Poulan 198933, 20112X92E0, 20112X92E1 User Manual

Models

20112X92E0

MOWER

20112X92E1

INSTRUCTION BOOK

This Instruction Book contains information for several models.
Read and keep this book for future reference.
This book contains important information on

SAFETY, ASSEMBLY, OPERATION, MAINTENANCE & STORAGE.

PRODUCT INFORMATION

The owner must be certain that all the product information is in­cluded with the unit. This information includes the INSTRUCTION
BOOKS, the REPLACEMENT PARTS and the WARRANTIES.
This information must be included to make sure state laws and
other laws are followed.

RECORD THE FOLLOWING INFORMATION ABOUT YOUR UNIT.
THIS INFORMATION IS NECESSARY WHEN ORDERING PARTS
OR IN CASE OF LOSS OR THEFT.

WHERE PURCHASED: _____________________________
DATE PURCHASED: Month______ Day ______ Year ______
MODEL NO.: _________ DATE OF MANUFACTURE: _________

198933 04.19.05 BY Printed in U.S.A.

TABLE OF CONTENTS

Warranty.................................................. 2

Safety Rules ......................................... 3-5

Product Spec i fi ca tions ........................... 5

Assembly/Pre-Operation ...................... 6-8

Operation............................................ 9-11

Maintenance Schedule.......................... 12

Maintenance..................................... 12-14

Service and Adjustments....................... 15

Storage............................................. 15-16

Troubleshooting ................................ 16-17

Repair Parts...................................... 18-19

Service .................................... Back Cover

WARRANTY

The Manufacturer warrants to the original consumer purchaser that this product as manu­factured is free from defects in materials and workmanship. For a period of one (1) year
from date of purchase by the original consumer purchaser, we will repair or replace, at our
option, without charge for parts or labor incurred in replacing parts, any part which we fi nd
to be defective due to materials or work man ship. This Warranty is subject to the following
limitations and exclusions.

1. This warranty does not apply to the engine, other than EHP manufactured transaxle/
transmission components, battery (except as noted below) or com po nents parts thereof.
Please refer to the applicable manufacturer's warranty on these items.

2. Transportation charges for the movement of any power equipment unit or at tach ment
are the responsibility of the purchaser. Transportation charges for any parts sub mit ted
for replacement under this warranty must be paid by the purchaser unless such return
is requested by Electrolux Home Products.

3. Battery Warranty: On products equipped with a Battery, we will replace, without charge
to you, any battery which we fi nd to be defective in manufacture, during the fi rst ninety
(90) days of ownership. After ninety (90) days, we will exchange the Battery, charging
you 1/12 of the price of a new Battery for each full month from the date of the original
sale. Battery must be maintained in accordance with the in struc tions furnished.

4. The Warranty period for any products used for rental or commercial purposes is limited
to 45 days from the date of original purchase.

5. This Warranty applies only to products which have been properly assembled, adjusted,
operated, and maintained in accordance with the instructions fur nished. This Warranty
does not apply to any product which has been subjected to al ter ation, misuse, abuse,
improper assembly or installation, delivery damage, or to normal wear of the product.

6. Exclusions: Excluded from this Warranty are belts, blades, blade adapters, normal wear,
normal adjustments, standard hardware and normal maintenance.

7. In the event you have a claim under this Warranty, you must return the product to an
authorized service dealer.

Should you have any unanswered questions concerning this Warranty, contact:

Electrolux Home Products, Inc.
Outdoor Products Customer Service Dept.
1030 Stevens Creek Road
Augusta, GA 30907 USA

giving the model number, serial number and date of purchase of your product and the name
and address of the au tho rized dealer from whom it was pur chased.

THIS WARRANTY DOES NOT APPLY TO INCIDENTAL OR CONSEQUENTIAL DAM­AGES AND ANY IMPLIED WAR RAN TIES ARE LIMITED TO THE SAME TIME PERIODS
STATED HEREIN FOR OUR EXPRESSED WARRANTIES. Some areas do not allow the
limitation of consequential damages or lim i ta tions of how long an implied Warranty may
last, so the above lim i ta tions or exclusions may not apply to you. This Warranty gives you
specifi c legal rights, and you may have other rights which vary from locale to locale.

In Canada contact:
Electrolux Consumer Outdoor Products
5855 Terry Fox Way
Mississauga, Ontario
L5V 3E4

This is a limited Warranty within the meaning of that term as defi ned in the Magnuson­Moss Act of 1975.

2

OWNER'S INFORMATION

This instruction book is written for a person
with some mechanical ability. Like most ser­vice books, not all the steps are described.
Steps on how to loosen or tighten fasten­ers are steps anyone can follow with some
mechanical ability. Read and follow these
instructions before you use the unit.
Know your product: If you understand the
unit and how the unit operates, you will get the
best performance. As you read this manual,
compare the illustrations to the unit. Learn
the location and the function of the controls.
To help prevent an accident, follow the oper­ating instructions and the safety rules. Keep
this manual for future reference.
IMPORTANT: Many units are not assembled
and are sold in cartons. It is the responsibility
of the owner to make sure the assembly in­structions in the manual are exactly followed.
Other units are purchased in assembled
condition. On assembled units, it is the re­sponsibility of the owner to make sure the

SAFETY RULES

unit is correctly assembled. The owner must
carefully check the unit according to the in­structions in this manual before it is fi rst used.

RESPONSIBILITY OF THE OWNER

The responsibility of the owner is to
follow the instructions below.

1. Carefully read and follow the rules for
safe operation.

2. Follow all the assembly and prepara­tion instructions.

3. Inspect the unit.

4. Make sure that the operator of the unit
knows how to correctly use all stan­dard and accessory equipment.

5. Operate the unit only with guards,
shields, and other safety items in place
and working correctly.

6. Correctly adjust the unit.

7. Service the unit only with authorized or
approved replacement parts.

8. Complete all maintenance on the unit.

IMPORTANT: This cutting machine is
capable of amputating hands and feet and
throwing objects. Failure to observe the
following safety instructions could result in
serious injury or death.

Look for this symbol to point out
im por tant safety precautions. It means
CAU TION!!! BECOME ALERT!!!
YOUR SAFE TY IS INVOLVED.

WARNING: In order to prevent ac ci den tal
starting when setting up, trans port ing, ad­ just ing or making repairs, always dis con nect
spark plug wire and place wire where it can not
come in contact with plug.

WARNING: Engine exhaust, some of its
constituents, and certain vehicle com po ­nents contain or emit chem i cals known to
the State of Cal i for nia to cause can cer and
birth defects or oth er re pro duc tive harm.

WARNING: Battery posts, terminals and
related accessories contain lead and lead
compounds, chemicals known to the State
of Cal i for nia to cause can cer and birth
defects or oth er re pro duc tive harm. Wash

hands after handling.

CAUTION: Muffl er and

other engine parts become
extremely hot during oper­ation and remain hot after
engine has stopped. To avoid
severe burns on contact,
stay away from these areas.

I. GENERAL OPERATION

• Read, understand, and follow all
in struc tions on the machine and in the
manual(s) before starting. Be thor ough ly
familiar with the controls and the proper
use of the machine before starting.

• Do not put hands or feet near or under
rotating parts. Keep clear of the dis­ charge opening at all times.

• Only allow responsible individuals, who
are familiar with the in struc tions, to
operate the machine.

• Clear the area of objects such as rocks,
toys, wire, bones, sticks, etc., which
could be picked up and thrown by blade.

• Be sure the area is clear of other people
before mowing. Stop ma chine if anyone
enters the area.

• Do not operate the mower when bare­ foot or wearing open sandals. Al ways
wear substantial foot wear.

• Do not pull mower backwards unless
absolutely nec es sary. Always look down
and behind before and while moving
backwards.

• Never direct discharged material toward
anyone. Avoid discharging material against
a wall or obstruction. Material may richo­chet back toward the operator. Stop the
blade when crossing gravel surfaces.

• Do not operate the mower without
proper guards, plates, grass catcher or
oth er safety protective devices in place.

3

• See manufacturer’s instructions for
proper operation and installation of
accessories. Only use accessories ap­proved by the manufacturer.

• Stop the blade(s) when crossing grav el
drives, walks, or roads.

• Stop the engine (motor) whenever you
leave the equip ment, before clean ing
the mower or unclogging the chute.

• Shut the engine (motor) off and wait
until the blade comes to complete stop
before removing grass catcher.

• Mow only in daylight / good artifi cial light.

• Do not operate the machine while under
the infl uence of alcohol or drugs.

• Never operate machine in wet grass.
Always be sure of your footing: keep a
fi rm hold on the handle; walk, never run.

• Disengage the self-propelled mech­ a nism or drive clutch on mowers so
equipped before starting the engine.

• If the equipment should start to vi brate
abnormally, stop the engine (motor) and
check immediately for the cause. Vibra­tion is generally a warning of trouble.

• Always wear safety goggles or safe ty
glasses with side shields when op er ­at ing mower.

II. SLOPE OPERATION

Slopes are a major factor related to slip &
fall accidents which can result in severe
injury. All slopes require extra caution. If
you feel uneasy on a slope, do not mow it.

DO:

• Mow across the face of slopes: nev er
up and down. Exercise extreme caution
when changing direction on slopes.

• Remove obstacles such as rocks, tree
limbs, etc.

• Watch for holes, ruts, or bumps. Tall
grass can hide obstacles.

DO NOT:

• Do not trim near drop-offs, ditches or
embankments. The operator could lose
footing or balance.

• Do not trim excessively steep slopes.

• Do not mow on wet grass. Reduced
footing could cause slipping.

III. CHILDREN

Tragic accidents can occur if the op er a tor
is not alert to the presence of children.
Children are often attracted to the ma-

Never

chine and the mowing activity.
sume that children will remain where you
last saw them.

• Keep children out of the trimming area
and under the watchful care of an oth er
re spon si ble adult.

as-

• Be alert and turn machine off if chil dren
enter the area.

• Before and while walking back wards,

down

look behind and

• Never allow children to operate the
machine.

• Use extra care when approaching blind
corners, shrubs, trees, or other objects
that may obscure vision.

for small chil dren.

IV. SAFE HANDLING OF GASOLINE

Use extreme care in handling gasoline.
Gasoline is extremely fl ammable and the
vapors are explosive.

• Extinguish all cigarettes, cigars, pipes
and other sources of ignition.

• Use only an approved container.

• Never remove gas cap or add fuel with
the engine running. Allow engine to
cool before refueling.

• Never refuel the machine indoors.

• Never store the machine or fuel contain­er where there is an open fl ame, spark
or pilot light such as a water heater or
on other appliances.

• Never fi ll containers inside a vehicle, on
a truck or trailer bed with a plastic liner.
Always place containers on the ground
away from your vehicle before fi lling.

• Remove gas-powered equipment from
the truck or trailer and refuel it on the
ground. If this is not possible, then
refuel such equipment with a portable
container, rather than from a gasoline
dispenser nozzle.

• Keep the nozzle in contact with the rim
of the fuel tank or container opening at
all times until fueling is complete. Do
not use a nozzle lock-open device.

• If fuel is spilled on clothing, change
clothing immediately.

• Never overfi ll fuel tank. Replace gas
cap and tighten securely.

V. GENERAL SERVICE

• Never run machine inside a closed area.

• Never make adjustments or repairs with
the engine (motor) running. Dis con nect
the spark plug wire, and keep wire away
from plug to prevent ac ci den tal starting.

• Keep nuts and bolts, especially blade
attachment bolts, tight and keep equip­ment in good condition.

• Never tamper with safety devices. Check
their proper operation reg u lar ly.

• Keep machine free of grass, leaves, or
other debris build-up. Clean oil or fuel spill­age. Allow machine to cool before storing.

• Stop and inspect the equipment if you
strike an object. Repair, if nec es sary,
before restarting.

4

• Never attempt to make wheel height
adjustments while the engine is running.

• Grass catcher components are sub ject to
wear, dam age, and de te ri o ra tion, which
could expose moving parts or allow objects
to be thrown. Frequently check com po ­nents and replace with man u fac tur er’s

• Mower blades are sharp and can cut.
Wrap the blade(s) or wear gloves, and
use extra caution when ser vic ing them.

• Do not change the engine governor set­ting or overspeed the engine.

• Maintain or replace safety and instruc­tion labels, as necessary.

recommended parts, when necessary.

WARNING: This lawn mower is equipped with an internal com bus tion engine and should
not be used on or near any un im proved forest-covered, brush-covered or grass-cov ered
land unless the engine’s exhaust system is equipped with a spark arrester meeting ap­plicable local or state laws (if any). If a spark arrester is used, it should be maintained
in effective working order by the operator. In the state of California the above is required
by law (Section 4442 of the California Public Resources Code). Other states may have
similar laws. Federal laws apply on federal lands. A spark arrester for the muffl er is
available through your nearest authorized service center.

PRODUCT SPECIFICATIONS

Gasoline Capacity / Type: 1.0 Quarts (0,94 Litres) Unleaded Regular
Oil Capacity: 20 Ounces (0,58 Litres)

Oil Type (API SG–SL): SAE 30 (above 0°C/32°F); SAE 5W-30 (below 0°C/32°F)

Spark Plug: Champion RJ19LM (Gap: 0.30" / 0,76 mm)
Blade Bolt Torque: 35-40 ft. lbs. (47-54 N-m)

Parts Bag contents (shown full size)

Lower Handle

(4) Hex Head

Bolts 3/8-16 x 3/4

Upper Handle

(4) Flangelock Nuts(4) Washers

Upstop Bracket

(1) Hex Washer Head

Self-Tapping Screw

#10-24 x 1/2

Discharge Guard

Rope Guide

(1) Locknut

1/4-20

(2) Hex Head Bolts 1/4-20 x 1-1/2

Wheels

(4)

(4) Shoulder Bolts

Locknuts
3/8-16

(2) Locknuts

(2) Hex Head

Bolts 1/4-20

(4) Spacers 1"

5

(2) Washers

(2) Washers 1-1/4"

(2) Nylock

Nuts 1/4-20

Parts packed separately in carton

(1) Lower Handle(1) Upper Handle

(4) Wheels

(1) Discharge Guard

(1)

Control

Bar

(1)

Engine

Zone

Control

Cable

Parts Bag

Contents

(not shown

full size)

(1) Rope Guide

(2) Wire

Ties

(1) Upstop Bracket

ASSEMBLY / PRE-OPERATION

CAUTION: Do not operate this mower

without the discharge guard or an entire
approved grass catcher in place. These
guards are for your protection and are
required by the Amer i can National Stan­ dards Institute and Consumer Products
Safety Com mis sion.

CAUTION: Dis con nect spark plug wire
from spark plug and place wire where it
can not come in contact with plug.
Read these instructions and this manual in
its entirety before you attempt to assemble
or operate your new lawn mower.
IMPORTANT: This lawn mower is
shipped WITHOUT OIL OR GASOLINE in
the engine.

Your new lawn mower has been as sem ­bled at the factory with the exception of
those parts left unassembled for shipping
purposes. All parts such as nuts, washers,
bolts, etc., necessary to com plete the as­ sem bly have been placed in the parts bag.
To ensure safe and proper operation of
your lawn mower, all parts and hard ware
you assemble must be tightened securely.
Use the correct tools as necessary to
ensure proper tight ness.

TOOLS REQUIRED FOR AS SEM BLY

A socket wrench set will make as sem bly
easier. Standard wrench sizes are listed.

(1) 5/16" Wrench (1) Ad just able Wrench
(1) 7/16" Wrench (1) 9/16" Wrench
(1) 1/2" Wrench (1) 3/4" Wrench

When right hand or left hand is men tioned
in this manual, it means when you are
standing in the operating po si tion, behind
the handle.

UNPACK CARTON

1. Remove all loose parts from carton.

2. Examine all items. Compare with list of
unas sembled parts and hardware.

3. Remove lawn mower housing with
care. Avoid touch ing blade under
housing. Always wear gloves or other
protection when working un der or lift ing
mower.

ASSEMBLE LOWER HANDLE
NOTE: For ease of lower handle as-

sem bly, raise rear of mower housing and
block se cure ly.

6