel hoses.
MANUFACTURER'S WARRANTY COVERAGE:
This evaporative emission control system is warranted for two years. The warranty period begins on the date the generator is delivered to
an ultimate purchaser.
Powermate warrants to the ultimate purchaser and any subsequent owner that the generator is (i) designed, built and equipped so as to
conform with all applicable regulations; and (ii) free from defects in materials and workmanship that cause the failure of a warranted part
to be identical in all material respects to that part as described in Powermate's application for certification.
If any evaporative emission-related part on your generator is defective, the part will be repaired or replaced by Powermate.
OWNER'S WARRANTY RESPONSIBILITIES:
As the generator owner, you are responsible for performance of the required maintenance listed in your owner's manual. Powermate
recommends that you retain all receipts covering maintenance on your generator, but Powermate cannot deny warranty solely for the lack
of receipts. You should, however, be aware that Powermate may deny you warranty coverage if your generator or a part has failed due to
abuse, neglect or improper maintenance or unapproved modifications.
You are responsible for presenting your generator to an authorized Powermate warranty service center as soon as the problem exists. The
warranty repairs should be completed in a reasonable amount of time, not to exceed 30 days. If you have a question regarding your
warranty coverage, you should call Powermate Product Service at 1-800-445-1805.
DETAILS OF YOUR WARRANTY
Subject to certain conditions and exclusions as stated below, the warranty on emission-related parts is as follows:
(1)Any warranted part that is not scheduled for replacement as required maintenance in the written instructions supplied, is warranted
for the period stated above. If the part fails during the period of warranty coverage, the part will be repaired or replaced by
Powermate according to Subsection (4) below. Any such part repaired or replaced under warranty will be warranted for the
remainder of the period.
(2)Any warranted part that is scheduled only for regular inspection in the written instructions supplied, is warranted for the warranty
period stated above. Any such part repaired or replaced under warranty will be warranted for the remaining warranty period.
(3)Any warranted part that is scheduled for replacement as required maintenance in the written instructions supplied, is warranted for
the period of time before the first scheduled replacement date for that part. If the part fails before the first scheduled replacement
date, the part will be repaired or replaced by Powermate according to Subsection (4) below. Any such part repaired or replaced under
warranty will be warranted for the remainder of the period prior to the first scheduled replacement date for the part.
(4)Repair or replacement of any warranted part under the warranty provisions herein must be performed at an authorized Powermate
warranty service center at no charge to the owner.
(5)The generator owner will not be charged for diagnostic labor that is directly associated with diagnosis of a defective,
emission-related warranted part, provided that such diagnostic work is performed at an authorized Powermate warranty service
center.
(6)Powermate is liable for damages to other engine or generator components proximately caused by a failure under warranty of any
warranted part.
(7)Throughout the generator warranty period stated above, Powermate will maintain a supply of warranted parts sufficient to meet the
expected demand for such parts.
(8)Any replacement part may be used in the performance of any warranty maintenance or repairs and must be provided without charge
to the owner. Such use will not reduce the warranty obligations of Powermate.
(9)Add-on or modified parts that are not exempted by the Air Resources Board may not be used. The use of any non-exempted add-on
or modified parts by the ultimate purchaser will be grounds for disallowing a warranty claims. Powermate will not be liable to war
rant failures or warranted parts caused by the use of a non-exempted add-on or modified part.
(10)The repair or replacement of any warranted part otherwise eligible for warranty coverage may be excluded from such warranty
coverage if the generator has been abused, neglected or improperly maintained, and such abuse, neglect or improper maintenance
was the direct cause of the need for repair or replacement of the part.
WARRANTED PARTS:
The following emission warranty parts list is covered:
Fuel Hose.
4
English
5
CARACTÉRISTIQUES PRINCIPALES DU
GROUPE ELECTROGENE
*Moteur 3.5 HP Briggs & Stratton
*Prises sur covre-enroulement
*Réservoir de carburant en plastique d'une
contenance de 5.1 litres (1.35 gallon)
*Pare-étincelles
*Sans balais génératrice
COVRE-ENROULEMENT
A.Prises double de 120 V, 15 A
15 ampères de courant peuvent être dessinés de chaque
moitié de la prise. La charge totale doit cependant rester dans
les limites indiquées sur la plaque signalétique.
B.Disjoncteurs
Les prises sont protégées par un disjoncteur alternatif. En
cas de surcharge ou de court-circuit extérieur, le disjoncteur
saute. Si cela se produit, débrancher tout appareil relié au
groupe électrogène et essayer de déterminer la cause du
problème avant d’essayer de le réutiliser. Si le disjoncteur
saute en raison d’une surcharge, réduire la charge.
REMARQUE : Le groupe électrogène ou les appareils
branchés dessus peuvent se trouver abîmés si le
disjoncteur saute continuellement. Appuyer sur le bouton du
disjoncteur pour le réenclencher.
DONNER VENT DE RESERVOIR DE CARBURANT
ATTENTION: Garder le réservoir de carburant
sans domaine de tout débris, toute eau, et
toute glace. Pas le conduit de bloc.
“Respire” de réservoir.
LE SILENCIEUX PARE-ETINCELLES
Ce moteur est muni d’un silencieux pare-étincelles
approuvé par le Service des Forêts aux USA. Il faut nettoyer
périodiquement le silencieux pour empêcher que le tamis
devienne colmaté, ce qui pourrait entraver le fonctionnement
de la machine.
Pour nettoyer le silencieux, enlevez la tôle. Enlevez les
quatre écrous et
tirez la plaque avec le tamis attaché. Nettoyez à l’aide d’une
brosse et réinstallez l’ensemble. Vérifiez que le joint est bien en
place.
C.Commutateur du moteur
PANNEAU DE PRISE PANNEAU DE
RECULER
LE PLAN D'ENTRETIEN DE MOTEUR
Vérifier l’huile du moteur . . . . . . . . . Avant chaque utilisation
Changer l’huile du moteur . . Après les premières 20 heures
d’utilisation et toutes les
50 heures d’utilisation
Nettoyer le filtre à air . . . . . Toutes les 50 heures d’utilisation
Nettoyer la bougie . . . . . . Toutes les 100 heures d’utilisation
Nettoyer le pare-étincelles. Toutes les 50 heures d’utilisation
Le type d’huile. Utilisez une huile neuve et de bonne
qualité telle que les grades SC, SD et SE. L’huile à utiliser
dépend de la température à laquelle le moteur sera actionné.
L’été: (des températures de plus de 10 degrés C / 40
degrés F) SAE 30 ou SAE 10W-30, SAE 20W-40
L’hiver: (des températures de moins de 10 degrés C / 40
degrés F) SAE 20 ou SAE 10W-30
Français
Loading...