Page 1
Installation Instructions
Tailgate Lock PL3600 Dodge DAKOTA 1997 - 2011
Mitsubishi Raider 2006 & Up
Contents:
Lock Assembly, 2 keys
1/4-20 One-Way Screw
1/4-20 Hex Head Bolt
Large Washer (‘97 - ‘04)
Large ‘V’ Notched Washer (‘05 & Up)
Instructions, Warranty Card
Tools Required:
#40 Torx Driver
Screw Driver
Tech Support:
Call 1-800-342-5911
1.
Lower the tailgate.
Remove the center bolt and loosen
the other two bolts.
For the latest instructions please
visit www.popandlock.net
2.
Lift the handle and insert the
POP&LOCK between the handle
and the plastic insert.
This is a tight fit and it helps to
loosen the handle bolts.
NOTE: POP&LOCK is designed to secure the passenger side latch. You may experience that the driver’s
side latch can open due to the flex in the handle, but
the tailgate will still remain locked.
If the tailgate should open, an adjustment is required to
the rods that run from the handle to the latches.
Remove the rod on the driver’s side from the latch side of
the tailgate. Once removed, the rod will be in the shape
of a ‘Z’. Straighten out BOTH bends by a few degrees,
effectively lengthening the rod and re-install. The
Pop&Lock should now secure the tailgate.
3.
Slide the POP&LOCK into place all
the way to the right side.
4.
Place the 1/4-20 hex bolt with the
appropriate washer into the rear
and screw it into the POP&LOCK.
Insert a screw driver in the slot
between the handle and the
POP&LOCK to spread them apart
as you tighten all the bolts.
12-27-11
Note: Do not over-tighten screws.
Page 2
POP & LOCK™ LIMITED WARRANTY FORM
Please complete and mail this form to record your warranty with the manufacturer.
NAME _______________________________________
ADDRESS_____________________________________
CITY_________________________________________
STATE________ZIP_________________
TELEPHONE #_________________________________
EMAIL ADDRESS ______________________________
POP & LOCK™ MODEL ________________________
VEHICLE YEAR ____________
VEHICLE MAKE/MODEL _______________________
REASON FOR RETURN (continue on other side):
Please Mail Completed Warranty Form (below) In Self Addressed Envelope To:
POP & LOCK LLC 1271 CONTRACT DRIVE GREEN BAY, WI USA 54304
Additional Install Instructions and answers to technical questions can be found on our website at www.popnlock.net or by calling
Technical Support 1-800-342-5911
Monday – Friday 8am to 5pm CST
LIMITED WARRANTY TERMS AND CONDITIONS
(1) Installation. Pop & Lock™, LLC (and Pop & Lock™ Corporation) is not responsible for installing the Pop & Lock™ or for the
harm suffered by any person as a result installing it.
(2) Warranties.
a. Customer acknowledges that it is unreasonable to believe that any device whatever will prevent a theft in the case
of every attempt and that the most that can be expected from a so-called anti-theft or security device is that it will
deter many thieves.
b. POP & LOCK™ LLC. (and Pop & Lock™ Corporation) MAKES, AND CUSTOMER RECEIVES, NO WARRANTY,
EXPRESSED OR IMPLIED, EXCEPT THE WARRANTIES OF TITLE TO THE POP & LOCK™ AND THEIR
MERCHANTABILITY, PARTICULARILY NO WARRANTY OF FITNESS FOR A PARTICULAR USE OR PURPOSE OR
AGAINST INFRINGEMENT.
c. As Customer’s only remedy, Pop & Lock™, LLC (and Pop & Lock™ Corporation) will repair or replace, at its option
and without charge, any lock that is defective in material or workmanship when received by Customer and is
returned to Pop & Lock™ LLC (and Pop & Lock™ Corporation), FOB Pop & Lock™ Corporation’s offices, within one
(1) year after it’s receipt by the Customer. Pop & Lock LLC will ship all replacement, or repaired, Locks to
Customer, FOB Pop & Lock™’s shipping point.
d. Factory support is only available for Pop & Lock™ products purchased as new through an Authorized Pop & Lock™
dealer.
Please Note: Pop & Lock™ Products purchased on auction sites such as Ebay, Amazon and Craigslist, to name a
few, will not be covered under factory warranty under any circumstance. Pop & Lock™, LLC (and Pop & Lock™
Corporation) is unable to verify whether products sold through Auction Sites are new, used, or refurbished, and
as such, Pop & Lock, LLC (and Pop & Lock™ Corporation) is unable to warranty such purchases. Pop & Lock, LLC
advises using extreme caution when buying through auction sites as you'll be doing so at your own risk.
(3) No Liability. Pop & Lock™ Corporation is not liable for any loss or damage claimed by Customer or any third person to have
been suffered or incurred as a result or, or related to, the Locks purchased under this Agreement, regardless of the
circumstances or form of action, except any bodily injury or death for which Pop & Lock™ is liable under products-liability
law. Without limiting the generality of the foregoing, in no event will Pop & Lock™ LLC be liable to Customer for any
indirect, special, or consequential damages, regardless of the circumstances or the cause of action, particularly not for the
value of a vehicle, or any other money damages in the event that a tailgate is stolen either notwithstanding the use of a Pop
& Lock™ or when it has been returned for repair or replacement.
END OF TERMS AND CONDITIONS
Loading...