How it Works
Poulan
Loading...
we16542e
Parts List
48 pgs1.94 Mb0
Parts List
48 pgs1.68 Mb0
Parts List
17 pgs686.36 Kb0

Poulan we16542e Parts List

For Parts Call K&T 606-678-9623 or 606-561-4983
REPAIR PARTS
SCHEMATIC
TRACTOR - - MODEL NUMBER WE16542E
A
AMMETER
(OPTIONAL)
B
G
L
IGNITION
SWITCH
BLACK
BLACK
BATTERY
FUSE
WHITE
M
STARTER
BLACK
SOLENOID
S
M
A1
CLUTCH / BRAKE
(PEDAL UP)
WHITE
A2
SEAT SWITCH
(NOT OCCUPIED)
BLACK
GROUNDING
CONNECTOR
SPARK
PLUG
GAP
(2 PLUGS ON
TWIN CYL. ENGINES)
28 VOLTS AC MIN. @ 3600 RPM (CHARGING SYSTEM DISCONNECTED)
ALTERNATOR
BLACK
BLACK
BLACK
HOUR
METER
(OPTIONAL)
FUEL
BLUE
FUEL SHUT-OFF SOLENOID
(IF SO EQUIPPED)
LINE
ORANGE
WHITE
ATT'MENT CLUTCH
(CLUTCH OFF)
BLACK
BLACK
CHARGING SYSTEM OUTPUT 3 AMP DC @ 3600 RPM
LIGHTING SYSTEM OUTPUT 5 AMP AC @ 3600 RPM
IGNITION
UNIT
DIODE
IGNITION SWITCH
CIRCUITPOSITION
OFF
M+G+A1
B+A1RUN/LIGHT
B+A1RUN
B + S + A1START
“MAKE”
NONE
A2+L
NONE
NONE
14 VOLTS AC MIN. @ 3600 RPM (LIGHTS OFF)
NOTE
YOUR TRACTOR IS EQUIPPED WITH A SPECIAL
BROWN
ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS
NON-REMOVABLE
CONNECTIONS
WILL BECOME THEIR BRIGHTEST.
REMOVABLE
CONNECTIONS
WIRING INSULATED CLIPS
NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR
SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING.
27
www.mymowerparts.com
BLACK
HEADLIGHTS
For Parts Call K&T 606-678-9623 or 606-561-4983
REPAIR PARTS
ELECTRICAL
24
TRACTOR - - MODEL NUMBER WE16542E
2221
42
41
33
30
27
27
43
25
27
27
26
40
16
16
48
8
27
2
1
52
29
28
28
www.mymowerparts.com
For Parts Call K&T 606-678-9623 or 606-561-4983
REPAIR PARTS
ELECTRICAL
TRACTOR - - MODEL NUMBER WE16542E
KEY PART NO. NO. DESCRIPTION
1 144925 Battery 12 Volt 25 Amp 2 74760412 Bolt Hex Hd 1/4-20unc X 3/4 8 156417 Case Battery 16 153664 Switch Interlock Push -In 21 166181 Harness Asm Light W/4152J 22 4152J Bulb Light #1156 24 4799J Cable Battery 6 Ga 11"red 25 146147 Cable Battery 6 Ga w/16 wire,red 26 175158 Fuse 20 AMP 27 73510400 Nut Keps Hex 1/4-20 unc 28 4207J Cable Ground 6 Ga 12" black 29 121305X Switch Plunger Nc Gray 30 175566 Switch Ign 33 140401 Key Ign 40 178437 Harness Ign 41 71110408 Bolt Blk Fin Hex 1/4-20 X 1/2 42 131563 Cover Terminal Red 43 178861 Solenoid 48 140844 Adaptor Ammeter Rectangular 52 141940 Protection Wire Loop
NOTE: All component dimensions give in U.S. inches
1 inch = 25.4 mm.
29
www.mymowerparts.com
For Parts Call K&T 606-678-9623 or 606-561-4983
REPAIR PARTS
TRACTOR - - MODEL NUMBER WE16542E
CHASSIS AND ENCLOSURES
212
208
26
30
31
25
17
24
29
18
20
58
53
23
12
51
28
54
52
55
57
24
25
26
3
11
209
9
15
209
5
5
209
209
207
8
33
206
26
207
6
16
3
37
10
2
35
205
38
3
35
38
3
34
26
205
1
13
145
37
208
30
www.mymowerparts.com
For Parts Call K&T 606-678-9623 or 606-561-4983
REPAIR PARTS
TRACTOR - - MODEL NUMBER WE16542E
CHASSIS AND ENCLOSURES
KEY PART NO. NO. DESCRIPTION
1 174620 Chassis 2 176554 Drawbar 3 17060612 Screw 3/8-16 x 3/4 5 155272 Bumper Hood/Dash 6 155923 Saddle Flat Lt Fender Shift 8 155138 Clip Retainer Slide-On 9 168347X011 Dash 10 72140608 Bolt RdHd Sqnk. 3/8-16 Unc x 1 11 155927 Panel Asm. Dash Lh 12 145660 Clip Tinnerman Grile P/L 13 172107X010 Panel Dash Rh 15 74180512 Screw Mach Trhd 5/16-18 Unc x 3/4 16 73510500 Nut Keps 5/16-18 Unc 17 159639X550 Hood 18 126938X Bumper Hood 20 156437 Plate Mtg Battery/Fuel Tank Fr 23 124028X Bushing Snap Nyl Blk Fuel Line 24 74780616 Bolt Fin Hex 3/8-16 Unc x 1 Gr. 5 25 19131312 Washer 13/32 x 13/16 x 12 Ga. 26 73800600 Nut Lock Hex w/Insert 3/8-16 UNC 28 140434 Grill/Lens Asm 29 140273X599 Lens Grille Private label 30 169467X550 Fender Asm 31 136619 Bracket Fender 33 145244X550 Footrest Lh 34 145243X550 Footrest Rh 35 72110606 Bolt RdHd Sht. Sqnk. 3/8-16 x 3/4 37 17490508 Screw Thdrol 5/16-18 x 1/2 Tyt 38 175710 Bracket Asm. Pivot Mower Rear 51 73800400 Nut Lock Hex W/Ins. 1/4-20 52 19091416 Washer 9/32 x 7/8 x 16 Ga. 53 144697 Bracket Grille LH 54 161464 Screw Hex Wshd 8-18 x 7/8 55 144696 Bracket, Grille RH 57 74780412 Bolt Fin Hex 1/4-20 x .75 58 150127 Air Duct Private Label tractor - ­145 156524 Rod Pivot Chassis/Hood 205 17490608 Screw 3/8-16 x 1/2 206 170165 Bolt shoulder 5/16-18 207 17670508 Screw Thdrol 5/16-18 x 1/2 208 17670608 Screw Thdrol 3/8-16 x 1/2 209 17000612 Screw Hex Wsh Thdrol 3/8-16 212 156229 Insert Lens Reflector
- - 5479J Plug Btn Blk
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
31
www.mymowerparts.com
For Parts Call K&T 606-678-9623 or 606-561-4983
REPAIR PARTS
DRIVE
TRACTOR - - MODEL NUMBER WE16542E
57
84
13
16
77
145
197
14
112
85
11
96
52
26
90
85
30
253
80
81
32
10
89
59
159
158
76
62
162
83
156
61
35
29
168
166
36
56
41
38
39
34
28
22
161
198
21
171
113
32
77
30
26
2
164
51
52
163
19
74
14
82
165
5
18
6
24
78
169
18
8
4
3
6
79
170
6
253
25
1
75
51
37
26
63
66
65
64
27
49
27
212
50
47
120
36
35
70
116
55
202
150
48
151 51
53
32
www.mymowerparts.com
Loading...
+ 11 hidden pages
Buy Points How it Works FAQ Contact Us Questions and Suggestions Privacy Policy Cookie Policy Terms of Use