Philips HX8240, HX8281, HX8241, HX8211, HX8140 Service Manual

Sonicare AirFloss

AirFloss
HX8111, AirFloss Retail
HX8181, AirFloss Dental Prof
HX8141, AirFloss Pro Disp
HX8140, AirFloss Handle

AirFloss 1.5
HX8211, AirFloss Retail
HX8241, AirFloss Dental Prof
HX8281, AirFloss Pro Disp
HX8240, AirFloss 1.5 Handle

4235-006-32611-671_13-08-02
(YY_MM_DD)

Philips Consumer Lifestyle

Service Manual

SERVICE POLICY

Warranty for this product is 2 years after purchase. The product
will be serviced for 3 years after End of Life.

PRODUCT INFORMATION

Using

AirFloss is designed to be used on the outside of the teeth. Place
the tip between teeth and apply gentle pressure. Press activation
button to deliver a burst of air and water. Glide the guidance tip
along the gum line until you feel it settle between the next two
teeth. Press the activation button again and repeat for all spaces
including behind your back teeth. Press power on/off button to
turn power off after use.

Charging

Charge for 24 hours before first use. Charge indicator fl ashes
green until fully charged. Rapid yellow flashing indicates charge
is extremely low (fewer than 3 uses left). AirFloss is designed to
last 2 weeks (or 14 uses) on a single charge. The charger that
comes in the finished good configuration is not compatible with
previous Sonicare toothbrush models. The service charger is
compatible with both previous Sonicare toothbrush models as
well as the AirFloss handle. The AirFloss handle is compatible
with previous FlexCare chargers but not DiamondClean or e­series.

Low Battery Warning - Yellow Indicator Flashes when
Approximately 90 Activations Remain (90 Activations = 3
Uses)

Full Battery Indication - Solid Green light appears after
appliance is fully charged.
Note: After 4 minutes the green light will turn off to conserve

battery life.

Attaching the Nozzle and filing the reservoir

attach nozzle and fill reservoir with water or mouthwash as
shown below.

Priming the device

After filling the reservoir, press the power on/off button to turn
on, then press the activation button approximately 6 times or
until spray is produced.

Cleaning - Remove the nozzle and rinse with water. Use a
cotton-tipped swab to wipe down the reservoir, if desired. Avoid
getting foreign objects inside. The use of cleaning agents inside
the device is not recommended. Do not clean in the dishwasher
or any other sanitizing devices.

Storing

If AirFloss will not be used for an extended period of time,
empty water from reservoir, press activation button until no
spray is produced, unplug the charger, clean the product, and
store it in a cool, dry place away from direct sunlight.

Servicing
Replace the nozzle every 6 months for optimal results.

Published by Philips Consumer Lifestyle Printed in the Netherlands © Copyright Reserved Subject to modification

HX8111, HX8181,
HX8141, HX8140
HX8211, HX8241 ,
HX8281, HX8240

4235-006-32611-671_13-08-02

(YY_MM_DD)

2-5

SAFETY INFORMATION

• Consult your dental professional before you use this
product if you have had oral or gum surgery in the
previous two (2) months.

• Contact your dental professional if excessive bleeding
occurs after using this product or bleeding continues to
occur after one (1) week of use.

• Discontinue use of this product and contact a physician/
dentist if discomfort or pain is experienced.

• This product complies with the safety standards for
electromagnetic devices. If you have a pacemaker or other
implanted device, contact your physician or the device
manufacturer prior to use.

• Consult your physician if you have other medical
concerns.
To reduce the risk of burns, electrocution, fire, or physical
injury:

• DO NOT use alcohol or other cleaning fluids in the
reservoir as it may be an ingestion hazard.

• DO NOT use attachments other than those recommended by the
manufacturer.

• DO NOT plug the charger into an outlet with a voltage

other than specified on the bottom of the charger.

This product is designed to operate within a range of
100 to 240 volts. Voltage converters DO NOT guarantee voltage
compatibility

• DO NOT use hot water so as to avoid physical injury.

• DO NOT use the charger outdoors.

• DO NOT drop

• Never force the plug into an outlet; if the plug does not

easily fit into the outlet, discontinue use.

• Keep the cord away from heated surfaces.

• Discontinue use if the nozzle, body, or charger body /
cord appear damaged in any way. Refer to “Warranty and
Service” for service or repair.

• This product contains no user-serviceable parts. Refer
to “Warranty and Service” if AirFloss no longer works

properly or needs repair.

• Use this product only for its intended use as described
in this document or as recommended by your dental
professional.

• This product is not intended for use by persons
(including children) with reduced physical, sensory, or
mental capabilities, or lack of experience and knowledge,
unless they have been given supervision or instruction
concerning use of the appliance by a person responsible
for their safety.

• Children should be supervised to ensure that they do not
play with the appliance.

• AirFloss is a personal care device and is not intended for
use on multiple patients in a dental office or institution.

• Do not direct the spray under the tongue or into the ear,
nose, eye, or other sensitive areas. See “Using AirFloss”

for correct usage.

• Avoid applying excessive nozzle tip pressure.

TECHNICAL INFORMATION

Charger Electrical Ratings

Operating Voltage: 100 – 240 V~
Operating Frequency: 50 / 60 Hz
Power Consumption: 0.4 – 1.4 W

AirFloss Electrical Ratings

Battery Type: Lithium-Polymer
Voltage: 3.7 V
Capacity: 630 mAh
Power consumption: 6 W

REPAIR INSTRUCTIONS

- Nozzle and Guidance tip (pos A& B)

In case of a defective Nozzle or tip, the complete Nozzle must
be replaced.

- Water reservoir cover (pos D)

If the reservoir cover is lost or no longer closes, it can be
replaced.

- Handle (pos E)

The batteries inside cannot be replaced. In case of a defect, the
handle only must be replaced.

- Charging unit (pos I)

In case of a defective charging unit or cordset, the charger must
be replaced. The charger that comes in the finished good
configuration, as shown below, is not compatible with previous
Sonicare toothbrush models. The AirFloss service charger is
compatible with both previous Sonicare toothbrush models as
well as the AirFloss handle. The AirFloss handle is compatible
with previous FlexCare chargers but not DiamondClean or
e-series chargers.

- Charging the handle (pos I)

The handle should be charged for at least 24 hours during the
first few days of use.