Poulan 225114X92E0, 224110X92E0, 2005-04 User Manual
Models
224110X92E0
MOWER
225114X92E0
INSTRUCTION BOOK
This Instruction Book contains information for several models.
Read and keep this book for future reference.
This book contains important information on
SAFETY, ASSEMBLY, OPERATION, MAINTENANCE & STORAGE.
PRODUCT INFORMATION
The owner must be certain that all the product information is included with the unit. This information includes the INSTRUCTION
BOOKS, the REPLACEMENT PARTS and the WARRANTIES.
This information must be included to make sure state laws and
other laws are followed.
RECORD THE FOLLOWING INFORMATION ABOUT YOUR UNIT.
THIS INFORMATION IS NECESSARY WHEN ORDERING PARTS
OR IN CASE OF LOSS OR THEFT.
WHERE PURCHASED: _____________________________
DATE PURCHASED: Month______ Day ______ Year ______
MODEL NO.: _________ DATE OF MANUFACTURE: _________
198189 Rev. 3 04.19.05 BY Printed in U.S.A.
TABLE OF CONTENTS
Warranty.................................................. 2
Safety Rules ......................................... 3-5
Product Spec i fi ca tions ........................... 5
Assembly/Pre-Operation ......................... 5
Operation.............................................. 6-8
Maintenance Schedule............................ 9
Maintenance....................................... 9-11
Service and Adjustments....................... 12
Storage............................................. 13-14
Troubleshooting ................................ 14-15
Repair Parts...................................... 16-17
Service .................................... Back Cover
WARRANTY
The Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materials and workmanship. For a period of two (2) years
from date of purchase by the original consumer purchaser, we will repair or replace, at our
option, without charge for parts or labor incurred in replacing parts, any part which we fi nd
to be defective due to materials or work man ship. This Warranty is subject to the following
limitations and exclusions.
1. This warranty does not apply to the engine, other than EHP manufactured transaxle/
transmission components, battery (except as noted below) or com po nents parts thereof.
Please refer to the applicable manufacturer's warranty on these items.
2. Transportation charges for the movement of any power equipment unit or at tach ment
are the responsibility of the purchaser. Transportation charges for any parts sub mit ted
for replacement under this warranty must be paid by the purchaser unless such return
is requested by Electrolux Home Products.
3. Battery Warranty: On products equipped with a Battery, we will replace, without charge
to you, any battery which we fi nd to be defective in manufacture, during the fi rst ninety
(90) days of ownership. After ninety (90) days, we will exchange the Battery, charging
you 1/12 of the price of a new Battery for each full month from the date of the original
sale. Battery must be maintained in accordance with the in struc tions furnished.
4. The Warranty period for any products used for rental or commercial purposes is limited
to 45 days from the date of original purchase.
5. This Warranty applies only to products which have been properly assembled, adjusted,
operated, and maintained in accordance with the instructions fur nished. This Warranty
does not apply to any product which has been subjected to al ter ation, misuse, abuse,
improper assembly or installation, delivery damage, or to normal wear of the product.
6. Exclusions: Excluded from this Warranty are belts, blades, blade adapters, normal wear,
normal adjustments, standard hardware and normal maintenance.
7. In the event you have a claim under this Warranty, you must return the product to an
authorized service dealer.
Should you have any unanswered questions concerning this Warranty, contact:
Electrolux Home Products, Inc.
Outdoor Products Customer Service Dept.
1030 Stevens Creek Road
Augusta, GA 30907 USA
giving the model number, serial number and date of purchase of your product and the name
and address of the au tho rized dealer from whom it was pur chased.
THIS WARRANTY DOES NOT APPLY TO INCIDENTAL OR CONSEQUENTIAL DAMAGES AND ANY IMPLIED WAR RAN TIES ARE LIMITED TO THE SAME TIME PERIODS
STATED HEREIN FOR OUR EXPRESSED WARRANTIES. Some areas do not allow the
limitation of consequential damages or lim i ta tions of how long an implied Warranty may
last, so the above lim i ta tions or exclusions may not apply to you. This Warranty gives you
specifi c legal rights, and you may have other rights which vary from locale to locale.
In Canada contact:
Electrolux Consumer Outdoor Products
5855 Terry Fox Way
Mississauga, Ontario
L5V 3E4
This is a limited Warranty within the meaning of that term as defi ned in the MagnusonMoss Act of 1975.
2
OWNER'S INFORMATION
This instruction book is written for a person
with some mechanical ability. Like most service books, not all the steps are described.
Steps on how to loosen or tighten fasteners are steps anyone can follow with some
mechanical ability. Read and follow these
instructions before you use the unit.
Know your product: If you understand the
unit and how the unit operates, you will get the
best performance. As you read this manual,
compare the illustrations to the unit. Learn
the location and the function of the controls.
To help prevent an accident, follow the operating instructions and the safety rules. Keep
this manual for future reference.
IMPORTANT: Many units are not assembled
and are sold in cartons. It is the responsibility
of the owner to make sure the assembly instructions in the manual are exactly followed.
Other units are purchased in assembled
condition. On assembled units, it is the responsibility of the owner to make sure the
SAFETY RULES
unit is correctly assembled. The owner must
carefully check the unit according to the instructions in this manual before it is fi rst used.
RESPONSIBILITY OF THE OWNER
The responsibility of the owner is to
follow the instructions below.
1. Carefully read and follow the rules for
safe operation.
2. Follow all the assembly and preparation instructions.
3. Inspect the unit.
4. Make sure that the operator of the unit
knows how to correctly use all standard and accessory equipment.
5. Operate the unit only with guards,
shields, and other safety items in place
and working correctly.
6. Correctly adjust the unit.
7. Service the unit only with authorized or
approved replacement parts.
8. Complete all maintenance on the unit.
IMPORTANT: This cutting machine is
capable of amputating hands and feet and
throwing objects. Failure to observe the
following safety instructions could result in
serious injury or death.
Look for this symbol to point out
im por tant safety precautions. It means
CAU TION!!! BECOME ALERT!!!
YOUR SAFE TY IS INVOLVED.
WARNING: In order to prevent ac ci den tal
starting when setting up, trans port ing, ad just ing or making repairs, always dis con nect
spark plug wire and place wire where it can not
come in contact with plug.
WARNING: Engine exhaust, some of its
constituents, and certain vehicle com po nents contain or emit chem i cals known to
the State of Cal i for nia to cause can cer and
birth defects or oth er re pro duc tive harm.
WARNING: Battery posts, terminals and
related accessories contain lead and lead
compounds, chemicals known to the State
of Cal i for nia to cause can cer and birth
defects or oth er re pro duc tive harm. Wash
hands after handling.
CAUTION: Muffl er and
other engine parts become
extremely hot during operation and remain hot after
engine has stopped. To avoid
severe burns on contact,
stay away from these areas.
I. GENERAL OPERATION
• Read, understand, and follow all
in struc tions on the machine and in the
manual(s) before starting. Be thor ough ly
familiar with the controls and the proper
use of the machine before starting.
• Do not put hands or feet near or under
rotating parts. Keep clear of the dis charge opening at all times.
• Only allow responsible individuals, who
are familiar with the in struc tions, to
operate the machine.
• Clear the area of objects such as rocks,
toys, wire, bones, sticks, etc., which
could be picked up and thrown by blade.
• Be sure the area is clear of other people
before mowing. Stop ma chine if anyone
enters the area.
• Do not operate the mower when bare foot or wearing open sandals. Al ways
wear substantial foot wear.
• Do not pull mower backwards unless
absolutely nec es sary. Always look down
and behind before and while moving
backwards.
• Never direct discharged material toward
anyone. Avoid discharging material against
a wall or obstruction. Material may richochet back toward the operator. Stop the
blade when crossing gravel surfaces.
• Do not operate the mower without
proper guards, plates, grass catcher or
oth er safety protective devices in place.
3
• See manufacturer’s instructions for
proper operation and installation of
accessories. Only use accessories approved by the manufacturer.
• Stop the blade(s) when crossing grav el
drives, walks, or roads.
• Stop the engine (motor) whenever you
leave the equip ment, before clean ing
the mower or unclogging the chute.
• Shut the engine (motor) off and wait
until the blade comes to complete stop
before removing grass catcher.
• Mow only in daylight / good artifi cial light.
• Do not operate the machine while under
the infl uence of alcohol or drugs.
• Never operate machine in wet grass.
Always be sure of your footing: keep a
fi rm hold on the handle; walk, never run.
• Disengage the self-propelled mech a nism or drive clutch on mowers so
equipped before starting the engine.
• If the equipment should start to vi brate
abnormally, stop the engine (motor) and
check immediately for the cause. Vibration is generally a warning of trouble.
• Always wear safety goggles or safe ty
glasses with side shields when op er at ing mower.
II. SLOPE OPERATION
Slopes are a major factor related to slip &
fall accidents which can result in severe
injury. All slopes require extra caution. If
you feel uneasy on a slope, do not mow it.
DO:
• Mow across the face of slopes: nev er
up and down. Exercise extreme caution
when changing direction on slopes.
• Remove obstacles such as rocks, tree
limbs, etc.
• Watch for holes, ruts, or bumps. Tall
grass can hide obstacles.
DO NOT:
• Do not trim near drop-offs, ditches or
embankments. The operator could lose
footing or balance.
• Do not trim excessively steep slopes.
• Do not mow on wet grass. Reduced
footing could cause slipping.
III. CHILDREN
Tragic accidents can occur if the op er a tor
is not alert to the presence of children.
Children are often attracted to the ma-
Never
chine and the mowing activity.
sume that children will remain where you
last saw them.
• Keep children out of the trimming area
and under the watchful care of an oth er
re spon si ble adult.
as-
• Be alert and turn machine off if chil dren
enter the area.
• Before and while walking back wards,
down
look behind and
• Never allow children to operate the
machine.
• Use extra care when approaching blind
corners, shrubs, trees, or other objects
that may obscure vision.
for small chil dren.
IV. SAFE HANDLING OF GASOLINE
Use extreme care in handling gasoline.
Gasoline is extremely fl ammable and the
vapors are explosive.
• Extinguish all cigarettes, cigars, pipes
and other sources of ignition.
• Use only an approved container.
• Never remove gas cap or add fuel with
the engine running. Allow engine to
cool before refueling.
• Never refuel the machine indoors.
• Never store the machine or fuel container where there is an open fl ame, spark
or pilot light such as a water heater or
on other appliances.
• Never fi ll containers inside a vehicle, on
a truck or trailer bed with a plastic liner.
Always place containers on the ground
away from your vehicle before fi lling.
• Remove gas-powered equipment from
the truck or trailer and refuel it on the
ground. If this is not possible, then
refuel such equipment with a portable
container, rather than from a gasoline
dispenser nozzle.
• Keep the nozzle in contact with the rim
of the fuel tank or container opening at
all times until fueling is complete. Do
not use a nozzle lock-open device.
• If fuel is spilled on clothing, change
clothing immediately.
• Never overfi ll fuel tank. Replace gas
cap and tighten securely.
V. GENERAL SERVICE
• Never run machine inside a closed area.
• Never make adjustments or repairs with
the engine (motor) running. Dis con nect
the spark plug wire, and keep wire away
from plug to prevent ac ci den tal starting.
• Keep nuts and bolts, especially blade
attachment bolts, tight and keep equipment in good condition.
• Never tamper with safety devices. Check
their proper operation reg u lar ly.
• Keep machine free of grass, leaves, or
other debris build-up. Clean oil or fuel spillage. Allow machine to cool before storing.
• Stop and inspect the equipment if you
strike an object. Repair, if nec es sary,
before restarting.
4
• Never attempt to make wheel height
adjustments while the engine is running.
• Grass catcher components are sub ject to
wear, dam age, and de te ri o ra tion, which
could expose moving parts or allow objects
to be thrown. Frequently check com po nents and replace with man u fac tur er’s
• Mower blades are sharp and can cut.
Wrap the blade(s) or wear gloves, and
use extra caution when ser vic ing them.
• Do not change the engine governor setting or overspeed the engine.
• Maintain or replace safety and instruction labels, as necessary.
recommended parts, when necessary.
WARNING: This lawn mower is equipped with an internal com bus tion engine and should
not be used on or near any un im proved forest-covered, brush-covered or grass-cov ered
land unless the engine’s exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any). If a spark arrester is used, it should be maintained
in effective working order by the operator. In the state of California the above is required
by law (Section 4442 of the California Public Resources Code). Other states may have
similar laws. Federal laws apply on federal lands. A spark arrester for the muffl er is
available through your nearest authorized service center.
PRODUCT SPECIFICATIONS
Gasoline Capacity / Type: 1.0 Quarts (0,94 Litres) Unleaded Regular
Oil Capacity: 20 Ounces (0,58 Litres)
Oil Type (API SG–SL): SAE 30 (above 0°C/32°F); SAE 5W-30 (below 0°C/32°F)
Spark Plug: Champion RJ19LM (Gap: 0.30" / 0,76 mm)
Blade Bolt Torque: 35-40 ft. lbs. (47-54 N-m)
ASSEMBLY / PRE-OPERATION
Read these instructions and this manual in
its entirety before you attempt to assemble
or operate your new lawn mower.
IMPORTANT: This lawn mower is shipped
WITHOUT OIL OR GASOLINE in the engine.
Your new lawn mower has been as sem bled
at the factory with the exception of those
parts left unassembled for shipping purposes.
All parts such as nuts, washers, bolts, etc.,
nec es sary to complete the as sem bly have
been placed in the parts bag. To ensure safe
and proper operation of your lawn mower, all
parts and hard ware you assemble must be
tightened securely. Use the correct tools as
necessary to ensure proper tightness.
TO REMOVE MOWER FROM CAR TON
1. Remove loose parts included with mower.
2. Cut down two end corners of carton
and lay end panel down fl at.
3. Remove all packing materials except
padding between upper and lower
handle and padding holding operator
presence control bar to upper handle.
4. Roll lawn mower out of carton and
check carton thor ough ly for additional
loose parts.
HOW TO SET UP YOUR MOW ER
TO UNFOLD HANDLE
IMPORTANT: Unfold handle carefully so
as not to pinch or damage con trol cables.
1. Raise handles until lower handle section locks into place in mowing position.
2. Remove protective padding, raise upper handle sec tion into place on lower
handle and tighten both handle knobs.
3. Remove handle padding holding operator
pres ence control bar to upper handle.
Your lawn mower handle can be adjusted
for your mowing comfort. Refer to “AD JUST HANDLE” in the Service and Adjustments section of this manual.
Operator
presence
control bar
LIFT
UP
LIFT
UP
MOWING
POSITION
handle
Handle
Lower handle
TO INSTALL ATTACHMENTS
Your lawn mower was shipped ready to be
used as a mulcher. To convert to discharging, see “TO CON VERT MOW ER” in
the Operation section of this man u al.
5
Upper
knob
Loading...