Polaris Shademaker Astral-TC Series Owner's Manual

T O P R O P E R L Y F O L D C A N O P Y

The 100% solution dyed canopy will last longer if you fold it as it was packed and
shipped. This technique is similar to the way a parachute is folded and is especially
important when folding the canopy for seasonal storage or when left in the closed
position for an extended period of time.

Using this technique at all times will significantly extend the life of the canopy.

1. When the canopy has been fully lowered, stand in front of the canopy structure
and begin the folding process by pulling out two panels opposite the mast.
Pull the two panels together and roll tight into the canopy.

2. Once rolled tight, pull adjacent panels out one at a time and fold to the center,
alternating sides until all the panels have been pulled out from the arms and folded
into the center.

3. Strap the canopy to the mast with the strap.

P R O T E C T I V E C O V E R

1. Screw rods together and insert into slit of the cover.

2. Unzip cover.

3. Using the rod as a guide, slide cover over your umbrella.

4. Pull on string to zip down your cover and tie.

M A I N T A I N I N G F R A M E & F I T T I N G S

1. Hose frame with water periodically, more often if installation is in a salty or industrial
environment.

2. Inspect the installation fitting on a regular basis and tighten if necessary.

M A I N T A I N I N G C A N O P Y F A B R I C

1. Clean up spills and stains right away. Spills can be removed by using a clean,
absorbent cloth.

2. For general maintenance, use a soft brush to remove dust and dry soil or wash
down with clean, warm water (i.e. garden hose) every so often so dirt does not
become engrained. Allow the fabric to dry naturally before closing the canopy.

3. If a thorough cleaning is necessary, sponge over the fabric using a mild soap
solution (2% solution). Rinse well with plenty of water to remove all soap residue.

4. Never use detergents, cleaning fluids, or solvents. Grease and oil stains may be
removed by using turpentine or similar with an absorbent cloth.

5. We recommend giving the canopy a good clean on a more frequent basis if
installed in a location where the canopy is likely to become soiled.

R E M O V A L & R E P L A C E M E N T O F C A N O P Y

Follow these instructions should you choose to replace your canopy with a new canopy.

1. Lower the canopy to the closed position.

2. Remove the button/screw at the end of each arm.

3. Remove canopy from structure.

4. To replace the canopy, reverse the above process.

W A R R A N T Y :

Upon receipt of your Polaris, please check to ensure you have received all of the parts.

Our Limited Warranty is outlined below by individual styles.

5 Year Limited Warranty

includes the Polaris, Sirius, Astral-TC, Libra and Nova styles.
This includes the mast, arms, ribs, center pole, top and bottom hubs and stainless steel
hardware only. If there is damage under the warranty, Shademaker will replace and/or
repair any item listed in this category at its discretion. The 5 Year Limited Warranty
applies to Sunbrella Firesist

®

, Sunbrella Firesist®PLUS and Sunbrella®Furniture Grade

fabrics. Visit www.sunbrella.com/warranty for more details.

10 Year Limited Warranty

includes the Sunbrella

®

Awning & Marine Grade Fabric
Collection. Visit www.sunbrella.com/warranty for more details. Labor charges are not
covered under this limited warranty.

5 Year Limited Warranty

also applies to O’bravia™ Awning Grade fabrics. Labor

charges are not covered under this limited warranty.

1 Year Limited Warranty

covers the powder coat finish on our steel bases. If the
powder coat finish flakes, bubbles, peels or loses color; Shademaker will re-finish or
replace the defective bases at its discretion. Normal wear and tear is not covered under
this limited warranty.

Exclusions:

Wind damage, acts of nature (such as, but not limited to, freezing or any
type of extreme weather.) Normal wear and tear and failures caused by abusive use are
not covered under this warranty.

Parts can be ordered under warranty at no charge, if found that the damage is a
manufacture defect and/or purchased out of warranty to make them whole again.

Those filing warranty claims will be responsible for all shipping, handling and freight
charges on all claims to Shademaker in Baldwin Park, CA. All warranty claims must be
submitted with the original proof of purchase, date of purchase, name of dealer and the
description of the damage. An authorized Shademaker RA# must be listed on all
products being returned. The Shademaker warranty is not transferable. Shademaker
reserves the right to repair, replace and/or redesign any product that is returned under a
warranty claim.

.125”

.10”

3.125”

Arm

Mast

2

ASTRAL-TC 3.5m / 11’5” 4.0m / 13’1” 5.0m / 16’4” 5.0m / 16’4”
Shape Square Square Square Octagon

A

Hub Height 7’1” 7’ 6’8” 7’1”

B

Arms Height 7’5” 7’4” 7’5” 7’5”

C

Canopy Width 11’5” 13’1” 16’4” 15’2”

D

Overall Height (Opened) 9’2” 9’4” 9’6” 9’2”
Overall Height (Closed) 11’5” 12’ 13’3” 12’3”

E

Crank Handle Height 2’8” 2’8” 2’4” 2’8”

Weight: Approximately 128-150 lbs.
Mast Shape & Diameter: 3.125” round
Wall Thickness of Mast: .10”
Arm Wall Thickness: .125”

A

B

C

D

I M P O R T A N T :
Please read this entire manual before installing or operating your Astral-TC
umbrella.

A S T R A L - T C W I N D R E S I S T A N C E G U I D E L I N E S :

Moderate to Strong Winds (when mounted)

When installed properly, the Astral-TC is engineered to handle strong wind conditions in the
open canopy position. Please adhere to these common sense wind guidelines:

1. As winds get stronger, or as gusts increase, the canopy should be lowered to the
folded and strapped position.

2. If unattended for an extended period of time, the Astral-TC should be left in the folded
and strapped position.

3. In anticipation of, and during extremely severe weather conditions, it is advisable to
remove and store the entire Astral-TC structure to protect it from storm-related debris.

E

S P E C I F I C A T I O N S