Poulan PO10530LT User Manual

IMPORTANT MANUAL DO NOT THROW AWAY

5000

REPAIR PARTS MANUAL

WARNING:

MODEL:

Read this Man u al and follow all Warnings
and Safety Instructions. Fail ure to do so
can re sult in serious in ju ry.

PO10530LT

LAWN TRACTOR

ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan.com

580 65 86-24

03.12.12 JM

Printed in the U.S.A.

HOW TO USE THIS MANUAL

This manual is designed to provide the customer with a means to identify the parts on his/her tractor
when ordering parts. The illustrations may or may not represent the actual assemblies; therefore, it
is not recommended to use this manual as a guide to assemble or disassemble the tractor. Some
hardware and parts are drawn larger in order to more readily identify them.

Each tractor has its own model number.
The model number for your tractor can be found on the fender under the seat.
When ordering parts, always give the following information:

• Product - “TRACTOR”

• MODEL NUMBER - “PO10530LT (96048003900)”

• Part Number

• Part Description

TABLE OF CONTENTS

SCHEMATIC ................................................................................................................ 3

ELECTRICAL ............................................................................................................ 4-5

CHASSIS ..................................................................................................................6-7

DRIVE........................................................................................................................8-9

ENGINE ................................................................................................................. 10-11

STEERING ............................................................................................................12-13

MOWER DECK .....................................................................................................14-15

MOWER LIFT ............................................................................................................. 16

SEAT .......................................................................................................................... 17

DECALS .....................................................................................................................18

WARRANTY ...............................................................................................................19

PARTS AND SERVICE .............................................................................................. 20

2

TRACTOR - MODEL NO. PO10530LT (96048003900), PRODUCT NO. 960 48 00-39

SCHEMATIC

SCH18

RED

(OPTIONAL)

B

G

L

A

AMMETER

S

M

A1

A2

WHITE

FUSE

BATTERY

BLACK

BLACK

BLACK

SOLENOID

DER

CLUTCH/BRAKE

(PEDAL UP)

WHITE

2

3
1

6

JUNCTION

CONNECTOR

BLACK

BLACK

BLACK
BLACKBLACK

GRAY

BLACK

STARTER

M

M

ATTACHMENT CLUTCH

(CLUTCH OFF)

BLACK

GRAY

REVERSE SWITCH
(NOT IN REVERSE)

SEAT SWITCH

(NOT OCCUPIED)

NOTE

YOUR TRACTOR IS
EQUIPPED WITH A SPECIAL
ALTERNATOR SYSTEM.
THE LIGHTS ARE NOT
CONNECTED TO THE
BATTERY, BUT HAVE THEIR
OWN ELECTRICAL SOURCE.
BECAUSE OF THIS, THE
BRIGHTNESS OF THE LIGHTS
WILL CHANGE WITH ENGINE
SPEED. AT IDLE THE LIGHTS
WILL DIM. AS THE ENGINE IS
SPEEDED UP, THE LIGHTS
WILL BECOME THEIR

BRIGHTEST.

IGNITION SWITCH

POSITION

RUN/OVERRIDE

OFF

CIRCUIT

M+G+A1

B+A1
B+A1RUN

B+S+A1START

“MAKE”

L+A2

BLACK

CHASSIS HARNESS

BLUE

63

52

41

CONNECTOR

(MATING SIDE)

BLACK /WHITE

IGNITION

(OPTIONAL)

BLUE BLACK

FUEL

LINE

FUEL SHUT-OFF

SOLENOID

(IF SO EQUIPPED)

RED

CHASSIS

HARNESS

UNIT

HOUR

METER

CHARGING SYSTEM OUTPUT
3 AMP DC @ 3600 RPM

SPARK

PLUGS GAP

(2 PLUGS ON

TWIN CYL. ENGINES)

POWER OUTLET

(OPTIONAL)

28 VOLTS AC MIN. @ 3600 RPM
(CHARGING SYSTEM DISCONNECTED)

DIODE

6

3

2

5

1

4

DASH HARNESS

CONNECTOR

(MATING SIDE)

WIRING INSULATED CLIPS
NOTE: IF WIRING INSULATED
CLIPS WERE REMOVED FOR
SERVICING OF UNIT, THEY
SHOULD BE RE-INSTALLED TO
PROPERLY SECURE YOUR
WIRING.

SHORTING

CONNECTOR

12V

ALTERNATOR

NON-REMOVABLE

CONNECTIONS

REMOVABLE

CONNECTIONS

3

TRACTOR - MODEL NO. PO10530LT (96048003900), PRODUCT NO. 960 48 00-39

ELECTRICAL

T31K

With 12V Outlet Option

103

59

With Service Minder Option

4646

26

87

40

33

30

27

43

42

41

25

28

16

90

2

29

55

71

94

92

93

4

TRACTOR - MODEL NO. PO10530LT (96048003900), PRODUCT NO. 960 48 00-39

ELECTRICAL

KEY PART
NO. NO. DESCRIPTION

1 532 14 49-24 Battery
2 874 76 04-12 Bolt Hex Hd 1/4-20 unc x 3/4
8 532 19 32-28 Box Battery
16 532 17 61-38 Switch Interlock
25 532 41 28-94 Cable Starter Battery 6 Ga. BL/Red 14.5
26 532 17 51-58 Fuse
27 873 51 04-00 Nut Keps Hex 1/4-20 unc
28 532 19 88-85 Cable Ground 18" Rear Battery Blk 6 Ga.
29 532 19 27-49 Switch Seat
30 532 19 33-50 Switch Ign
33 532 41 19-35 Key/Chain
40 532 40 10-98 Harness Ign
41 817 72 04-08 Screw 1/4-20 unc x 1/2
42 532 13 15-63 Cover Terminal Red
43 532 19 25-07 Solenoid
55 817 06 05-12 Screw 5/16-18 x 3/4
71 532 44 15-44 Harness Ign. Chass.
87 532 19 78-02 Switch Interlock Clutch
90 532 43 53-95 Cover Terminal
92 532 19 66-15 Harness Pigtail Reverse Switch
93 532 19 25-40 Screw Plastic 10-14 x 2.0
94 532 19 18-34 Modual Reverse ROS

NOTE: All component dimensions given in U.S. inches
1 inch = 25.4 mm

5

TRACTOR - MODEL NO. PO10530LT (96048003900), PRODUCT NO. 960 48 00-39

CHASSIS

18

14

5

176

151

137

181

287

196

37

162

36

176

182

138

194

189

181

194

58

176

177

176

175

68

228

235

183

68

180

236

183

68

68

130

34

235

68

236

213

218

68

Chassis-tex_ALPHA_1

189

217

194

52

189

228

189

152

189

6