Polar Electro G596-A, G598-A, G599-A, DL914-A, G600-A Instruction Manual

...

Download

Model:

G596-A/G597-A/G598-A/G599-A/G600-A/

DL914-A/DL915-A/DL916-A/DL917-A

Stainless Steel Counter Refrigerators/Freezers

Instruction manual

G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 1 2017/8/2 14:29

Telephone Helpline: 1300225960

Safety Tips

• Position on a flat, stable surface.

• A service agent/qualified technician should carry out installation and any repairs if required. Do not remove any components or service panels on this product.

• Consult Local and National Standards to comply with the following:

- Health and Safety at Work Legislation

- Fire Precautions

- Wiring Regulations

- Building Regulations

• DO NOT use jet/pressure washers to clean the appliance.

• DO NOT use the appliance outside.

• DO NOT use this appliance to store medical supplies.

• DO NOT use electrical appliances inside the appliance (e.g. heaters, ice cream makers etc.)

• DO NOT stand or support yourself on the base, drawers or doors.

• DO NOT allow oil or fat to come into contact with the plastic components or door seal. Clean immediately if contact occurs.

• Bottles that contain a high percentage of alcohol must be sealed and placed vertically in the refrigerator.

• Always carry, store and handle the appliance in a vertical position and move by holding the base of the appliance.

• Always switch off and disconnect the power supply to the unit before cleaning.

• Keep all packaging away from children. Dispose of the packaging in accordance with the regulations of local authorities.

• If the power cord is damaged, it must be replaced by a POLAR agent or a recommended qualified technician in order to avoid a hazard.

G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 2 2017/8/2 14:29

UKAUAU

Telephone Helpline: 1300225960

• This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience or knowledge, unless they have been given supervision or instruction concerning the use of the appliance by a person responsible for their safety.

• Polar recommend that this appliance is PAT tested on an annual basis to ensure the product remains safe.

Caution Risk of Fire

• Do not store explosive substances such as aerosol cans with a flammable propellant in this appliance.

Warning: Keep all ventilation openings clear of obstruction. Unit should not be boxed in without adequate ventilation.

• Warning: Do not use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer.

• Warning: Do not damage the refrigerant circuit.

• Warning: Do not use electrical appliances inside the food storage compartments of the appliance, unless they are the type recommended by the manufacturer.

Product Description

G596-A - POLAR 282 litre 2 Door Counter Refrigerator G597-A - POLAR 417 litre 3 Door Counter Refrigerator G598-A - POLAR 563 litre 4 Door Counter Refrigerator G599-A - POLAR 282 litre 2 Door Counter Freezer G600-A - POLAR 417 litre 3 Door Counter Freezer DL914-A - Polar Counter GN REFRIGERATOR - 2 Doors 700mm with upstand DL915-A - Polar Counter GN REFRIGERATOR - 3 Doors 700mm with upstand DL916-A - Polar Counter GN FREEZER - 2 Doors 700mm with upstand DL917-A - Polar Counter GN FREEZER - 3 Doors 700mm with upstand

G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 3 2017/8/2 14:29

Telephone Helpline: 1300225960

Introduction

Please take a few moments to carefully read through this manual. Correct maintenance and operation of this machine will provide the best possible performance from your POLAR product.

Pack Contents

The following is included:

• POLAR Refrigerator or Freezer

• Shelf guide (2 per door)

• Shelf (1 per door)

• Instruction manual

POLAR prides itself on quality and service, ensuring that at the time of packaging the contents are supplied fully functional and free of damage.

Should you find any damage as a result of transit, please contact your POLAR dealer immediately.

Installation

Note: If the unit has not been stored or moved in an upright position, let it stand upright for approximately 12 hours before operation. If in doubt allow to stand.

1. Remove the appliance from the packaging. Make sure that all protective plastic film and coatings are thoroughly removed from all surfaces.

2. Maintain a distance of 20cm (7 inches) between the unit and walls or other objects for ventilation. NEVER LOCATE NEXT TO OR

NEAR A HEAT SOURCE.

Note: Before using the appliance for the first time, clean the shelves and interior with soapy water.

3. Set the brakes on the castors to keep the appliance in position.

Fitting the Shelves & Floor Guards

1. Place one set of shelf guides on either side of the cabinet at the desired height.

2. Slide the shelf into place.

3. Repeat for the remaining shelves.

4. Place the floor guards on the floor of the

cabinet, ensuring the flat side is clear of the floor.

Note: This is vital for ensuring correct drainage of condensation.

Operation

Storing Food

To get the best results from your POLAR appliance, follow these instructions:

• Only store foodstuffs in the appliance when it has reached the correct operating temperature.

• Do not place uncovered hot food or liquid inside the appliance.

• Wrap or cover food where possible.

• Do not obstruct the fans inside the appliance.

• Avoid opening the doors for prolonged periods of time.

Turn On

1. Ensure the power switch is set to [O] and turn on at the socket.

2. Switch on the Power [I]. The current temperature within the appliance is displayed.

Control Panel

Set the Operating Temperature

1. Hold the SET button for 3 seconds. The value of the current set point will be displayed.

2. Press the or buttons to display the required temperature.

3. Press the SET button to store the temperature.

Manual Defrost

• The appliance will automatically run a defrost cycle every six hours.

• To manually defrost the appliance: Press and hold the defrost button "aux" for 2 seconds to begin a manual defrost. The defrost light illuminates.

G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 4 2017/8/2 14:29

UKAUAU

Telephone Helpline: 1300225960

Cleaning, Care & Maintenance

Defrost appliance at least every 3 months, more often if required.

Switch off and disconnect from the power supply before cleaning.

• Clean the interior of the appliance as often as possible.

• Do not use abrasive cleaning agents. These can leave harmful residues.

• Clean the door seal with warm soapy water.

• Always wipe dry after cleaning.

• Do not allow water used in cleaning to run through the drain hole into the evaporation pan.

• Take care when cleaning the rear of the appliance. Sharp edges can cut.

• A POLAR agent or qualified technician must carry out repairs if required.

Stainless Steel Care

To maintain the stainless steel exterior of your Polar item, please consider the following information:

Never:

• Use abrasive Scourers or scrubbing pads, etc.

• Use Chlorinated or acidic detergents

• Allow anything e.g. food, dirt, cleaning chemicals to remain on the surface for longer than necessary, clean them off right away.

• Allow the surface to remain wet.

Do:

• Clean often.

• Use soft Cloths or plastic Scourers.

• Rub with the grain of the metal, rather than across it.

• Use detergents and polish designed for cleaning Stainless Steel.

• Ensure that the cleaning products are washed off fully and that the steel is left dry.

Routine Maintenance

Condenser Cleaning

• The condenser is part of the refrigeration system. The condenser requires monthly cleaning.

• Always disconnect power supply before carrying out Routine Maintenance.

• Failure to clean the condenser will reduce the performance and life of your Polar unit and may invalidate your warranty

• The condenser is located behind the service door on the right-hand side of the refrigeration cabinet.

• These models have a removable filter which can be cleaned with a vacuum cleaner.

G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 5 2017/8/2 14:29

Telephone Helpline: 1300225960

Troubleshooting

If your POLAR appliance develops a fault, please check the following table before making a call to the Helpline or your POLAR dealer.

Fault Probable Cause Solution

The appliance is not working

The unit is not switched on Check the unit is plugged in correctly and

switched on

Plug and lead are damaged Call POLAR agent or qualified Technician

Fuse in the plug has blown Replace the fuse

Power supply Check power supply

Internal wiring fault Call POLAR agent or qualified Technician

The appliance turns on, but the temperature is too high/low

Too much ice on the evaporator Defrost the appliance

Condenser blocked with dust Clean the Condenser

Doors are not shut properly Check doors are shut and seals are not

damaged

Appliance is located near a heat source or air flow to the condenser is being interrupted

Move the refrigerator to a more suitable location

Ambient temperature is too high Increase ventilation or move appliance to a

cooler position

Unsuitable foodstuffs are being stored in the appliance

Remove any excessive hot foodstuffs or blockages to the fan

Appliance is overloaded Reduce the amount of food stored in the

appliance

The appliance is leaking water

The appliance is not properly levelled

Adjust the screw feet to level the appliance (if applicable)

The discharge outlet is blocked Clear the discharge outlet

Movement of water to the drain is obstructed

Clear the floor of the appliance (if applicable)

The water container is damaged Call POLAR agent or qualified Technician

The drip tray is overflowing Empty the drip tray (if applicable)

The appliance is unusually loud

Loose nut/screw Check and tighten all nuts and screws

The appliance has not been installed in a level or stable position

Check installation position and change if necessary

G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 6 2017/8/2 14:29

UKAUAU

Telephone Helpline: 1300225960

Technical Specifications

Model Voltage Power Current Temperature Range

Capacity

(litres)

G596-A 230V 50Hz 350W 1.95A -2°C to 10°C 282

G597-A 230V 50Hz 350W 1.95A -2°C to 10°C 417

G598-A 230V 50Hz 350W 1.95A -2°C to 10°C 563

G599-A 230V 50Hz 750W 3.5A -10°C to -20°C 282

G600-A 230V 50Hz 750W 3.55A -10°C to -20°C 417

DL914-A 230V 50Hz 350W 1.95A -2°C to 10°C 282

DL915-A 230V 50Hz 350W 1.95A -2°C to 10°C 417

DL916-A 230V 50Hz 750W 3.5A -10°C to -20°C 282

DL917-A 230V 50Hz 750W 3.5A -10°C to -20°C 417

Model Refrigerant

Dimensions

H x W x D mm

Weight

(kg)

G596-A R134a 230g 850 x 1360 x 700 98

G597-A R134a 230g 850 x 1790 x 700 134

G598-A R134a 250g 850 x 2230 x 700 153

G599-A R404a 300g 850 x 1360 x 700 98

G600-A R404a 300g 850 x 1790 x 700 136

DL914-A R134a 230g 960 x 1360 x 700 98

DL915-A R134a 230g 960 x 1795 x 700 134

DL916-A R404a 230g 960 x 1360 x 700 103

DL917-A R404a 230g 960 x 1795 x 700 136.5

G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 7 2017/8/2 14:29

Telephone Helpline: 1300225960

Electrical Wiring

The plug is to be connected to a suitable mains socket.

This appliance is wired as follows:

• Live wire (coloured brown) to terminal marked L

• Neutral wire (coloured blue) to terminal marked N

• Earth wire (coloured green/yellow) to terminal marked E

The appliances must be earthed.

If in doubt consult a qualified electrician.

Electrical isolation points must be kept clear of any obstructions. In the event of any emergency disconnection being required they must be readily accessible.

Compliance

The WEEE logo on this product or its documentation indicates that the product must not be disposed of as household waste. To help prevent possible harm to human health and/or the environment, the product must be disposed of in an approved and environmentally safe recycling process. For further information on how to dispose of this product correctly, contact the product supplier, or the local authority responsible for waste disposal in your area.

POLAR parts have undergone strict product testing in order to comply with regulatory standards and specifications set by international, independent, and federal authorities.

POLAR products have been approved to carry the following symbol:

mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR.

Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserve the right to

change specifications without notice.

G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 8 2017/8/2 14:29