Peiker acustic PNADB User Manual
NAD6200 Network Access Device
Datasheet, Rev. 1.3
september, 2013
PEIKER acustic Confidential and Proprietary
________________________________________________________________________________________________________________________________________ Site 1
peiker acustic GmbH & Co. KG, Max-Planck-Straße 28-32, D-61381 Friedrichsdorf, Amtsgericht Bad Homburg HRA 1897
phG: peiker Verwaltungs GmbH, Vorsitzender der Geschäftsführung: Andreas Peiker, Geschäftsführer: Reinhard Kromer-von Baerle, Amtsgericht Bad Homburg HRB 1369
Vorsitzender des Aufsichtsrates: Dr. Helmut Rothenberger Ein Unternehmen der peiker Firmengruppe
Revision
Date
Chapter
Comment
1.0
13.5.2013
all
Release
1.1
17.7.2013
10
Insert chapter 10.2 Warning Statements
1.2
28.8.2013
10
Insert RF Exposure Warning and Notice
1.3
2.9.2013
10
Insert OEM responsibility to the FCC rules and regulations
Revision History
________________________________________________________________________________________________________________________________________ Site 2
peiker acustic GmbH & Co. KG, Max-Planck-Straße 28-32, D-61381 Friedrichsdorf, Amtsgericht Bad Homburg HRA 1897
phG: peiker Verwaltungs GmbH, Vorsitzender der Geschäftsführung: Andreas Peiker, Geschäftsführer: Reinhard Kromer-von Baerle, Amtsgericht Bad Homburg HRB 1369
Vorsitzender des Aufsichtsrates: Dr. Helmut Rothenberger Ein Unternehmen der peiker Firmengruppe
Index of contents
Abstract .................................................................................................................................. 9
1. Introduction ................................................................................................................... 10
1.1. Scope ............................................................................................................................. 10
1.2. References ...................................................................................................................... 10
1.3. Audience ......................................................................................................................... 10
1.4. Contact information, support ............................................................................................ 10
2. Overview of the NAD6200 – Module .............................................................................. 11
2.1. Key features .................................................................................................................... 11
2.2. Product variants and Approvals ......................................................................................... 13
3. Overview HW – Part ....................................................................................................... 14
3.1. Block – Diagram .............................................................................................................. 14
3.2. Pin description of the board to board connector ................................................................. 15
3.3. HW – Features ................................................................................................................ 17
3.3.1. W-WAN connectivity .................................................................................................. 17
3.3.1.1. GSM/EDGE ......................................................................................................... 17
3.3.1.2. UMTS/WCDMA ................................................................................................... 17
3.3.1.3. GNSS ................................................................................................................. 18
3.3.2. Detailed Pin description ............................................................................................. 18
3.3.2.1. Power Supply ..................................................................................................... 18
3.3.2.2. KPD_Power ........................................................................................................ 19
3.3.2.3. RES_IN .............................................................................................................. 19
3.3.2.4. VREG_MSME ...................................................................................................... 20
3.3.2.5. SIM Card ........................................................................................................... 20
3.3.2.6. USB ................................................................................................................... 21
3.3.2.7. GPIOs ................................................................................................................ 22
3.3.2.8. UART ................................................................................................................. 24
3.3.2.9. I²C .................................................................................................................... 24
3.3.2.10. I²S ................................................................................................................... 25
3.3.2.11. GPS Pins ........................................................................................................... 26
3.3.3. Antenna ................................................................................................................... 26
3.3.3.1. Antenna connector ............................................................................................. 26
________________________________________________________________________________________________________________________________________ Site 3
peiker acustic GmbH & Co. KG, Max-Planck-Straße 28-32, D-61381 Friedrichsdorf, Amtsgericht Bad Homburg HRA 1897
phG: peiker Verwaltungs GmbH, Vorsitzender der Geschäftsführung: Andreas Peiker, Geschäftsführer: Reinhard Kromer-von Baerle, Amtsgericht Bad Homburg HRB 1369
Vorsitzender des Aufsichtsrates: Dr. Helmut Rothenberger Ein Unternehmen der peiker Firmengruppe
3.3.3.2. Antenna Switching .............................................................................................. 27
3.3.3.3. Antenna diagnostics ............................................................................................ 28
3.3.4. Chipset MDM6200 + PM8028 ..................................................................................... 28
3.3.4.1. PM8028 ............................................................................................................. 28
3.3.4.2. MDM6200 .......................................................................................................... 28
3.3.5. Memory .................................................................................................................... 29
4. Application software ...................................................................................................... 30
5. Antenna characteristics ................................................................................................. 31
5.1. Electrical characteristics for the Antenna ............................................................................ 31
5.2. Electrical characteristics for the Bands ............................................................................... 31
5.2.1. Frequencies .............................................................................................................. 31
5.2.2. Power Consumption, Call ........................................................................................... 32
6. Environmental Specification .......................................................................................... 34
6.1. General information ......................................................................................................... 34
6.2. Temperature Range ......................................................................................................... 34
7. Mechanical Specification ................................................................................................ 35
8. Safety Recommendations according to EN60950-1 ....................................................... 36
9. Evaluation Kit ................................................................................................................. 37
10. Appendix ........................................................................................................................ 39
10.1. AT Command list .......................................................................................................... 39
10.2. Warning Statements ..................................................................................................... 40
________________________________________________________________________________________________________________________________________ Site 4
peiker acustic GmbH & Co. KG, Max-Planck-Straße 28-32, D-61381 Friedrichsdorf, Amtsgericht Bad Homburg HRA 1897
phG: peiker Verwaltungs GmbH, Vorsitzender der Geschäftsführung: Andreas Peiker, Geschäftsführer: Reinhard Kromer-von Baerle, Amtsgericht Bad Homburg HRB 1369
Vorsitzender des Aufsichtsrates: Dr. Helmut Rothenberger Ein Unternehmen der peiker Firmengruppe
Index of figures
Figure 1: Block diagram of NAD6200 module ....................................................................... 14
Figure 2: board to board pin connector ................................................................................ 16
Figure 3: Mating connector .................................................................................................. 16
Figure 4: Pin description of GSBIs ........................................................................................ 23
Figure 5: Antenna connectors .............................................................................................. 26
Figure 6: FAKRA HF Single connector ................................................................................... 27
Figure 7: FAKRA HF Dual connector ..................................................................................... 27
Figure 8: Mechanical dimensions of the NAD6200 module ................................................... 35
Figure 9: Mechanical dimensions of the NAD6200 module (top view) ................................. 35
Figure 10: Evaluation Kit for NAD6200 module .................................................................... 37
________________________________________________________________________________________________________________________________________ Site 5
peiker acustic GmbH & Co. KG, Max-Planck-Straße 28-32, D-61381 Friedrichsdorf, Amtsgericht Bad Homburg HRA 1897
phG: peiker Verwaltungs GmbH, Vorsitzender der Geschäftsführung: Andreas Peiker, Geschäftsführer: Reinhard Kromer-von Baerle, Amtsgericht Bad Homburg HRB 1369
Vorsitzender des Aufsichtsrates: Dr. Helmut Rothenberger Ein Unternehmen der peiker Firmengruppe
Index of tables
Table 1: References .............................................................................................................. 10
Table 2: Key features of NAD6200 - Module ......................................................................... 11
Table 3: Product variants ..................................................................................................... 13
Table 4: Pin description of the board to board connector .................................................... 15
Table 5: Features of the GPS ................................................................................................ 18
Table 6: Characteristics of GLONASS .................................................................................... 18
Table 7: nominal values of the NAD6200 - module .............................................................. 19
Table 8: Electrical characteristics of KPD_Power ................................................................. 19
Table 9: Electrical characteristics of RES_IN ........................................................................ 20
Table 10: Electrical characteristics of VREG_MSME.............................................................. 20
Table 11: Electrical characteristics of SIM Interface ............................................................ 21
Table 12: Electrical characteristics of USB Interface ............................................................ 21
Table 13: Electrical characteristics of GPIOs ........................................................................ 23
Table 14: Definition of High - and Low - Level for digital inputs and outputs ...................... 24
Table 15: Electrical characteristics of UART Interfaces ........................................................ 24
Table 16: Electrical characteristics of I²C ............................................................................ 25
Table 17: Electrical characteristics of I²S ............................................................................. 25
Table 18: Electrical characteristics of GPS Pins .................................................................... 26
Table 19: switch combinations ............................................................................................. 27
Table 20: Frequencies of supported WCDMA Bands for uplink ............................................. 31
Table 21: Frequencies of supported WCDMA Bands for downlink ........................................ 31
Table 22: Frequencies of supported GSM Bands (Uplink) ..................................................... 31
Table 23: Frequencies of supported GSM Bands (Downlink) ................................................ 31
Table 24: Power Consumption @ TA = +25°C, VPH_PWR = 3.8 V, P = 23 dBm ................... 32
Table 25: Power Consumption @ TA = +25°C, VPH_PWR = 3.8 V, P = 10 dBm ................... 32
Table 26: Power Consumption @ TA = +25°C, VPH_PWR = 3.8 V, P = 0 dBm ..................... 32
Table 27: Power Consumption @ TA = +25°C, VPH_PWR = 3.8 V, Single Slot .................... 32
Table 28: Idle current for GSM and WCDMA ......................................................................... 32
Table 29: Operating temperature range ............................................................................... 34
Table 30: AT Command list with description ........................................................................ 39
________________________________________________________________________________________________________________________________________ Site 6
peiker acustic GmbH & Co. KG, Max-Planck-Straße 28-32, D-61381 Friedrichsdorf, Amtsgericht Bad Homburg HRA 1897
phG: peiker Verwaltungs GmbH, Vorsitzender der Geschäftsführung: Andreas Peiker, Geschäftsführer: Reinhard Kromer-von Baerle, Amtsgericht Bad Homburg HRB 1369
Vorsitzender des Aufsichtsrates: Dr. Helmut Rothenberger Ein Unternehmen der peiker Firmengruppe
Index of abbreviations
3 GPP 3rd Generation Partnership Project
ADC Analog – Digital – Converter
DAC Digital – Analog - Converter
eCall Emergency Call
Gb Gigabit
GLONASS Global Satellite navigation system
GNSS Global Navigation Satellite System
GPIO General Purpose Input Output
GPRS General Packet Radio Service
GSBI General Serial Bus Interface
GSM Global System for Mobile Communications
HSDPA High Speed Downlink Packet Access
HSIC High Speed Inter – chip Interface
HSPA High Speed Packet Access
HSUPA High Speed Uplink Packet Access
HW Hardware
IC Integrated Circuit
I²C Inter –Integrated Circuit
I²S Inter-IC Sound Interface
LDO Low Drop-Out
Mbit/s Megabit per second
MPP Multi Purpose PIN
NAD6200 Network Access Device
QCT Qualcomm technology
PCM Pulse Code Modulation
PCB Printed Circuit Board
RF Radio Frequency
SDIO SD Input / Output
________________________________________________________________________________________________________________________________________ Site 7
peiker acustic GmbH & Co. KG, Max-Planck-Straße 28-32, D-61381 Friedrichsdorf, Amtsgericht Bad Homburg HRA 1897
phG: peiker Verwaltungs GmbH, Vorsitzender der Geschäftsführung: Andreas Peiker, Geschäftsführer: Reinhard Kromer-von Baerle, Amtsgericht Bad Homburg HRB 1369
Vorsitzender des Aufsichtsrates: Dr. Helmut Rothenberger Ein Unternehmen der peiker Firmengruppe
SMPS Switched Mode Power Supply
SPDIF Sony / Philips Digital Interface
SPI Serial Peripheral Interface
SIM Subscriber Identity Module
SSBI Single – wired Serial Bus Interface
SW Software
UART Universal Asynchronous Receiver Transmitter
UIM User Interface Module
UMTS Universal Mobile Telecommunications System
USB Universal Serial Bus
WCDMA Wideband Code Division Multiple Access
W-WAN Wireless Wide Area Network
________________________________________________________________________________________________________________________________________ Site 8
peiker acustic GmbH & Co. KG, Max-Planck-Straße 28-32, D-61381 Friedrichsdorf, Amtsgericht Bad Homburg HRA 1897
phG: peiker Verwaltungs GmbH, Vorsitzender der Geschäftsführung: Andreas Peiker, Geschäftsführer: Reinhard Kromer-von Baerle, Amtsgericht Bad Homburg HRB 1369
Vorsitzender des Aufsichtsrates: Dr. Helmut Rothenberger Ein Unternehmen der peiker Firmengruppe
Abstract
Peiker NAD 6200
- Network Access Device
- ERA – GLONASS / eCall enabled
Automotive Grade by Design
- 10 – Layer design for best possible EMC and RF characteristics
- At the PA – Area and the Antenna Connector – Area is nothing assembled on bottom side
- Components integrated for antennas diagnostics
- Temperature sensors included for temperature management of some parameters
Automotive Grade by Application
A 500 MHz clocked ARM11 application processor is part of the MDM6200 chipset:
- It contains all mandatory application software for ERA-GLONASS / eCall support
- The complete emergency call procedure as specified in ETSI standards and the EGTS protocol
are implemented
- Enables different license models for different UMTS data rates
Automotive Grade Characteristics
- Enhanced lifetime of the device (till 2020)
- GPS / GLONASS receiver and LNA integrated
- Operational temperature range -40°C to +85°C
- Shock resistance up to 200g
________________________________________________________________________________________________________________________________________ Site 9
peiker acustic GmbH & Co. KG, Max-Planck-Straße 28-32, D-61381 Friedrichsdorf, Amtsgericht Bad Homburg HRA 1897
phG: peiker Verwaltungs GmbH, Vorsitzender der Geschäftsführung: Andreas Peiker, Geschäftsführer: Reinhard Kromer-von Baerle, Amtsgericht Bad Homburg HRB 1369
Vorsitzender des Aufsichtsrates: Dr. Helmut Rothenberger Ein Unternehmen der peiker Firmengruppe
Ref.
Name
Comment
Revision
Date
1
ASP-162345-02
(samtec)
Board to board connector 40-pole
2
CLP-120-02-F-D-A-K-TR
(samtec)
Mating connector
3
4369.SMBA.1H10.009
(IMS Connector Systems
GmbH)
FAKRA HF dual connector
d
10.09.2007
4
4408.SMBA.1H10.009
(IMS Connector Systems
GmbH)
FAKRA HF single connector
b
30.01.2008
1. Introduction
1.1. Scope
This document gives an overview about electrical, functional and mechanical details of the peiker
NAD6200 module based on the Qualcomm chipset MDM6200 and PM 8028.
1.2. References
Table 1: References
1.3. Audience
Information how integrate the NAD6200 module in other applications.
1.4. Contact information, support
Peiker acustic GmbH & Co. KG
Max-Planck-Street 32
D – 61381 Friedrichsdorf
Web page: http:// www.peiker.de
E-Mail: info@peiker.de
________________________________________________________________________________________________________________________________________ Site 10
phG: peiker Verwaltungs GmbH, Vorsitzender der Geschäftsführung: Andreas Peiker, Geschäftsführer: Reinhard Kromer-von Baerle, Amtsgericht Bad Homburg HRB 1369
peiker acustic GmbH & Co. KG, Max-Planck-Straße 28-32, D-61381 Friedrichsdorf, Amtsgericht Bad Homburg HRA 1897
Vorsitzender des Aufsichtsrates: Dr. Helmut Rothenberger Ein Unternehmen der peiker Firmengruppe
Feature
Processors
Application Processor: ARM1136 + L2 cache at 480 MHz
Modem DSP: QDSP4000 processor at 147.5 MHz
Application DSP: QDSP4000 processor at 162 MHz
Memory
512 Mb 16 bit DDR SDRAM
1 Gb NAND flash
GSM,GMSK,EDGE
GSM850,900 Class 4 (2W)
GSM1800, 1900 Class 1 (1W)
EDGE850, EDGE900 Class E2 (0.5W)
EDGE1800, EDGE1900 Class E2 (0.4W)
GPRS/EDGE Multi slot class 12
DTM Multi slot class 11
WCDMA, HSDPA,
HSUPA
BC1, 2, 5, 6, 8 Class 3 (0.25W)
HSDPA CAT 10 (14.4Mbps)
HSUPA CAT 6 (5.76Mbps)
GNSS
GPS
Glonass
Antenna
functions/interface
Connector for one main antenna
Connector for one backup antenna
Optional connector for one GPS antenna
Antenna diagnostics
Interfaces
USB2.0 HS
UIM
SPI
I²C
UART
Digital Audio1
Data
Communication
CSD analog (V.32/V.34) and digital (V110) with 2.4/4.8/9.6/14.4 kbit/s
Packet switched data
PPP-Stack
SMS:
- Point-to-Point MT and MO
- Text and PDU mode (“binary-SMS”)
- transmission of SMS alternatively over CSD and GPRS
- Support of MO/MT SMS parallel to circuit switched (voice/data)
- Packet switched data connections
Software
Firmware and application software independently updatable.
Power supply
Single power supply 3.8 V
2. Overview of the NAD6200 – Module
This chapter gives a general overview of approvals, functionality and product variants of the NAD6200
module.
2.1. Key features
Table 2: Key features of NAD6200 - Module
1
I²S
________________________________________________________________________________________________________________________________________ Site 11
phG: peiker Verwaltungs GmbH, Vorsitzender der Geschäftsführung: Andreas Peiker, Geschäftsführer: Reinhard Kromer-von Baerle, Amtsgericht Bad Homburg HRB 1369
peiker acustic GmbH & Co. KG, Max-Planck-Straße 28-32, D-61381 Friedrichsdorf, Amtsgericht Bad Homburg HRA 1897
Vorsitzender des Aufsichtsrates: Dr. Helmut Rothenberger Ein Unternehmen der peiker Firmengruppe
Thermal functions
Operating Temperature: -40 °C to +85 °C2
Additional
operations
DTMF after dialing
DTMF configurable
Multiple PDP contexts
Echo Cancellation / Noise suppression VDA Class 2a fulfilled
Speech codecs:
- Half rate EFR
- Full rate FR
- Enhanced Full rate EFR
- Adaptive Multi – Rate AMR
2
: Automotive ambience fulfilled
________________________________________________________________________________________________________________________________________ Site 12
phG: peiker Verwaltungs GmbH, Vorsitzender der Geschäftsführung: Andreas Peiker, Geschäftsführer: Reinhard Kromer-von Baerle, Amtsgericht Bad Homburg HRB 1369
peiker acustic GmbH & Co. KG, Max-Planck-Straße 28-32, D-61381 Friedrichsdorf, Amtsgericht Bad Homburg HRA 1897
Vorsitzender des Aufsichtsrates: Dr. Helmut Rothenberger Ein Unternehmen der peiker Firmengruppe
Variant
GSM –
Quad Band
Band 1
Band 2
Band 5
Band 63
Band 8
GPS &
Glonass
GCF4
PTCRB5
MNO
Approval
Country
Approval
EU6 X X X Yes
n/a
Vodafone
R&TTE
NA7 X X X n/a
Yes
AT&T
Rogers (in
progress)
FCC
FCC
China
X
X Yes
n/a
China
Unicom
SRRC, CCC,
NAL
APAC8
X
X X X X ??
n/a
Vodafone
In progress
EU6 +
GNSS
X
X X X Yes
n/a
Vodafone
R&TTE
NA7 +
GNSS
X
X X X n/a
Yes
AT&T
Rogers (in
progress)
FCC
FCC
China +
GNSS
X
X X Yes
n/a
China
Unicom
SRRC, CCC,
NAL
APAC8 +
GNSS
X
X X X X X ??
n/a
Vodafone
In progress
2.2. Product variants and Approvals
Table 3: Product variants
3
: It is a part of Band 5.
4
: Weblink to the Webpage of GCF: http://www.globalcertificationforum.org/
5
: Weblink to the Webpage of PTCRB: http://www.ptcrb.org/
6
: Germany, Benelux, Italy, Spain, France, Austria, Denmark, Czech Republic
7
: USA, Canada
8
: Japan, Singapore
________________________________________________________________________________________________________________________________________ Site 13
peiker acustic GmbH & Co. KG, Max-Planck-Straße 28-32, D-61381 Friedrichsdorf, Amtsgericht Bad Homburg HRA 1897
phG: peiker Verwaltungs GmbH, Vorsitzender der Geschäftsführung: Andreas Peiker, Geschäftsführer: Reinhard Kromer-von Baerle, Amtsgericht Bad Homburg HRB 1369
Vorsitzender des Aufsichtsrates: Dr. Helmut Rothenberger Ein Unternehmen der peiker Firmengruppe
Loading...