Stainless Steel Condensing Boiler
USERS’ INFORMATION MANUAL
TO THE BOILER OWNER: READ THIS MANUAL IMMEDIATELY AFTER THIS BOILER IS
PLACED IN SERVICE AND RETAIN IT FOR FUTURE REFERENCE.
WARNING
If the information in this manual is not
followed exactly, a fire or explosion may
result causing property damage, personal
injury or loss of life.
-Do not store gasoline or other flammable
vapors and liquids in the vicinity of this or
any
other appliance.
-What to do if you smell gas:
Do not try to light any appliance•
Do not touch any electrical switch; •
do not use any phone in your building.
Immediately call your gas supplier •
from a neighbor’s phone. Follow the
gas supplier’s instructions.
If you cannot reach your gas sup-•
plier, call the fire department.
-Installation and service must be performed
by a qualified installer, service agency or
the gas supplier.
105313-01 - 6/14
AVERTISSEMENT
Assurez-vous de bien suivre les instructions données dans cette notice pour
réduire au minimum le risque d’incendie ou
d’explosion ou pour éviter tout dommage
matériel, toute blessure ou la mort.
- Ne pas entreposer ni utiliser d’essence ni
d’autres vapeurs ou liquides inflammables
dans le voisinage de cet appareil ou de tout
autre appareil.
QUE FAIRE SI VOUS SENTEZ UNE
ODEUR DE GAZ:
Ne pas tenter d’allumer d’appareils.•
Ne touchez à aucun interrupteur. Ne •
pas vous servir des téléphones dans le
bâtiment où vous vous trouvez.
Appelez immédiatement votre fournis-•
seur de gaz depuis un voisin. Suivez
les instructions du fournisseur.
Si vous ne pouvez rejoindre le four-•
nisseur de gaz, appelez le service des
incendies.
L’installation et D’entretien doivent être
assuréx par un installateur ou un service
d’entretien qualifié ou par le fournisseur de
gaz.
The following terms are used throughout this manual to bring attention to the presence of various risk levels
DANGER
Indicates an imminently hazardous
situation which, if not avoided, will result in
death, serious injury or substantial property
damage.
CAUTION
Indicates a potentially hazardous situation
which, if not avoided, may result in
moderate or minor injury or property
damage.
I. General Information
This manual covers the proper care and use of the Phantom Condensing High Efciency Gas Fired Boiler.1.
Instructions to safely operate and shut down this boiler are shown in Figure 1 of this manual, as well as on a label afxed to 2.
the boiler.
WARNING
Indicates a potentially hazardous situation
which, if not avoided, could result in death,
serious injury or substantial property
damage.
NOTICE
Indicates special instructions on
installation, operation, or maintenance
which are important but not related to
personal injury hazards.
DANGER
There are no user serviceable parts on this boiler. Attempts to service this boiler by someone
other than a qualified gas service technician could void the warranty, cause property damage,
personal injury or loss of life.
CAUTION
Do not use this boiler if any part has been under water. Immediately call a qualified •
service technician to inspect the boiler and to replace any part of the control system and
any gas control which has been under water.
Should overheating occur or the gas supply fail to shut off, do not turn off or disconnect •
the electrical supply to the pump. Instead shut off the gas supply at a location external
to the appliance. En cas de surchauffe ou si l’admission de gaz ne peut être coupée, ne
pas couper ni débrancher l’alimentation électrique de la pompe. Fermer plutôt le robinet
d’admission de gaz à l’extérieur de l’appareil.
This boiler has parts containing refractory ceramic fibers (RCF). See the safety •
information on the back of this manual if this boiler must be serviced or repaired.
Like all central heating appliances, this boiler is equipped with safety devices, which •
could cause it to shutdown, requiring service to restore normal operation. Where such
a shutdown could result in damage from low temperatures (such as frozen pipes), do
not leave the heating system unattended during cold weather unless alarms or other
safeguards are in place to prevent damage.
1
Phantom boilers use an electronic means built into the ignition system to extinguish the burner in the event that ames exit 3.
the combustion chamber. If the boiler fails to re, call a qualied gas service technician to diagnose and correct the problem.
Phantom boilers are equipped with a safety feature which will shut down the burner in the event that there is a blockage in 4.
the vent system. In the event that the boiler fails to function, and the boiler is vented through an outside wall accessible from
the ground, inspect the vent terminal on the outside wall for a blockage such as a bee’s nest or ice. If a blockage is found, the
burner should ignite approximately 30 seconds after the blockage is removed. If no blockage is found, or if the terminal is
inaccessible from the ground, the problem must be diagnosed and corrected by a qualied gas service technician.
WARNING
Asphyxiation Hazard. Explosion Hazard. Fire Hazard. Failure of the boiler to fire upon a call
for heat is usually the result of a potential safety issue (such as a blocked vent) that has
been detected by the control system. Call a qualified gas service technician to diagnose and
correct the problem.
II. Maintenance
1. On a continuous basis:
Keep the area around the boiler free from combustible materials, gasoline, and other ammable vapors and liquids.•
Keep the area around the combustion air inlet terminal and the area around the boiler free from contaminants, includ-•
ing all sources of hydrocarbons such as bleaches, fabric softeners, chemicals, sprays, cleaners, paints, paint removers,
refrigerants, and cat boxes. Traces of these chemicals can be drawn into the boiler, causing severe corrosion damage to
the boiler and/or objectionable odors.
Keep the boiler room ventilation openings open and unobstructed.•
Do not expose the boiler to large amounts of dust such as that generated by drywall construction or woodworking.•
2. On a monthly basis:
Inspect outdoor vent and combustion air intake terminals for obstructions, damage due to impact or other deterioration.•
Inspect vent and combustion air exterior wall penetrations to be sure they are weather tight.•
Inspect all vent and combustion air intake piping for cracks, loose joints, condensate leakage, sags in horizontal runs of •
pipe, corrosion, loose supports or other deterioration.
Inspect vent terminals, exterior of vent system and boiler exterior for carbon (soot).•
Inspect water, gas and condensate drain lines for leaks.•
Lift off front door and inspect visible controls, wiring and sheet metal components for deterioration. •
WARNING
If any of the conditions listed above are found, follow instructions “TO TURN OFF GAS TO
APPLIANCE” in Figure 1 and contact a qualified gas service technician to correct the problem
before placing the boiler back in service. Failure to correct these conditions could result in
property damage, personal injury or loss of life.
WARNING
Carbon (“soot”) in or near the vent system or boiler is an indication of a potential carbon
monoxide hazard. If carbon is found, immediately follow instructions “TO TURN OFF GAS TO
APPLIANCE” in Figure 1 and contact a qualified gas service technician to correct the problem
before placing the boiler back in service.
2
3. On an annual basis: Have a qualied gas service technician perform the inspection and maintenance described in Part XIII of
the Phantom Installation and Operating instructions.
NOTICE
This boiler has a heat exchanger made from a special stainless steel alloy which can be
severely damaged by frequent additions of water or by the addition of boiler water additives
which are not designed for use with stainless steel boilers. If it is necessary to add water to
the boiler, have a service technician check the system for leaks. Do not add any chemicals to
the boiler not listed in Section XI of the Phantom Installation and Operating Manual. Warranty
is void if the service and maintenance procedure shown in Section XIII of the Phantom
Installation and Operating Manual is not followed.
3
$OSLQH6HULHV/LJKWLQJDQG2SHUDWLQJ,QVWUXFWLRQV
Figure 1: Lighting and Operating Instructions
4
Important Product Safety Information
Refractory Ceramic Fiber Product
Warning:
This boiler may include parts that contain refractory ceramic fibers (RCF).
RCF has been classified as a possible human carcinogen. When exposed to
temperatures about 1805°F, such as during direct flame contact, RCF changes
into crystalline silica, a known carcinogen. When disturbed as a result of
servicing or repair, these substances become airborne and, if inhaled, may be
hazardous to your health.
AVOID Breathing Fiber Particulates and Dust
Precautionary Measures
:
Do not remove or replace RCF parts or attempt any service or repair work
involving RCF without wearing the following protective gear:
1. A National Institute for Occupational Safety and Health (NIOSH)
approved respirator
2. Long sleeved, loose fitting clothing
3. Gloves
4. Eye Protection
• Take steps to assure adequate ventilation.
• Wash all exposed body areas gently with soap and water after contact.
• Wash work clothes separately from other laundry and rinse washing
machine after use to avoid contaminating other clothes.
• Discard used RCF components by sealing in an airtight plastic bag. RCF
and crystalline silica are not classified as hazardous wastes in the United
States and Canada.
First Aid Procedures
:
• If contact with eyes: Flush with water for at least 15 minutes. Seek
immediate medical attention if irritation persists.
• If contact with skin: Wash affected area gently with soap and water.
Seek immediate medical attention if irritation persists.
• If breathing difficulty develops: Leave the area and move to a location
with clean fresh air. Seek immediate medical attention if breathing
difficulties persist.
• Ingestion: Do not induce vomiting. Drink plenty of water. Seek
immediate medical attention.
Manufacturer of Hydronic Heating Products
P.O. Box 14818 3633 I. Street
Philadelphia, PA 19134
www.crownboiler.com
CBC PN: 980126 Rev 0
Loading...