Pentair JUNG PUMPEN SIMER 5, JUNG PUMPEN SIMER 4 Instruction Manual
B 253PB550-10-1611 www.jung-pumpen.de
EN Instruction Manual
JUNG PUMPEN SIMER 5
2
ENGLISH
You have purchased a product made by
JUNG PUMPEN and with it, therefore,
also excellent quality and service. Secure
this service by carrying out the installation works in accordance with the instructions, so that our product can perform its
task to your complete satisfaction. Please
remember that damage caused by incorrect installation or handling will adversely
affect the guarantee.
Therefore please adhere to the instructions in this manual!
As with all electrical devices, this product
can also fail to operate due to an interruption in the electricity supply or due
to a technical defect. If this could result
in damage, a mains-independent alarm
system must be installed. Depending on
the application, you may also wish to install an emergency power generator, or a
second system as a back-up.
SAFETY
INSTRUCTIONS
This instruction manual contains essential information that must be observed during installation, operation and servicing. It is therefore
important that the installer and the responsible technician/operator read this instruction
manual before the equipment is installed and
put into operation. The manual must always be
available at the location where the pump or the
plant is installed.
Failure to observe the safety instructions can
lead to the loss of all indemnity.
In this instruction manual, safety information is
distinctly labelled with particular symbols. Disregarding this information can be dangerous.
General danger to people
Warning of electrical voltage
ATTENTION! Danger to equipment and operation
Qualification and training of
personnel
All personnel involved with the operation, servicing, inspection and installation of the equipment must be suitably qualified for this work
and must have studied the instruction manual
in depth to ensure that they are sufficiently
conversant with its contents. The supervision,
competence and areas of responsibility of
the personnel must be precisely regulated by
the operator. If the personnel do not have the
necessary skills, they must be instructed and
trained accordingly.
Safety-conscious working
The safety instructions in this instruction manual, the existing national regulations regarding
accident prevention, and any internal working,
operating and safety regulations must be adhered to.
Safety instructions for the
operator/user
All legal regulations, local directives and safety
regulations must be adhered to.
The possibility of danger due to electrical energy must be prevented.
Leakages of dangerous (e.g. explosive, toxic,
hot) substances must be discharged such that
no danger to people or the environment occurs.
Legal regulations must be observed.
3
ENGLISH
Safety instructions for installation, inspection and maintenance works
As a basic principle, works may only be carried out to the equipment when it is shut down.
Pumps or plant that convey harmful substances
must be decontaminated.
All safety and protection components must be
re-fitted and/or made operational immediately
after the works have been completed. Their effectiveness must be checked before restarting,
taking into account the current regulations and
stipulations.
Unauthorised modifications,
manufacture of spare parts
The equipment may only be modified or altered
in agreement with the manufacturer. The use of
original spare parts and accessories approved
by the manufacturer is important for safety reasons. The use of other parts can result in liability for consequential damage being rescinded.
Unauthorised operating methods
The operational safety of the supplied equipment is only guaranteed if the equipment is
used for its intended purpose. The limiting values given in the “Technical Data” section may
not be exceeded under any circumstances.
Instructions regarding accident prevention
Before commencing servicing or maintenance
works, cordon off the working area and check
that the lifting gear is in perfect condition.
Never work alone. Always wear a hard hat, safety glasses and safety shoes and, if necessary, a
suitable safety belt.
Before carrying out welding works or using
electrical devices, check to ensure there is no
danger of explosion.
People working in wastewater systems must
be vaccinated against the pathogens that may
be found there. For the sake of your health, be
sure to pay meticulous attention to cleanliness
wherever you are working.
Make sure that there are no toxic gases in the
working area.
Observe the relevant occupational health and
safety regulations and keep first aid materials
available.
In some cases, the pump and the pumping medium may be hot and could cause burns.
For installations in areas subject to explosion
hazards, special regulations apply!
This appliance can be used by children aged 8
years or over and by persons with limited physical, sensory or intellectual capabilities, or with
limited experience and knowledge, provided that
they are supervised or have been instructed in
the safe use of the appliance and are aware of
the dangers involved. Children must not be allowed to play with the appliance. Cleaning and
user maintenance must not be carried out by
children unless they are supervised.
Loading...