Page 1
Cancels: New OMOI 56
11/15/97
NOTE TO INSTALLER:
This manual should be left with the equip-
ment owneF.
PAIZ Packaged Air Conditioner
Page 2
WELCOMETO EFFICIENT COOLING COMFORT
Congratulations on your excellent choice and sound invest-
ment in home cooling comfort!
Your new air conditioner represents both tile latest in engi-
neering development and the cuhnination of many years of
experience fl'om one of the most reputable manufacturers of
comfort systems.
Your new unit is among the most energy efficient and reli
able air conditioning products available today. To assure its
dependability, spend just a few minutes with this booklet now.
Learn about the operation of your air conditioner and the small
amount of maintenance it takes to keep it operating at its
peak efficiency.
With minimal care, your air conditioner will provide you and
your family with satisfying home comfort -- both now and
for" years to come.
IMPORTANT FACTS
To better protect your investment and to eliminate unneces-
sary service calls, familiarize yourself with the following facts:
• Your air conditioning system should never" be operated with
out a clean air filter properly installed. Plan to inspect the
filter periodically. A clogged air filter will increase operat-
ing costs and shorten the life of the unit.
• Supply-air and return-air registers should not be blocked.
Drapes, fllrniture, and toys are some of the items com-
monly found obstructing grilles. Restricted airflow lessens
the unit's efficiency and life span.
• Outdoor units must have unrestricted airflow. Do not cover
the unit, lean anything against it, or stand upon it. Do not
allow grass clippings, leaves, or other debris to accu-
mulate around or on top of the unit. Maintain a 12 in. mini
mum clearance between tire outdoor unit and tall grass,
vines, shrubs, et cetera.
• Your multipurpose indoor thermostat is the control center
for your air conditioning system. You should familiarize your
self with its proper operation. Attempting to control the
system by other means for" instance, switching the elec-
trical supply power ON and OFF -- may cause damage to
the unit.
• Thermostat '_jiggling" causes rapid cycling, which is poten
tially damaging to the compressor. Do not move the tern
perature selector on the thermostat for" any reason for at
least 5 minutes after the compressor has shut off.
• You may find that you can maintain greater personal com-
fort by running tile fan continuously. "Air pockets" can form
due to the structure of the building, placement of regis
ters, et cetera. These air pockets may be too cool or warm
for your liking. Continuous fan operation minimizes any
temperature differences. Also, systems equipped with elec-
tronic air cleaners and/or humidifiers offer" the added ben
efits of having the air continuously cleaned year round, and
humidified during the winter season.
• Your air conditioner will remove humidity fl'om your home
during tire cooling season. After a few minutes of opera
tion, you should be able to see water trickle from the
condensate drain of the cooling coil. Check this occasion-
ally to be sure the drain system is not clogged. Of course,
do not expect to see much drainage if you live in a very dry
environn]ent.
OPERATING YOUR AIR CONDITIONER
The operation of your air conditioning system is controlled
by the indoor thermostat. You simply adjust the thermostat
and it maintains the indoor" temperature at the level you se-
lect. Most thermostats for air-conditioning systems have three
controls. These are the temperature control selector, FAN switch,
and SYSTEM switch.
The temperature control selector is a dial or lever" that al
lows you to establish the degree of temperature that you wish
to maintain for your personal comfort. Some thermostats pos-
sess two temperature control selectors: one for"setting the tern
perature desired during the cooling cycle, and one to set tile
heating operation temperature (if tile accessory electric heater
is used). Typical settings are 78 degrees Fahrenheit for" cool-
ing and 68 degrees for heating.
The FAN switch offers two options for controlling tire blower:
AUTO and ON. When set to AUTO, the blower will run
during the time the air conditioner is operating. When the
FAN switch is set at the ON position, the blower will run
continuously.
Typically, the SYSTEM switch on your thermostat offers the
following selections: COOL, OFF, and HEAT. Your thermo-
stat may also have a fourth selection, AUTO. The air condi-
tioner will not operate when the SYSTEM switch is set at
the OFF position. With the SYSTEM switch set at COOL,
the cooling section of your comfort system will operate when
the indoor" temperature rises above the level that you wish to
maintain. With tire SYSTEM switch set at the HEAT posi
tion, the accessory electric heater will operate automatically
whenever the indoor" temperature falls below the level that
you have selected.
The AUTO selection found on some thermostats provides for
automatic changeover between cooling and heating cycles. With
the SYSTEM switch set in the AUTO position, the cooling
mode is activated when the indoor temperature rises above
the thermostat cooling temperature setting, or the heating
mode will be activated when the indoor temperature drops
below the thermostat setting for" the heating cycle.
I. COOLING CYCLE
When operating in the cooling cycle, your air conditioner will
run until tile indoor" temperature is lowered to the level you
have selected. On extremely hot days, your air conditioner
will run for" longer periods at a time and have shorter "off'
periods than on moderate days.
The following are typical conditions that add extra heat and/or
humidity to your home. Your air conditioner will work longer
to keep your home comfortable under these conditions:
• Entrance doors are frequently opened and closed
• Laundry appliances are being operated
• A shower is running
• More than the usual number of people are present in the
home
• More than the normal number of electric lights are in use
• Drapes are open on the sunny side of the home
2
Page 3
II. HEATING CYCLE
If you own a packaged air conditioner that includes electric
heat as an accessory, you need only program your thermostat
for heating.
With the SYSTEM switch of your indoor thermostat set to
the HEAT position, tire heating section of your home comfort
system will operate until room temperature is raised to the
level you have selected. Of course, the heating unit will have
to operate for longer periods to maintain a comfortable envi-
ronment on colder days and nights than on moderate ones.
PERFORMING ROUTINE MAINTENANCE
With the proper maintenance and care, your air conditioner
will operate economically and dependably, Maintenance can
be accomplished easily by referring to the following direc
tions. However. before performing maintenance, consider these
important safety precautions:
overheat and automatically shut down. In the extreme, the
components will fail and need to be replaced, To avoid inefi
ficient or failed operation of your unit, CHECK THE FIE
TER(S) EVERY 3 TO 4 WEEKS. Replace filter(s) when nec-
essary, or clean the filter(s) if you have the reusable type.
Disposable filters should be replaced by similar, new filters
of the same dimensions,
Reusable, permanent filters should be washed in a solution
of cold water and mild detergent, then rinsed and thoroughly
dried. THE FILTER MUST BE COMPLETELY DRY BE
FORE BEING REINSTALLED. To avoid prolonged shut
down of your unit while a filter is drying, you should have an
extra filter on hand. This would allow you to rotate between
the two with minimal downtime for" your comfort system. Ex-
tra filters may be purchased fl'om your dealer'.
The filter(s) and filter rack fox" a packaged system are sup
plied and installed by the contractor or dealer. Typically, the
filter(s) and rack are located in the return-air duct at the out-
door unit or behind the return air grille(s). Have your dealer
show you the location of your filter(s) and the procedures for"
removal and replacement.
If you have any questions about the removal and/or cleaning
of your filter(s), contact your dealer fox" assistance.
If grass clippings, leaves, shrubbery, and debris are kept away
fl'om the unit, minimal care should be sufficient to keep the
system flmctioning properly. However, if the outdoor coil be-
comes dirty, use a brush or vacuum cleaner and soft brush
attachment to clean the exterior surface. If dirt is deep in the
coil. contact your dealer for service. The outdoor fan motor
may have to be disconnected and the top panel removed to
gain access to the coil for thorough cleaning. Do not attempt
this yourself.
II. UNIT SUPPORT
Your packaged unit should be maintained at a level position.
If its support should shift or settle so that the unit is no longer
level, you should correct the condition, Relevel it promptly to
assure condensate drainage out of the unit. If you notice that
water or ice collects beneath the unit, arrange for it to be drained
away fl'om the unit.
MAIN
ON
I
I
I. CHECK THE AIR FILTER
A dirty air filter will cause excessive strain on the compres
sor and blower motor. This can cause the components to
BEFORE YOU CALL FOR SERVICE, CHECK FOR THESE
EASILY SOLVED PROBLEMS
Check the indoor and outdoor disconnect switches, Verify that
circuit breakers are ON.
Check for sufficient airflow. Check the air filter(s) for any ac-
cumulations of dirt. Check for blocked return air or supply
air grilles. Be sure grilles are open and unobstructed,
Check the settings on your indoor thermostat. If you desire
cooling, see that the temperature control selector is set below
room temperature and the SYSTEM switch is on the COOL
or AUTO position. If you require warmth, be sure the tern
perature control selector" is set above room temperature and
the SYSTEM switch is at HEAT or AUTO. The FAN switch
should be set at ON for continuous blower" operation or AUTO
if you wish the blower to function only while the unit is
operating.
If your conffort system still fails to operate, contact your ser-
vicing dealer for troubleshooting and repairs. Specify your ap-
parent problem, and state the model and serial numbers of
your equipment. (You should have them recorded on page 4
of this booklet.) With this information, your dealer may be
able to offer helpfid suggestions over the phone, or save yah>
able time through knowledgeable preparation for the service
call.
--3--
Page 4
REGULAR DEALER MAINTENANCE
In addition to the routine maintenance that you perform, your
home comfort system should be inspected regularly by a prop-
erly trained service technician. The inspection (preferably each
year, but at least every other year) should include the
following:
• Routine inspection of air filter(s). Replacement or cleaning
as required.
• Inspection and cleaning of the blower wheel, housing, and
motor. Service should include proper lubrication of these
conlponents.
• Inspection and, if required, cleaning of indoor (evaporator)
and outdoor (condenser) coils.
• Inspection of the indoor coil drain pan, plus the primary
and secondary drain lines. Service should include cleaning
if required.
• A check of all electrical wiring and connections.
• A check for secure physical connections of individual corn-
ponents within units.
• Operational check of the air conditioning system to deter-
mine actual working condition. Necessary repair and/or
adjustment should be performed at this time.
WARRANTIES
The PAIZ units have a warranty located at the back of this
book. Be sure to read the warranty careflrlly to determine the
coverage for your unit.
FOR THE RECORD
Record the model, product, and serial numbers of your new
equipment in the spaces provided below. This informa-
tion, along with the other" ready-reference facts requested be-
low, will be necessary should you ever require information or
service.
INSTALLATION DATA
Date Installed
Dealer Name
Address
City
State
Telephone
UNIT DATA
Product No.
Model No.
Serial No.
Heater, if applicable:
Part No.
Kilowatt Rating
Zip
--4--
Page 5
DETACH & MAIL PRODUCT REGISTRATION CARD _-_ STAPLE OR TAPE HERE
I
IMPORTANT: Complete, detach and mail immediately for...
PRODUCT REGISTRATION
THE FEDERAL CONSUMER PRODUCT SAFETY ACT REQUIRES THAT YOU BE NOTIRED OF ANY RECALLS INVOLV-
ING THIS PRODUCT. YOUR NAME AND AODRESU AND THE MODEL AND SERIAL NUMBERS OF YOUR PRODUCT
WILL ASSIST US IN NOTIFYING YOU SHOULD THE NEED ARISE,
Your warranty coverage is not dependent upon the return of this card.
1. 1. E] Mr. 2. O Mrs. 3. [] Ms, 4. O Miss
Name (Fffst/IniRal!Last)
I I I I I I I I I I i I I I I I I I I I I L I
Street
t I I I I I I I I I I I I I I I ! t I I I I I I I I I
City Slate Zip
I I I I I I I I I t I I I I I I I I I I L I I I I I I
I t f I I F i I I I I I I I I I I I I I I I L I I t I I
MODEL NO. (Copy from rating plate on unit.) SERIAL NO.
2. DATE INSTALLED / /
Me, Day Yr,
$. What producl did you purchase?
1. O CentraJ aircondiUoner
2. 1:3 Gasfurnace
3. [30IIturnace
4 E3 Electric furnace
5. U Heat pump
4. When did you acquire your product?
t. [] Uponpurchaseof new dwelling
2. [] Toreplaceanoldersystemmanufacturedbyour
company
3. [] Toreplaceanoidersystemmanufacturedbya
c_mpetitor
4. [] Withinayearofbuyingnewdwelllngwithno
central air system
5. [] 2-4 years after buying dwelling with no eentraI air
syslem
8, WhiCh rd the Iollowing have you done in the paslt 6
months? (check all that apply)
1. _ Redeemed a product coupon
2. (_ Ordered an item from mail order catalog
3. _ Sent in product inquiry card from magazine
4. [] Uc*ught an Item from offer reoeived in mall
5. [] Entered sweepstakesleont@st
9. In which age group are you?
1. _ 18-24
2. [] 25-34
3. [] 35"44
4. _ 45-54
5. _ 55-64
6. [] 65 & over
6. O Over 4 years after buying dwelling with no central 10. Madfal status:
air syst_ 1. O Married 2. [] Unmarried
5. If this was a reptueement product, how old was the
original?
1. _ 1-5years
2. LJ 6-eyears
3. _ 9*11years
4. [] 12-14yeals
5. L3 15-17years
6. FI 18&overyears
6. Your product is Ilmtalled in?
1. F1 Singlefamlly/Townhouse
2. E3 Multi-family: 2-4
3. [] Mobllehome
4. _ ApaJrtrnent: 1.3 floors
5. [3 Apartment: 4 + floors
6. [] Office/Bank
7. [7 Store
8. r9 Hospital/School
9. [3 Manufacturing building
10. LJ Other
7, What 2 factors most influenced your purchase?
1. _ Our reputation
2, [] Friend's recommendation
3, _ Contractor/Dealer's recommendation
4, _ Price
5. ZI Er=ergy efficiency
6. _ Ready availability
7, [] Radio ads
8. E] T.V. ads
g. [] Newspaper ads
10. _ Magazineeds
11, _ Dealerdisplay
,=
-1-
o
LL
11. WhIQh group best describes your family income?
1. f3 Under$10.00o 6. [3 $30,000534,999
2. [] $10.000-$14,999 7. r9 $35.000.$39,999
3. [] $15.0G_$1g,999 8. 1_ $40_000-$44,999
4. [] $20.000_$24.999 9. L_ $45,000-$49,999
5. [] $25,000529.999 10. 1_ $50,000 & over
12. DO you have any children in any of the fallowing age
groups who are living at home?
1. O Underage2 5. O Age11-12
2. [] Age_4 6. E3 Age13-15
3. F3 AgeS-7 7. 13 Age16-18
4. O Agee-lO
13. For your primary residence, do you:
t. _ Ownahouse?
2. _ Rent a house?
3. "30wnatownhouSe.lcendominium?
4. [] Rent an apartment?
14. Which of the following typos 04 credit cards do you usa?
t, [7 TravelfEntett_inrnenl (AmericP.n Express, Diners
Club, Carte Blanche)
2. [] Uank(MasterCharge, Visa)
3. LJ Gas, _epartmenl store, etc.
iS, What is your occupation? (check one)
1. _ Prntes@ional/Tenhni_al
2 _7 Upper Mgi/Administrator
3. _ Sales/Service!Middle Mgt.
4. O Clerical/WhiteCollar
5, O CraffsmanlBlue Collar
6. D Student
7. _ Housewile
8 _ Retired
16. WhiCh of the following interests and hobbies do you and
your family enjoy?
1. [] Tennis
2. [] Goll
3. [] Snow Skiing
4, _ Running/Jogging
5. _ Camping/Hiking
6. [] Hunting/Shooting
7. O Fishing
8. 1:7 Bicycling
9. [] Racquetball
10. _ Sailing/Boating
lf. [] Stamp/Coin Collecting
12. E3 Mo_orbikingiMotorcycling
13. [7 HomeVideeGames
14. [] Physical FitnasstRxerclse
15. [] Home Video Re_gordlng
16. [] RecreationeiVehiole/4-WD
17. [] Photography
18. O CU Radio
19. _ HomeWorkshogiDoJI-Yourself
20. _ Gardening/Plants
21. _ E_ectrenies
22. _ AutomoUveWork
23. _ Sewing/Needlework
24. _ Crafts
25. [9 CollectibldstColleclions
26. [] Art&Antiques
27. LJ StereoMusicEquipment
28, L_ Foreign Travel
29. [] Attending CulturaUArts Events
30. _ Gourmet FoodstCooking
31 _ HealtdlNatural Foods
32. _ Wines
33, LJ Fashion Clothing
34. £3 Home FurnishingslDecoratin_
35. [3 Records & Tapes
36, O Avid Book Reading
37. [] Ucienee Fiction
38. [] AstrologylOccult
39. O Stol:k/Bond Investments
40. [3 Real Estate I_vestments
4t. [7 Self Improvement Programs
42 [] Communtty/CivicActivities
We app_ctat • your taking the time to complete this Pardi the
irdormaUon provided wRI help us sen_a you better in the
future. We participate in a multi.company program whereby
you can receive intormntion about new products, develop-
merits, Pre.ds, etc. refuted 1o the interest areas and ofhe[
information you have indicated above. Please chech here U
you would prefer not to learn about such products and
services. []
Other comments U suggestions about our product:
Fold Here
PLACE
FI RST CLASS
STAMP
HERE
CAC/BDP
Product Registration Center
P.O. Box 173246
Denver, Colorado 80217
Page 6
Page 7
<=_
<=_
<=_
<=_
<=_
<=_
<=_
<=_
<=_
<=_
<=_
<=_
<=_
<=_
<=_
<=_
<=_
<=_
<=_
<=_
<=_
<=_
c
<=_
<=_
<=_
<==_
MODEL PAIZ WARRANTY
PAYNE BRAND
FOR SERVICE OR REPAIR, FOLLOW THESE STEPS IN ORDER:
FIRST: Contact the installer. You may find his name on the product or in your
User's Manual. If his name is not known, call your builder if yours is
a new residence.
SECOND: Contact the nearest distributor. (See telephone yellow pages.)
THIRD: Contact:
Payne Co.
Consumer Relations
P.O. Box 4952
Syracuse, New York 13221
Phone: 1-888-41PAYNE (888-417-2963) (TOLL FREE) from U.S.A.
1-315-432-7885 from Canada
Model No. Unit Serial No.
Date of Installation Installed by
Name of Owner Address of Installation
OUTDOOR COOLING, HEATING-COOLING, OR HEATING PRODUCT
(Units Smaller Than 185.000-Btu_ Cooling Capacity)
LIMITED WARRANTY
UIBTED 1-YEAR WARRANTY--This CARRIER CORPORATION (herein after reterred to as 'COMPANY') product iswatramed to be free from deleots in material end workman-
ship underfiormal use and maintenance for a period of 1 year from the date oforiginalisstaL_Sen whethe_ or not actual use beginson that date. A new Orrentenufadiursd part, at
the CaM PANY'S sole option, to replace any defective part wil_beprovided, within a reasonable time after rotum ofthe defective part,without charge for the part itse_ PROVIDED
the dafec_ve part is ratumed to our distributor through a qualified servicing dealer. The replacement part assumes the unused portion of the warranty.
THIS WARRANlrY DOES NOT II_LU DE LABOR OR OTHER COSTS incurred for diagnosing, rebelr_0, removing, installing, Shipping, servicing or haedllag of either defective
parts or repiacement bens or comp_e_ unit. Such costs may be covered by a separate warcaotyprovid_ by _ installer.
_OED LIMITED/.-YEAR WARRANTY ON COMPRESSOR ONLY -- During the second through tilth years alter the date of origthal i_daliatios, the COMPANY further war-
rantsthe coml:_essoragainst defects in material at workmanship under nmmal use and malaten_nce. A new o¢ temanufactmecl coml::i_ssor, at 111oCOMPANY'S sole option, will
be provided under the san_ conditions as stere0 in the 1-YEAR WARRANTY.
THIS EXTEI_DED WARRANTY DOES NOT INCLUOE LABOR OR OTHER COSTS inoJrred for diagnosing, repairing, removing, installing,shipping, servicing Orhandling of al_et
_lefent;ve parts or replacement parts.
THESE WARRANTIES APPLY ONLY TO PRODUCTS IN THEIR ORIGINAL INSTALLATION LOCATION AND BECOME VOID UPON REINSTALLATION.
U MITATIONS OF WARRANTIES---ALL IMPMED WARRANTIF.S_(INCLUOING IMPLIED WARRANTIES OF MERCHANTABILITY) ARE HEREBY UMITED IN DURATION TO THE
PERIOD FOR WHICH THE MMrrED 1 YEAR WARRANTY IS GWEN. SOME STATES CO NOT ALLOW UMITATIONS ON HOW LONG AN IMPLIED WARRANTY LASTS. SO THE
ABOVE MAY NOT APPLY TO YOU. THE EXPRESSED WARRANTIES MADE INTHIS WARRANTY ARE EXCLUSIVE AND MAY NOT BE ALTERED, ENLARGED, OR CHANGED
BY ANY DISTRIBUTOR, DEALER, OR OTHER PERSON WHATSOEVER.
ALL WORK UNDER THE TERMS OF THIS WARRANTY SHALL BE PERFORMED DURING NORMAL WORKING HOURS. ALL REPLACEMENT PARTS, WHETHER NEW OR
REMANUFACTURED, ASSUME AS THEIR WARRANTY PBRiCO ONLY THE REMAINING TIME PERIOD OF THIS WARRANTY
THE COMPANY WILL NOT BE RESPONSIBLE FORt
1. Normal malnte_arme as ouffined ltl the instotlalton end servinthg inalxuotions Orowners menuat incfudlng¢oil c_osning,ltfter clsening andlor replacemnt andfubricatlt:_n.
2. Damage or repairs required as a consequence of teuity insteltet_on, misepp_ica'_or_,abuSe, improper servicing, unamberized altera_on or intpreper operation.
3. Failure to startdue to voltage condi_oos, blown fuses, open circuit breakers or other damages (:lueto the iNadequanyor interruption of e]ectrtcal service.
4. Damage as aresuit of floo_s, winds, fires. _ightning, accidents, corrosive environments Or other con¢iltionsbeyond the o0r_ol of the COMPANY
5. Parts not supplied or designated by the COMPANY, at damages resulting from their use.
6. COMPANY produots installed outside the continental U.S.A., Alaska, Hawaii and Canada.
7. Electr_ or fuel costs or incrosses in aleotricity or fuel costs fro_ any _osson whatsoever includingadditional Or unuSUal uSe of supplemental elec_ic heal
8. ANY SPECIAL INDIRECT OR CONSEQUENTIAL PROPERTY OR cam MERC_L DAMAGE OF ANY NATURE WH.=.TSOEVER. Some states do not a_w _ exclusi_ Of
in¢ide_ or ¢o.sequenltat dsn_gos, so the above limitation may not appiy to you.
This wanaoty gives you spacftk= legat rights, aed you may alse have other rigltts which ve_3tfrom m to m.
Effective on product manufactured after July 1,1987. Supersedes any other warranty c_rdficatss supplied withthe pteduct.
_=>
_:>
===,
_==:>
_=>
_===>
_=>
_=>
_:>
_:>
_:>
_=>
_=>
--7--
Page 8
Copyright 1997 Carrier Corporation CATALOG NO 53PA-1Z2
Loading...