|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Ultrasonic direct detection sensor |
UB250-F77-F-V31 |
|||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Technical data |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
General specifications |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Sensing range |
35 ... 250 mm |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Dead band |
0 ... 35 mm |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Standard target plate |
20 mm x 20 mm |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Transducer frequency |
approx. 400 kHz |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Response delay |
≤ 50 ms |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Nominal ratings |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Time delay before availability tv |
≤ 150 ms |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Limit data |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Permissible cable length |
max. 300 m |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Indicators/operating means |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
LED yellow |
object inside the scanning range |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Electrical specifications |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Rated operating voltage Ue |
24 V DC |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Operating voltage UB |
20 ... 30 V DC , ripple 10 %SS ; 12 ... 20 V DC sensitivity |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
reduced to 90 % |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
No-load supply current I0 |
≤ 20 mA |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Input |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Input type |
1 program input |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Level |
low level : 0 ... 0.7 V (Teach-In active) |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
high level : UB or open input (Teach-In inactive) |
|
|
Model Number |
|
|
|
|
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
Input impedance |
16 kΩ |
|
||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
UB250-F77-F-V31 |
|
|
|
|
|
|
|
|
|
|
Pulse length |
≥ 3 s |
|
|||
|
|
|
|
|
|
|
|
|
|
|
Output |
|
|
||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Ultrasonic direct detection sensor |
|
|
|
Output type |
Frequency output , PNP |
|||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Rated operating current Ie |
100 mA , short-circuit/overload protected |
|
|
Features |
|
|
|
|
|
|
|
|
|
|
|
Resolution |
Standard 2 Hz / mm |
|||
|
|
|
|
|
|
|
|
|
|
|
|
Repeat accuracy |
± 2.5 % |
|
|||
|
• |
|
Miniature design |
|
|
|
|
|
|
|
|
|
|
||||
|
|
|
|
|
|
|
|
|
|
|
Off-state current Ir |
≤ 0.01 mA |
|
||||
|
• |
|
Frequency output |
|
|
|
|
|
|
|
|
|
Output frequency |
frequency : 70 ... 500 Hz ( 35 ... 250 Hz ) , adjustable |
|
||
|
|
|
|
|
|
|
|
|
|
|
Temperature influence |
+ 0.17 %/K |
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
|
• |
|
Program input |
|
|
|
|
|
|
|
|
|
|
Ambient conditions |
|
|
|
|
• Degree of protection IP67 |
|
|
|
Ambient temperature |
-25 ... 70 °C (-13 ... 158 °F) |
|||||||||||
|
|
|
|
Storage temperature |
-40 ... 85 °C (-40 ... 185 °F) |
|
|||||||||||
|
• Switching status indicator, yellow |
|
Shock resistance |
30 g , 11 ms period |
|||||||||||||
|
|
Vibration resistance |
10 ... 55 Hz , Amplitude ± 1 mm |
|
|||||||||||||
|
|
|
LED |
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Mechanical specifications |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Connection type |
M8 x 1 connector , 4-pin |
|
|
Diagrams |
|
|
|
|
|
|
|
|
|
|
|
|
||||
|
|
|
|
|
|
|
|
|
|
|
|
Degree of protection |
IP67 |
||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Material |
|
|
|
Characteristic response curve |
|
|
|
|
|
|||||||||||
|
|
|
|
Transducer |
epoxy resin/hollow glass sphere mixture; polyurethane foam |
||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Housing |
Polycarbonate |
|
|
Distance Y [mm] |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
Installation position |
any position |
||||
50 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Mass |
10 g |
|
||
40 |
|
|
|
|
|
|
|
|
|
|
|
|
|
Tightening torque, fastening screws |
max. 0.2 Nm |
||
30 |
|
|
|
|
|
|
|
|
|
|
|
|
|
Compliance with standards and |
|
|
|
20 |
|
|
|
|
|
|
|
|
|
|
|
|
|
directives |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
Standard conformity |
|
|
||
10 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
Standards |
EN 60947-5-2:2007 + A1:2012 |
|||
0 |
|
|
|
|
|
|
|
|
|
|
|
|
|
||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
IEC 60947-5-2:2007 + A1:2012 |
|||
-10 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
-20 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Approvals and certificates |
|
|
||
-30 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
UL approval |
cULus Listed, General Purpose |
|||
-40 |
|
|
|
|
|
|
|
|
|
|
|
|
|
||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
CSA approval |
cCSAus Listed, General Purpose |
|
||
-50 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
0 |
50 |
100 |
150 |
200 |
250 |
300 |
|
|
CCC approval |
CCC approval / marking not required for products rated |
|||||||
|
|
|
|
||||||||||||||
<![if ! IE]> <![endif]>eng.xml |
|
|
|
|
|
|
|
Distance X [mm] |
|
|
≤36 V |
||||||
|
|
|
|
|
|
|
|
|
Y |
X |
|
|
|
|
|||
<![if ! IE]> <![endif]>233260 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
<![if ! IE]> <![endif]>2016-02-12 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
<![if ! IE]> <![endif]>Date of issue: |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
<![if ! IE]> <![endif]>-02-12 14:50 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
<![if ! IE]> <![endif]>Release date: 2016 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Refer to “General Notes Relating to Pepperl+Fuchs Product Information”.
1
Ultrasonic direct detection sensor
Dimensions
12
<![if ! IE]><![endif]>31
<![if ! IE]><![endif]>18
<![if ! IE]> <![endif]>9 |
M8 x 1 |
23 |
3.2 |
<![if ! IE]> <![endif]>25 |
<![if ! IE]> <![endif]>22 |
|
|
<![if ! IE]> <![endif]>ø3.2 |
<![if ! IE]> <![endif]>3.2 |
|
<![if ! IE]> <![endif]>3 |
|
3 |
14 |
|
17 |
Electrical Connection
1
+UB 2
ET (Frequency selection)
4
Frequency output
3
-UB
Pinout
2 |
4 |
1 |
3 |
Wire colors in accordance with EN 60947-5-2
1 |
BN |
(brown) |
2 |
WH |
(white) |
3 |
BU |
(blue) |
4 |
BK |
(black) |
Refer to “General Notes Relating to Pepperl+Fuchs Product Information”.
UB250-F77-F-V31
<![if ! IE]><![endif]>Release date: 2016-02-12 14:50 Date of issue: 2016-02-12 233260_eng.xml
2