Polar Refrigeration G604-A, G605-A Instruction Manual

Model:

G604-A / G605-A

Stainless Steel Pizza
Salad Prep/Saladette
Counter

Instruction manual

G604-A_G605-A_A5_v3_20181010.indb 1 2018/10/10 14:42

2

AU

Telephone Helpline: 1300225960

Safety Tips

• Position on a flat, stable surface.

• A service agent/qualified technician should carry out
installation and any repairs if required. Do not remove any
components or service panels on this product.

• Consult Local and National Standards to comply with the
following:

- Health and Safety at Work Legislation

- Fire Precautions

- Wiring Regulations

- Building Regulations

• DO NOT use jet/pressure washers to clean the appliance.

• DO NOT use the appliance outside.

• DO NOT use this appliance to store medical supplies.

• DO NOT use electrical appliances inside the appliance
(e.g. heaters, ice cream makers etc.)

• DO NOT stand or support yourself on the base, drawers or
doors.

• DO NOT allow oil or fat to come into contact with the plastic
components or door seal. Clean immediately if contact occurs.

• Bottles that contain a high percentage of alcohol must be
sealed and placed vertically in the refrigerator.

• Always carry, store and handle the appliance in a vertical
position and move by holding the base of the appliance.

• Always switch off and disconnect the power supply to the unit
before cleaning.

• Keep all packaging away from children. Dispose of the
packaging in accordance with the regulations of local
authorities.

• If the power cord is damaged, it must be replaced by a POLAR
agent or a recommended qualified technician in order to avoid
a hazard.

G604-A_G605-A_A5_v3_20181010.indb 2 2018/10/10 14:42

3

AUAU

Telephone Helpline: 1300225960

• This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience or knowledge, unless they have been
given supervision or instruction concerning the use of the
appliance by a person responsible for their safety.

• Polar recommend that this appliance is PAT tested on an
annual basis to ensure the product remains safe.

Caution Risk of Fire

• Do not store explosive substances such as aerosol cans with a
flammable propellant in this appliance.

Warning: Keep all ventilation openings clear of
obstruction. Unit should not be boxed in without
adequate ventilation.

• Warning: Do not use mechanical devices or other means
to accelerate the defrosting process, other than those
recommended by the manufacturer.

• Warning: Do not damage the refrigerant circuit.

• Warning: Do not use electrical appliances inside the food
storage compartments of the appliance, unless they are the
type recommended by the manufacturer.

Product Description

G604-A - POLAR 2 Door Pizza/Salad Prep Counter Refrigerator
G605-A - POLAR 3 Door Pizza/Salad Prep Counter Refrigerator

Introduction

Please take a few moments to carefully read through this manual. Correct maintenance and operation of
this machine will provide the best possible performance from your POLAR product.

G604-A_G605-A_A5_v3_20181010.indb 3 2018/10/10 14:42

4

AU

Telephone Helpline: 1300225960

Pack Contents

The following is included:

• POLAR Refrigerator

• Shelf guides

• Shelves (G604-A x 2, G605-A x 3)

• Gastronorm Adaptor Bars

• Floor guards (G604-A x 3, G605-A x 4)

• Instruction manual

POLAR prides itself on quality and service, ensuring that at the time of packaging the contents are
supplied fully functional and free of damage.

Should you find any damage as a result of transit, please contact your POLAR dealer immediately.

Installation

Note: If the unit has not been stored or moved in an upright position, let it stand
upright for approximately 12 hours before operation. If in doubt allow to stand.

1. Remove the appliance from the packaging. Make sure that all protective plastic film and coatings are
thoroughly removed from all surfaces.

2. Maintain a distance of 20cm (7 inches) between the unit and walls or other objects for ventilation.

NEVER LOCATE NEXT TO OR NEAR A HEAT SOURCE.

Note: Before using the appliance for the first time, clean the shelves and interior
with soapy water.

3. Set the brakes on the castors to keep the appliance in position
OR
Level the appliance by adjusting the screw feet.

Fitting the Shelves & Floor Guards

1. Place one set of shelf guides on either side of the cabinet at the desired height.

2. Slide the shelf into place.

3. Repeat for the remaining shelves.

4. Place the floor guards on the floor of the cabinet, ensuring the flat side is clear of the floor.

Note: This is vital for ensuring correct drainage of condensation.

G604-A_G605-A_A5_v3_20181010.indb 4 2018/10/10 14:42